IllustrationDT: THE CONSUMER WAS DRIVING AND HEARD A LOUD BANG ON THE PASSENGER SIDE. SHE EXITED THE VEHICLE AND CHECKED IT AND EVERYTHING SEEMED FINE. AS THEY ACCELERATED SMOKE STARTED COMING FROM THE ENGINE. CONSUMER EXITED THE VEHICLE AND WAS WALKING AWAY FROM IT TO CALL FOR HELP WHEN IT BURST INTO FLAMES. *NM
2002 Nissan Altima
Owner reports · Recalls · Investigations
More warning signs than most Altima years
Owner complaints for the 2002 Nissan Altima are substantially higher than the model-year median of 231.
About this comparison →How this year compares
Owner complaints by model year
Compare all Altima years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
7425–50K
12150–75K
23575–100K
239100–150K
60150K+
801 reports with mileage · 246 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 594 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports28 fire reports23 injury reports
Engine And Engine Cooling complaints
594 reportsMY CAR HEATING SYSTEM WAS NOT FUNCTIONING PROPERLY AND THEN MY CAR HAD OVERHEATED. MECHANIC SAID THERE WAS A LEAK IN THE RADIATOR WHICH CAUSED MY CAR TO OVERHEAT CAUSING A CRACK IN MY ENGINE. CAR IS ONLY 3 YEARS OLD WITH 75,781 MILES.
ENGINE SHUTDOWN AND THE CAR STOPPED SUDDENLY AT 70MPH ON A HIGHWAY. CAR WAS RESTARTED BUT QUICKLY SHUTDOWN AGAIN WHEN TRYING TO RETURN TO HIGHWAY SPEED. MANAGED TO PULL OVER, BUT WHEN TRYING TO SHIFT INTO PARK THE TRANSMISSION GOT STUCK IN REVERSE AND THE CAR WOULD NO LONGER MOVE. CAR HAD TO BE TOWED TO DEALER AND IS BEING LO…
Read full complaint
ENGINE SHUTDOWN AND THE CAR STOPPED SUDDENLY AT 70MPH ON A HIGHWAY. CAR WAS RESTARTED BUT QUICKLY SHUTDOWN AGAIN WHEN TRYING TO RETURN TO HIGHWAY SPEED. MANAGED TO PULL OVER, BUT WHEN TRYING TO SHIFT INTO PARK THE TRANSMISSION GOT STUCK IN REVERSE AND THE CAR WOULD NO LONGER MOVE. CAR HAD TO BE TOWED TO DEALER AND IS BEING LOOKED AT. CAR HAS A RECENT HISTORY OF STALLING 1 SECOND AFTER COLD START, INCLUDING AT LEAST ONCE WHEN THE CAR LUNGED FORWARD AS IT STALLED WHILE STILL IN PARK. PRIOT TO THIS SHUTDOWN, THE DEALER WAS NOT VERY COOPERATIVE AND HAD ONLY FOUND TWO SETTINGS OUT OF SPEC IN THE ENGINE MANAGEMENT SYSTEM AND RESET THEM (TWICE, 2 DAYS APART).
THE CONSUMER STATED A NEW ENGINE WAS PLACED IN THE CAR IN NOVEMBER, THEN TWO MONTHS LATER, IT NEEDED A NEW DRIVESHAFT, AND CURRENTLY NEEDS MOTOR MOUNTS. THERE WAS A MOVING SENSATION WHEN FIRST TAKING OFF. WHEN THE CONSUMER STOPPED THE VEHICLE THERE WAS A POPPING NOISE. THE CAR HAS BEEN DOING THIS SINCE OWNERSHIP. *AK
RECALL CAMPAIGN 03V455000 CRANK SHAFT FAILURE. CONSUMER TOOK VEHICLE TO DEALER BECAUSE THE CHECK ENGINE LIGHT CAME ON. CONSUMER WAS INFORMED THERE WAS RECALL REPAIRS THAT NEEDED TO BE PERFORMED FOR THE CRANK SHAFT SENSOR. RECALL REPAIRS WERE PERFORMED. UPON RECEIVING THE VEHICLE FROM THE DEALER THE PERFORMANCE CHANGED. TH…
Read full complaint
RECALL CAMPAIGN 03V455000 CRANK SHAFT FAILURE. CONSUMER TOOK VEHICLE TO DEALER BECAUSE THE CHECK ENGINE LIGHT CAME ON. CONSUMER WAS INFORMED THERE WAS RECALL REPAIRS THAT NEEDED TO BE PERFORMED FOR THE CRANK SHAFT SENSOR. RECALL REPAIRS WERE PERFORMED. UPON RECEIVING THE VEHICLE FROM THE DEALER THE PERFORMANCE CHANGED. THEN, VEHICLE STARTED TO SMOKE FROM THE REAR. IT WAS TAKEN BACK TO THE DEALER, AND THE ENGINE WAS FOUND TO BE DEFECTIVE, AND NEEDED TO BE REPLACED AT CONSUMER'S EXPENSE. *AK CONSUMER KEPT OIL CHANGED EVERY 3,000 MILES, ENGINE FAILURE. *BF
FIRST WAS THE SERVICE ENGINE LIGHT WAS COMING ON AND OFF. THEN I NOTICED AS I ACCELERATE THERE WAS A STRANGE NOISE, WHICH WAS GETTING MORE PRONOUNCED DAILY, FINALLY THE LAST TWO DAYS AS I WAS TRAVELING AND ACCELERATED TO GO FASTER IT WAS ALMOST LIKE IT WAS SLOWING DOWN INSTEAD OF INCREASING IN SPEED. THE NOISE ALSO IS OBVIOUS I…
Read full complaint
FIRST WAS THE SERVICE ENGINE LIGHT WAS COMING ON AND OFF. THEN I NOTICED AS I ACCELERATE THERE WAS A STRANGE NOISE, WHICH WAS GETTING MORE PRONOUNCED DAILY, FINALLY THE LAST TWO DAYS AS I WAS TRAVELING AND ACCELERATED TO GO FASTER IT WAS ALMOST LIKE IT WAS SLOWING DOWN INSTEAD OF INCREASING IN SPEED. THE NOISE ALSO IS OBVIOUS IN PARK NOW. I WENT ON-LINE AND NOTICED A RECALL (03V455000) FOR THE EXACT SAME SYMPTOMS SO I CALLED THE DEALER AND WAS TOLD "NO THAT DOES NOT INCUDE YOUR VIN #, WE GO BY VIN#'S AND YOURS ISN'T LISTED. I SAID"BUT THIS IS WHAT IS GOING ON WITH MY CAR AND IT SAYS IT CAN STALL AT HIGH SPPEDS AND CRASH". SHE SAID SHE COULD CHARGE ME $85 TO HOOK IT UP AND CHECK IT OUT BUT IT IS NOT UNDER A RECALL NOR WARRANTY. PERHAPS THEIR RECALL IS NOT BROAD ENOUGH AND SHOULD INCLUDE MORE VIN#'S... NOT SURE WHAT TO DO FROM HERE, AFRAID TO DRIVE IT, AND THE DEALER IS 50+ MILES AWAY. ANOTHER RECALL (03V061000) IS FOR DRIVER AIR BAG INTERMITTENT WHICH IS ALSO WHATS GOING ON IN MY CAR. *AK
LOST OF HEAT THE DEALERSHIP HAS REPLACED THE WATER PUMP,HEAT BOX,TERMOSTAT'S, FLUSHED COOLING SYSTEM & STILL I LOSE HEAT. THEY HAVE CONTACTED THE ENGINEERS IN CALIF. AND THEY DON'T KNOW WHAT WRONG EITHER. ONE SHOULD BE HERE IN DETROIT BY MARCH 22,2005 TO TRY AND SOLVE THE PROBLEM. NOW THE CAR IS BURNING OIL, WHIN IN A WEEK I HAV…
Read full complaint
LOST OF HEAT THE DEALERSHIP HAS REPLACED THE WATER PUMP,HEAT BOX,TERMOSTAT'S, FLUSHED COOLING SYSTEM & STILL I LOSE HEAT. THEY HAVE CONTACTED THE ENGINEERS IN CALIF. AND THEY DON'T KNOW WHAT WRONG EITHER. ONE SHOULD BE HERE IN DETROIT BY MARCH 22,2005 TO TRY AND SOLVE THE PROBLEM. NOW THE CAR IS BURNING OIL, WHIN IN A WEEK I HAVE TO REPLACE OIL IN THE CAR BECAUSE ALL THE OIL IS GONE AND IT'S NOT LEAKING. *AK
ENGINE DAMAGE DUE TO CATALYTIC CONVERTER BREAKING UP INTO PIECES AND THIS PIECES GOING INTO THE ENGINE. *JB
NO COLLISION- WHILE DRIVING THE VEHICLE MADE A LARGE NOISE AND SUDDENLY EVERYTHING SHUT DOWN.THE ENGINE WAS ON FIRE AND WE HAD CAR TOWED. CAR NEEDS COMPLETE NEW ENGINE. TWO DIFFERENT AUTO SHOPS SAID THEY HAD NO IDEA WHAT COULD HAVE CAUSED THIS. CAR HAD ALWAYS BEEN PROPERLY MAINTAINED. NISSAN WAS NOTIFIED AND CAME TO TAKE PICTURE…
Read full complaint
NO COLLISION- WHILE DRIVING THE VEHICLE MADE A LARGE NOISE AND SUDDENLY EVERYTHING SHUT DOWN.THE ENGINE WAS ON FIRE AND WE HAD CAR TOWED. CAR NEEDS COMPLETE NEW ENGINE. TWO DIFFERENT AUTO SHOPS SAID THEY HAD NO IDEA WHAT COULD HAVE CAUSED THIS. CAR HAD ALWAYS BEEN PROPERLY MAINTAINED. NISSAN WAS NOTIFIED AND CAME TO TAKE PICTURES OF CAR IN NOVEMBER 2004. HAS BEEN UNDER "LEGAL REVIEW" EVER SINCE AND COMPANY HAS BEEN LESS THAN COOPERATIVE WHEN WE'VE TRIED TO CONTACT THEM NUMEROUS TIMES, SO WE'VE CONTACTED AN ATTORNEY.*AK
NISSAN'S RECALL DEALS SEVERELY WITH THE MOTOR. HEAT SENSORS WERE NOT INSTALLED ON THE MOTOR ALLOWING THE MOTOR TO REACH EXTREME TEMPERATURES, THUS BURNING OFF THE OXYGEN SENSOR INTO THE PRE-CATALYST CONVERTER CAUSING MY MOTOR TO LOSE 3 QTS. PLUS OF OIL PER DAY. NISSAN KNEW OF THE PROBLEM AND HAVE TRIED TO CORRECT THE PROBLEM. AL…
Read full complaint
NISSAN'S RECALL DEALS SEVERELY WITH THE MOTOR. HEAT SENSORS WERE NOT INSTALLED ON THE MOTOR ALLOWING THE MOTOR TO REACH EXTREME TEMPERATURES, THUS BURNING OFF THE OXYGEN SENSOR INTO THE PRE-CATALYST CONVERTER CAUSING MY MOTOR TO LOSE 3 QTS. PLUS OF OIL PER DAY. NISSAN KNEW OF THE PROBLEM AND HAVE TRIED TO CORRECT THE PROBLEM. ALTHOUGH I HAVE 117,000 MILES HAVE KEPT UP WITH OIL CHANGES, NISSAN WANTS ME TO PAY 50% OF THE COST TO FIX MY VEHICLE. I HAVE CALLED AND COMPLAINED TO NISSAN'S 800 NUMBER AND OVER 20 PLUS CALLS WENT UNANSWERED. I THEN DROPPED MY VEHICLE OFF AND LEFT IN ORDER TO GET SOMEONE TO RETURN MY CALL. NISSAN THREATENED ME WITH THE TOWING OF MY VEHICLE OFF THEIR PREMISES AND HAVE DONE SO. I AM NOW OUT OF A VEHICLE AND NISSAN WONT BUDGE OFF OF THEIR 50% SPLIT FOR A MOTOR. THIS WAS NISSAN'S FAULT IN THE PRODUCTION OF THE VEHICLE NOT MINE. *NM
Official recalls
507V527000 · Engine And Engine Cooling
Nov 14, 2007
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L ENGINE, THE CRANKSHAFT POSITION SENSOR CAN OVERHEAT CAUSING A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.
Consequence & remedy
Consequence: IF THE INTERRUPTION IN THE SIGNAL FROM THE CRANKSHAFT POSITION SENSOR IS SO BRIEF THAT THE ELECTRONIC CONTROL MODULE (ECM) LOGIC DOES NOT HAVE TIME TO DIAGNOSE THE CONDITION, THE ENGINE MAY STOP RUNNING WITHOUT WARNING WHILE THE VEHICLE IS DRIVEN AT A LOW SPEED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ECM FREE OF CHARGE. CERTAIN MY 2006 ALTIMAS WHICH HAVE BEEN PREVIOUSLY REMEDIED UNDER RECALL CAMPAIGN 06V223 (NISSAN R0606) ARE NOT INCLUDED IN THIS RECALL SINCE THE REPROGRAMMING FOR 06V223 ALSO INCLUDED THIS REPROGRAMMING. THE RECALL BEGAN ON DECEMBER 31, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
03V455000 · Engine And Engine Cooling
Nov 17, 2003
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
Consequence & remedy
Consequence: THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
03V251000 · Fuel System, Gasoline:storage:tank Assembly
Jul 14, 2003
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, CONNECTICUT, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WISCONSIN, AND WYOMING. AT EXTREMELY COLD TEMPERATURES, MOISTURE IN THE FUEL TANK COULD FREEZE AND FORM ICE CRYSTALS. THESE ICE CRYSTALS MAY OBSTRUCT THE SUCTION OPENING OF THE FUEL PUMP.
Consequence & remedy
Consequence: THIS CAN PREVENT THE SUPPLY OF FUEL TO THE ENGINE AND CAUSE THE ENGINE TO STOP, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A SCREEN AT THE SUCTION OPENING OF THE FUEL PUMP TO PREVENT ICE CRYSTALS FROM BLOCKING THE OPENING. OWNER NOTIFICATION BEGAN ON AUGUST 18, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-333-0829.
03V084000 · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Mar 11, 2003
ON CERTAIN VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE, THE EXHAUST PIPE HANGER PIN MAY CATCH DEBRIS FROM THE ROAD THAT COULD BE IGNITED BY CONTACT WITH THE MAIN CATALYST. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE.
Consequence & remedy
Consequence: EITHER OF THESE TWO CONDITIONS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIPE HANGER PIN. IN ADDITION TO THE CORRECTIVE ACTION, IN ORDER TO REDUCE THE RISK OF FIRE IN THE EVENT OF POOR OR IMPROPER MAINTENANCE THAT COULD RESULT IN OIL SPILLAGE, HEAT SHIELD(S) WILL BE INSTALLED ON THE PRE-CATALYST AND EXHAUST TUBE. OWNER NOTIFICATION BEGAN ON JULY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261. NISSAN RECALL NOS. R3007, R3014, R3015, R3016, R3017. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE. IF SUBSTRATE PARTICLES ENTER THE COMBUSTION CHAMBER, THEY COULD SCORE THE CYLINDER WALLS, RESULTING IN INCREASED OIL CONSUMPTION. IF THE ENGINE OIL LEVEL IS NOT CHECKED ON A PERIODIC BASIS AND DROPS BELOW THE LOW LEVEL, AND THE DRIVER CONTINUES TO OPERATE THE VEHICLE IGNORING NOTICEABLE ENGINE NOISE, ENGINE DAMAGE MAY OCCUR WHICH COULD RESULT IN A FIRE. THE PRE-CATALYST WILL BE TESTED TO ENSURE IT IS WORKING PROPERLY AND REPLACED IF NECESSARY. IF DAMAGE IS FOUND INSIDE THE PRE-CATALYST, IT WILL BE NECESSARY TO REPLACE THE ENGINE.
03V061000 · Air Bags:frontal:driver Side:inflator Module
Feb 27, 2003
ON CERTAIN VEHICLES, THE ELECTRICAL CONNECTOR FOR THE DRIVER AIR BAG MAY COME LOOSE. IF THE CONNECTOR COMES LOOSE, THE SUPPLEMENTAL AIR BAG WARNING LIGHT FLASHES INTERMITTENTLY.
Consequence & remedy
Consequence: THE DRIVER SIDE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSTALL A RETAINING CLIP ON THE CLOCK SPRING ELECTRICAL CONNECTOR. OWNER NOTIFICATION BEGAN APRIL 21, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE02078 · Engine Compartment Fires
Opened Oct 18, 2002 · Closed Mar 25, 2003
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON OCTOBER 18, 2002 BASED ON THREE REPORTS INDICATING THAT THE ENGINE COMPARTMENT IN MODEL YEAR (MY) 2002 NISSAN ALTIMA VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE CAUGHT ON FIRE WITHOUT ANY WARNING TO THE DRIVER WHILE THE VEHICLE WAS DRIVEN AT HIGHWAY SPEEDS.ONE NON-BURN RELATED INJURY WAS REPORTED AS A RESULT OF THE COMPLAINANT EXITING THE VEHICLE IN HASTE AFTER IT HAD CAUGHT ON FIRE.NISSAN DISCOVERED THAT ONE OF THE HANGER PINS WHICH HOLDS EXHAUST PIPE IN PLACE MAY CATCH DEBRIS FROM THE ROAD.IF THE DEBRIS WERE TO COME IN CONTACT WITH THE MAIN CATALYST, A FIRE COULD RESULT.THIS CONDITION IS ALSO PRESENT IN MY 2003 NISSAN ALTIMA VEHICLES BUILT THRU FEBRUARY 18, 2003.NISSAN ALSO STATED IN ITS DEFECT INFORMATION REPORT THAT ON MY 2002 ALTIMAS AND SENTRAS (EQUIPPED WITH THE 2.5-LITER ENGINE) THAT CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT, WHICH WOULD CAUSE CATALYST SUBSTRATE PARTICLES TO FLOW INTO THE ENGINE.THESE PARTICLES CAN SCORE THE CYLINDER WALLS WHICH RESULTS IN INCREASE OIL CONSUMPTION.IF THE ENGINE OIL LEVEL IS LOW, ENGINE NOISE AND DAMAGE CAN OCCUR WHICH COULD RESULT IN A FIRE.THE RECALL INCLUDES 268,000 MY 2002-2003 ALTIMAS AND 2002 SENTRAS EQUIPPED WITH THE 2.5-LITER ENGINE.TO CORRECT THE CONDITION NISSAN WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIN ON THE ALTIMAS.NISSAN IS DEVELOPING A CORRECTIVE ACTION TO ADDRESS THE PRE-CATALYST.IN ADDITION TO THE CORRECTIVE ACTION, NISSAN WILL INSTALL HEAT SHIELDS ON THE PRE-CATALYST AND THE SURROUNDING EXHAUST TUBING.NISSAN WILL BEGIN OWNER NOTIFICATION IN MAY OF 2003.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON OCTOBER 18, 2002 BASED ON THREE REPORTS INDICATING THAT THE ENGINE COMPARTMENT IN MODEL YEAR (MY) 2002 NISSAN ALTIMA VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE CAUGHT ON FIRE WITHOUT ANY WARNING TO THE DRIVER WHILE THE VEHICLE WAS DRIVEN AT HIGHWAY SPEEDS.ONE NON-BURN RELATED INJURY WAS REPORTED AS A RESULT OF THE COMPLAINANT EXITING THE VEHICLE IN HASTE AFTER IT HAD CAUGHT ON FIRE.NISSAN DISCOVERED THAT ONE OF THE HANGER PINS WHICH HOLDS EXHAUST PIPE IN PLACE MAY CATCH DEBRIS FROM THE ROAD.IF THE DEBRIS WERE TO COME IN CONTACT WITH THE MAIN CATALYST, A FIRE COULD RESULT.THIS CONDITION IS ALSO PRESENT IN MY 2003 NISSAN ALTIMA VEHICLES BUILT THRU FEBRUARY 18, 2003.NISSAN ALSO STATED IN ITS DEFECT INFORMATION REPORT THAT ON MY 2002 ALTIMAS AND SENTRAS (EQUIPPED WITH THE 2.5-LITER ENGINE) THAT CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT, WHICH WOULD CAUSE CATALYST SUBSTRATE PARTICLES TO FLOW INTO THE ENGINE.THESE PARTICLES CAN SCORE THE CYLINDER WALLS WHICH RESULTS IN INCREASE OIL CONSUMPTION.IF THE ENGINE OIL LEVEL IS LOW, ENGINE NOISE AND DAMAGE CAN OCCUR WHICH COULD RESULT IN A FIRE.THE RECALL INCLUDES 268,000 MY 2002-2003 ALTIMAS AND 2002 SENTRAS EQUIPPED WITH THE 2.5-LITER ENGINE.TO CORRECT THE CONDITION NISSAN WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIN ON THE ALTIMAS.NISSAN IS DEVELOPING A CORRECTIVE ACTION TO ADDRESS THE PRE-CATALYST.IN ADDITION TO THE CORRECTIVE ACTION, NISSAN WILL INSTALL HEAT SHIELDS ON THE PRE-CATALYST AND THE SURROUNDING EXHAUST TUBING.NISSAN WILL BEGIN OWNER NOTIFICATION IN MAY OF 2003.
Engine And Engine Cooling:exhaust System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON OCTOBER 18, 2002 BASED ON THREE REPORTS INDICATING THAT THE ENGINE COMPARTMENT IN MODEL YEAR (MY) 2002 NISSAN ALTIMA VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE CAUGHT ON FIRE WITHOUT ANY WARNING TO THE DRIVER WHILE THE VEHICLE WAS DRIVEN AT HIGHWAY SPEEDS.ONE NON-BURN RELATED INJURY WAS REPORTED AS A RESULT OF THE COMPLAINANT EXITING THE VEHICLE IN HASTE AFTER IT HAD CAUGHT ON FIRE.NISSAN DISCOVERED THAT ONE OF THE HANGER PINS WHICH HOLDS EXHAUST PIPE IN PLACE MAY CATCH DEBRIS FROM THE ROAD.IF THE DEBRIS WERE TO COME IN CONTACT WITH THE MAIN CATALYST, A FIRE COULD RESULT.THIS CONDITION IS ALSO PRESENT IN MY 2003 NISSAN ALTIMA VEHICLES BUILT THRU FEBRUARY 18, 2003.NISSAN ALSO STATED IN ITS DEFECT INFORMATION REPORT THAT ON MY 2002 ALTIMAS AND SENTRAS (EQUIPPED WITH THE 2.5-LITER ENGINE) THAT CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT, WHICH WOULD CAUSE CATALYST SUBSTRATE PARTICLES TO FLOW INTO THE ENGINE.THESE PARTICLES CAN SCORE THE CYLINDER WALLS WHICH RESULTS IN INCREASE OIL CONSUMPTION.IF THE ENGINE OIL LEVEL IS LOW, ENGINE NOISE AND DAMAGE CAN OCCUR WHICH COULD RESULT IN A FIRE.THE RECALL INCLUDES 268,000 MY 2002-2003 ALTIMAS AND 2002 SENTRAS EQUIPPED WITH THE 2.5-LITER ENGINE.TO CORRECT THE CONDITION NISSAN WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIN ON THE ALTIMAS.NISSAN IS DEVELOPING A CORRECTIVE ACTION TO ADDRESS THE PRE-CATALYST.IN ADDITION TO THE CORRECTIVE ACTION, NISSAN WILL INSTALL HEAT SHIELDS ON THE PRE-CATALYST AND THE SURROUNDING EXHAUST TUBING.NISSAN WILL BEGIN OWNER NOTIFICATION IN MAY OF 2003.