Owner reports · Recalls · Investigations
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →Owner complaints by model year
Compare all 9300 years →Counts vary with age, sales and reporting. They are not failure rates.
No component reports in this snapshot.
Tap a category to read its complaints. One report may name several components.
Mileage at the reported incident
Limited mileage data: 0 of 0 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
NHTSA owner reports · September 18, 2026 snapshot.
No matching complaints in this snapshot.
Jul 15, 1999
VEHICLE DESCRIPTION: TRUCKS ASSEMBLED WITH SKF LEVEL 2 TRUCK HUB UNITS (THU) RECEIVED FROM MERITOR. THESE HUBS CAN FATIGUE CRACK.
Consequence: THIS FATIGUE CRACKING CAN RESULT IN WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THESE HUBS WITH PRODUCTION LEVEL 3 HUBS.
Nov 9, 1998
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH SPICER SPL170 55MM CENTER BERING PACKAGE. THE END YOKE RETAINING NUT CAN LOOSEN.
Consequence: IF THIS CONDITION OCCURS, THE DRIVE LINE CAN VIBRATE AND SEPARATE FROM THE VEHICLE, CAUSING VEHICULAR DAMAGE, OR PERSONAL INJURY, OR BOTH.
Remedy: DEALERS WILL REMOVE THE 55MM CENTER BEARING PACKAGE AND COUPLER SHAFT, AND REPLACE IT WITH A NEW COUPLER SHAFT AND A 60MM CENTER BEARING PACKAGE. AN INTERIM REMEDY CAN BE IMPLEMENTED BY PLACING A SPOT WELD ON THE COUPLING SHAFT THREADS UNTIL PARTS ARE AVAILABLE.
May 27, 1998
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH PROSLEEPER BUNKS. A MICRO RELAY LOCATED BEHIND THE HVAC CONTROL PANEL IN THE BUNK CAN CORRODE FROM MOISTURE.
Consequence: THIS CONDITION CAN RESULT IN A SHORT CIRCUIT BETWEEN CONTACTS ON THE RELAY INCREASING THE RISK OF A VEHICLE FIRE.
Remedy: DEALERS WILL REMOVE THE EXISTING RELAY AND REPLACE IT WITH A SEALED RELAY.
Jul 29, 1997
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH ANTILOCK BRAKE SYSTEM (ABS). THE WIRING FROM THE ELECTRONIC CONTROL UNIT WAS CONNECTED TO THE WRONG WHEEL SENSOR.
Consequence: SHOULD THE ABS WIRING BE CROSSED, IT WOULD RESULT IN A SIGNIFICANT DEGRADATION IN BRAKING STABILITY. A SIGNAL WOULD BE SENT TO THE WRONG BRAKE CHAMBER WHEN A BRAKE IMBALANCE IS DETECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE ABS WIRING AND PROPERLY CONNECT THE WIRES, IF NECESSARY.
Jul 28, 1997
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH SIX-SPOKE WHEEL ASSEMBLIES. THESE VEHICLES WERE MANUFACTURED WITH THE WRONG COMBINATIONS OF WHEEL ASSEMBLY PARTS. SHOULD THE SIX-SPOKE WHEEL ASSEMBLY HAVE MIS-MATCHED PARTS, HIGH STRESSES IN THE WHEEL STUDS AND POTENTIAL WHEEL FAILURES CAN OCCUR.
Consequence: STUD FAILURES CAN OCCUR RESULTING IN A WHEEL SEPARATION INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THESE WHEELS AND MAKE THE NECESSARY COMBINATION CORRECTIONS. ALSO OPERATOR INSTRUCTIONS AND VISUAL AIDS WILL BE UPDATED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
No exact-year investigations in this snapshot.
Illustration