NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
4 reportsClear category filterMileage unknown · Aug 1, 2023
Suspension
Dealer wants to replace rear lower control arms due to corrosion and the car control arms were never addressed when I took it into the dealer for recall 16V458. The dealer was supposed to add a anti corrosion spray to the control arms in the front and back. The corrosion is very bad with these parts on my car and I am very con…
Read full complaint
Dealer wants to replace rear lower control arms due to corrosion and the car control arms were never addressed when I took it into the dealer for recall 16V458. The dealer was supposed to add a anti corrosion spray to the control arms in the front and back. The corrosion is very bad with these parts on my car and I am very concerned about safety.
NHTSA ODI #11535688
Mileage unknown · Feb 15, 2022
StructureSuspension
High Point Mitsubishi in High Point NC preformed the recall in regards to rust forming on the underside crossmember of this vehicle. Less than 3 years later this vehicle is immovable because of the exact same reason as the original recall. The technician obviously overlooked areas of which to spray the rust preventative in which…
Read full complaint
High Point Mitsubishi in High Point NC preformed the recall in regards to rust forming on the underside crossmember of this vehicle. Less than 3 years later this vehicle is immovable because of the exact same reason as the original recall. The technician obviously overlooked areas of which to spray the rust preventative in which caused the structural integrity to completely fail at the front mounting location of the driver side control arm onto the crossmember. This vehicle is not safe to drive any longer because of Mitsubishi's lack of thoroughness in performing and evaluating the situation and the condition of said crossmember. High Point Mitsubishi now insists that the issue was resolved even after clear pictures have been sent showing the clear damage and obvious nature of the reasoning of the recall in the first place but argue that they took care of the recall although obviously the exact issue that the recall was made for is thr reason this vehicle is no longer driveable.
NHTSA ODI #11452025
Mileage unknown · Aug 31, 2021
Suspension
The cross member is rusted through with holes in it. Dangerous to drive.
NHTSA ODI #11431274
75,000 miles · Sep 3, 2019
StructureSuspension
TL* THE CONTACT OWNS A 2010 MITSUBISHI OUTLANDER. WHILE THE VEHICLE WAS AT SCHAUMBURG MITSUBISHI (660 EAST GULF RD, SCHAUMBURG, IL) UNDERGOING ROUTINE MAINTENANCE, IT WAS DISCOVERED THAT BOTH LOWER CONTROL ARMS AND CROSS MEMBERS SUSTAINED SEVERE RUSTING AND CORROSION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 2010 MITSUBISHI OUTLANDER. WHILE THE VEHICLE WAS AT SCHAUMBURG MITSUBISHI (660 EAST GULF RD, SCHAUMBURG, IL) UNDERGOING ROUTINE MAINTENANCE, IT WAS DISCOVERED THAT BOTH LOWER CONTROL ARMS AND CROSS MEMBERS SUSTAINED SEVERE RUSTING AND CORROSION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V458000 (STRUCTURE); HOWEVER, THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 75,000.
NHTSA ODI #11252868
Official recalls
10May 18, 2020
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2008-2010 Lancer, 2009-2010 Lancer Sportback, 2008-2013 Outlander, and 2011-2016 Outlander Sport vehicles originally sold in, or ever registered in, Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. The front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.
Consequence & remedy
Consequence: A detached front control arm can result in a loss of vehicle control, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one. These repairs will be performed free of charge. The recall began August 7, 2020. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-20-003.
Additional source detail variants (2)
Structure:frame And Members
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2008-2010 Lancer, 2009-2010 Lancer Sportback, 2008-2013 Outlander, and 2011-2016 Outlander Sport vehicles originally sold in, or ever registered in, Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. The front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.
Consequence: A detached front control arm can result in a loss of vehicle control, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one. These repairs will be performed free of charge. The recall began August 7, 2020. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-20-003.
Suspension:front:control Arm:lower Arm
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2008-2010 Lancer, 2009-2010 Lancer Sportback, 2008-2013 Outlander, and 2011-2016 Outlander Sport vehicles originally sold in, or ever registered in, Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. The front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.
Consequence: A detached front control arm can result in a loss of vehicle control, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one. These repairs will be performed free of charge. The recall began August 7, 2020. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-20-003.
Jan 26, 2018
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2009-2012 Lancer, 2008-2012 Outlander, 2010-2012 Lancer Sportback, and 2011-2012 Outlander Sport vehicles equipped with either a 4B11 or 4B12 engine. The drive belt automatic tensioner flange may crack, allowing the accessory drive belt to detach.
Consequence & remedy
Consequence: If the drive belt detaches, the battery will discharge and the engine will stall, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will replace the belt tensioner with one that has an improved shape, free of charge. The recall is expected to begin March 27, 2018. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-18-001.
Jan 26, 2018
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2007-2010 Outlander, 2008-2010 Lancer, 2009-2010 Lancer Evolution, and 2010 Lancer Sportback vehicles equipped with sunroofs. The sunroof glass may detach from the sunroof assembly, becoming a road hazard to other vehicles.
Consequence & remedy
Consequence: If the sunroof glass detaches from the assembly while driving, it can become a road hazard, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will replace the sunroof glass assembly, free of charge. The recall began on February 27, 2018. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-18-003.
Jul 20, 2017
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2007-2013 Outlander vehicles. In the affected vehicles, water may drop between the hood and the windshield and leak into the wiper motor breathing hole. The water may cause internal corrosion of the windshield wiper motor and the possible failure of the motor.
Consequence & remedy
Consequence: Failure of the wiper motor can cause a loss of visibility, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will replace the wiper motor, free of charge. The recall began July 28, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-003.
Oct 31, 2016
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2007-2013 Outlander vehicles manufactured September 8, 2006, to March 29, 2013. In the affected vehicles, water may enter between the hood and windshield and cause the front wiper link ball joint to corrode, possibly resulting in the wiper link separating and the wipers becoming inoperative.
Consequence & remedy
Consequence: Loss of wiper function can reduce visibility and increase the risk of a crash.
Remedy: MMNA will notify owners, and dealers will replace the rubber boot on the ball joint to prevent water intrusion. Additionally, they will inspect the wiper motor crank arm for excessive play, replacing it as necessary. These repairs will be done free of charge. The recall began on July 28, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-009.
Jun 23, 2016
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2002-2007 Lancer, 2004 Lancer Wagon, 2003-2006 Lancer Evolution, 2003-2006 Outlander and 2007-2013 Outlander V-6 vehicles originally sold in, or ever registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.
Consequence & remedy
Consequence: A detached front control arm can result in the loss of control of the vehicle, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one that has a sealing/anti-corrosion agent applied to it. These repairs will be performed free of charge. The recall began January 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-003.
Apr 20, 2015
Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2009-2010 Mitsubishi Lancer vehicles manufactured January 12, 2009, to July 6, 2010, 2009-2010 Outlander vehicles manufactured January 12, 2009, to August 27, 2010, 2010 Lancer Sportback vehicles manufactured June 17, 2009, to June 8, 2010, and 2010 Lancer Evolution vehicles manufactured July 14, 2009, to August 4, 2010. The affected vehicles have an electronic control unit (ECU) that controls the head lights, tail lights, and windshield wipers. Due to a manufacturing error, the voltage inside this ECU may be unstable.
Consequence & remedy
Consequence: Unstable voltage could result in intermittent failure of the vehicle's head lights, tail lights, and windshield wipers. If the headlights and/or windshield wipers fail, the driver could have reduced visibility. If the tail lights fail, the vehicle could be less visible. Either condition increases the risk of a crash.
Remedy: Mitsubishi will notify owners, and dealers will replace the affected ECU, free of charge. The recall began on June 15 ,2015. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-15-002.
Apr 20, 2015
Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2009-2011 Lancer vehicles manufactured March 16, 2009, to March 30, 2011, 2010-2011 Lancer Sportback vehicles manufactured June 17, 2009, to December 1, 2010, 2010-2011 Lancer Evolution vehicles manufactured July 14, 2009, to January 7, 2011, 2009-2011 Outlander vehicles manufactured February 10, 2009, to June 22, 2011, and 2011 Outlander Sport vehicles manufactured August 26, 2010, to November 19, 2010. In the affected vehicles, the blower motor may fail.
Consequence & remedy
Consequence: Failure of the blower motor may reduce the performance of the windshield defroster, diminishing the driver's visibility and increasing the risk of a crash.
Remedy: Mitsubishi will notify owners, and dealers will replace a suspect blower motor, free of charge. The recall began on June 15, 2015. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-15-003.
Sep 12, 2014
Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2008-2011 Lancer, Lancer Evolution, and Outlander; 2009-2011 Lancer Sportback, Lancer Rilliart, and Lancer Sportback Ralliart; and 2011 Outlander Sport vehicles. The affected vehicles, manufactured with 4B1 engines, have an engine pulley and belt arrangement for turning the alternator, the cooling fan and the power steering pump (if equipped). These pulleys may experience unusual wear and allow for belt detachment.
Consequence & remedy
Consequence: If the drive belt detaches, the battery may discharge, resulting in an engine stall, increasing the risk of a crash.
Remedy: Mitsubishi will notify owners, and dealers will replace the drive belt with a rubber belt. Drive pulleys that are excessively worn will be replaced. These repairs will be performed free of charge. The recall began on October 15, 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-009.
Jun 25, 2014
Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2013 Outlander vehicles equipped with a 6-speed automatic transmission. Additionally, Mitusbishi is recalling certain 2007-2012 Outlander vehicles that received replacement 6-speed automatic transmissions during servicing. The transmissions in these vehicles have insufficient clearance between the power steering pressure tube and the converter housing of the automatic transmission. As a result of the contact, the power steering pressure tube may develop a hole and leak power steering fluid.
Consequence & remedy
Consequence: A power steering fluid leak could result in a loss of steering assistance, increasing the risk of a crash.
Remedy: Mitsubishi will notify owners, and dealers will replace the power steering pressure tube and return tube, free of charge. The recall began in August 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-006.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration