IllustrationHE WILL FILL OUT THE INFORMATION CONCERNING TRUCK: FRAME:MEMBERS: OTHER PARTS FAILURE. *AK THE STORAGE COMPARTMENT UNDER THE MIDDLE SEAT GOT VERY HOT CAUSING CAN OF FIX A FLAT TO EXPLODED. THE PLASTIC COVER FOR SAFETY FLARES ALSO MELTED BY THE HEAT. *YH
1994 Mitsubishi Montero
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Mitsubishi Montero do not stand out strongly from the model-year median of 20.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Montero years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 6 of 31 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports2 injury reports
Structure complaints
2 reportsREAR DOOR HINGE WEAKENS DUE TO WEIGHT OF SPARE TIRE AND CAUSES A GAP TO OPEN AT TOP OF DOOR. MAY ALLOW EXHAUST GASES TO ENTER PASSANGER COMPARTMENT.
Official recalls
500V311001 · Engine And Engine Cooling:engine
Oct 2, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES: MIRAGE MODEL VEHICLES EQUIPPED WITH 1.5L ENGINES; MONTERO SPORT MODELS EQUIPPED WITH 3.0L ENGINES; AND MONTERO MODELS EQUIPPED WITH 3.0L ENGINES. THE BOLT SECURING THE CRANKSHAFT PULLEY CAN BECOME LOOSE AND THE PULLEY COULD FALL OFF THE VEHICLE.
Consequence & remedy
Consequence: THE CONDITION CAN RESULT IN A LOSS OF POWER STEERING ASSIST, INCREASING THE RISK OF A CRASH.
Remedy: ON THE MIRAGE VEHICLES, THE DEALERS WILL INSTALL A NEW, IMPROVED CRANKSHAFT PULLEY BOLT ON THE OLDER ENGINES. ON NEW ENGINES WHICH ALREADY HAVE THE IMPROVED BOLT, THE DEALER WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATION. ON THE MONTERO MODELS, DEALERS WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATIONS. IF THE BOLT IS DAMAGED, IT WILL BE REPLACED.
00V226001 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Aug 15, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONT LOWER BRAKE HOSES CAN DEVELOP A CRACK, CAUSING A LOSS OF BRAKE FLUID.
Consequence & remedy
Consequence: THIS COULD RESULT IN IMPAIRED BRAKING ABILITY AND A POSSIBLE CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER BRAKE HOSES.
98V205000 · Unknown Or Other
Sep 2, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ACCESSORY CARGO MATS IN THE THIRD-SEAT AND CARGO AREA. THIS CARGO MAT INTERFERES WITH THE LATCHING INTEGRITY OF THE FOLDING THIRD SEATS.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT OF THE THIRD SEAT MAY NOT BE PROPERLY RESTRAINED AND COULD BE EJECTED FROM THE VEHICLE.
Remedy: DEALERS WILL INSPECT THE THIRD-SEAT LATCH AND STRIKER. A RECTANGLE WILL BE REMOVED FROM THE CARGO MAT AROUND EACH STRIKER TO PROVIDE ADEQUATE STRIKER CLEARANCE AND PROPER LATCHING.
96V143002 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Aug 12, 1996
UNDER CONDITIONS OF FULL LOCK STEERING AND FULL SUSPENSION TRAVEL, THE LEFT OR RIGHT FRONT WHEEL-SIDE BRAKE HOSE CAN CRACK, RESULTING IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE WILL CAUSE ILLUMINATION OF THE BRAKE WARNING LAMP AND REDUCTION IN BRAKING EFFECTIVENESS INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT WHEEL-SIDE BRAKE HOSES WITH REVISED HOSE ASSEMBLIES.
96V143001 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jul 25, 1996
UNDER CONDITIONS OF FULL LOCK STEERING AND FULL SUSPENSION TRAVEL, THE LEFT OR RIGHT FRONT WHEEL-SIDE BRAKE HOSE CAN CRACK, RESULTING IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE WILL CAUSE ILLUMINATION OF THE BRAKE WARNING LAMP AND REDUCTION IN BRAKING EFFICIENCY INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT WHEEL-SIDE BRAKE HOSES WITH REVISED HOSE ASSEMBLIES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.