2008 Mitsubishi Lancer

I WAS DRIVING MY CAR TO WORK THIS MORNING AND ALL OF A SUDDEN I FELT A DRASTIC PULL TO THE LEFT. I GET OUT OF THE CAR AND LOOK AT ALL SIDES OF THE VEHICLE AND DON'T NOTICE ANYTHING RIGHT AWAY. THEN I NOTICE MY LEFT FRONT WHEEL IS TURNED SLIGHTLY WHILE THE STEERING WHEEL IS STRAIGHT. I LOOK UNDER THE VEHICLE TO FIND THE SUB FRAME ROTTED AND RUSTED AWAY FROM THE CONTROL ARM. THIS IS A HUGE SAFETY ISSUE AS THIS CAR HAS 123K MILES AND BEING A 2008 CAR, JUST 1 YEAR LATER THAN THE RECALLS CURRENTLY UP TO 2007 FOR THE SAME EXACT ISSUE. THE RECALL SHOULD BE EXTENDED TO THE 2008 VEHICLES AS WELL DUE TO THE INSANE AMOUNT OF COMPLAINTS ON THIS SPECIFIC SUB FRAME ROTTING ISSUE.

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. WHILE DRIVING APPROXIMATELY 25 MPH AND ATTEMPTING TO TURN, THE CROSSMEMBER ON THE DRIVER'S SIDE FRACTURED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DEALER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

WHILE DRIVING ON BACK STREET THE CAR STARTED PULLING DRAMATICALLY TO THE LEFT. ON FURTHER INSPECTION IT WAS NOTICED THAT WHERE THE WHEEL CONNECTS TO THE SUBFRAME THERE WAS EXCESSIVE ROT THE POINT THE WHEEL WAS NO LONGER ATTACHED AT THE BOTTOM OF THE SUBFRAME. CONTACTED MITSUBISHI. THEY SAID THE LANCER (AND OTHER MODELS) HAD A RECALL ON EXCESSIVE SUBFRAME ROT BUT ONLY YEARS 2002 TO 2007 FOR THE LANCER. MINE BEING 2008 IS NOT RECALLED. I WILL HAVE TO PAY FOR REPAIRS $2000. THIS IS A HUGE SAFETY ISSUE AS THE SUBFRAME HOLDS THE WHEELS ON, AND THE ENGINE IN PLACE AND IT HAD A CATISTROPIC FAILURE WHICH COULD HAVE EASILY RESULTED IN LOSS OF CONTROL AND LOSS OF LIFE. I WAS NOT NOTIFIED OF THIS OR I COULD HAVE INFORMED MY MECHANIC TO CAREFULLY LOOK FOR SUBFRAME ROT (MOST INSPECTIONS ARE JUST BY SITE). HAD ANYONE HIT THIS SUBFRAME WITH A HAMMER THEY WOULD HAVE SEEN IT WAS DISSINTEGRATING. THE CAR DOES LOOK LIKE ITS RECALLED IN CANADA " TRANSPORT CANADA RECALL 2016317, WHICH WAS ISSUED ON JUNE 21, 2016. THE RECALL INVOLVES 64,305 MITSUBISHI OUTLANDER AND LANCER MODELS MANUFACTURED BETWEEN 2003 AND 2013." MITSUBISHI CUSTOMER RELATIONS HAS INFORMED ME TODAY THAT I WILL BE RESPONSIBLE FOR THE REPAIR. THIS IS NOT RIGHT. FAILURE OF A SUBFRAME IS A VERY RARE EVENT. ITS CLEAR THIS SUBFRAME HAS THE SAME EXACT PROBLEM AS THE LANCERS BUILT THE YEAR BEFORE. THE OUTLANDER ALSO HAS THE EXACT SAME SUBFRAME. THE DEALER HAS MY SUBFRAME IN STOCK BECAUSE ITS EXACTLY THE SAME AS THE OUTLANDER (WHICH IS COVERED). I AM HOPING THEY REALIZE THAT NOT INFORMING CUSTOMERS OF THIS DANGEROUS SITUATION COULD RESULT IN POSSIBLE LOSS OF LIFE. INFORMING THE LANCER OWNERS UP TO 2013 (AS THEY DID IN CANADA) COULD SAVE LIVES.

WHEN I WAS ON MY WAY HOME FROM WORK, I STOPPED AT THE STORE TO GRAB A FEW THINGS. WHEN I WAS DONE, I GOT IN MY CAR AND STARTED TO BACK OUT OF THE PARKING SPOT. I THEN HEARD A CLUNK NOISE, BUT DISMISSED IT BECAUSE I WASN'T SURE WHAT IT WAS. I THEN PULLED OUT OF THE PARKING LOT AND STARTED TO DRIVE ROUGHLY 5-10MPH, WHEN MORE CLUNKS HAPPENED AND THE STEERING WHEEL WENT ALL OVER AND I LOST CONTROL AND WAS FORCED TO STOP IN THE MIDDLE OF THE ROAD. I GET OUT OF SEE WHAT HAPPENED, AND I CAN SEE THAT THE WHOLE SUBFRAME CROSSMEMBER WAS COMPLETELY ROTTED THROUGH, AND THE LOWER CONTROL ARM HAD BROKEN FROM ALL THE ROT AND WAS LOOSE. THIS ALSO CAUSED MY CV AXLE/DRIVESHAFT TO SNAP AS WELL. THERE WAS NO INDICATION THAT ANYTHING WAS WRONG UP TO THIS POINT, AND I WAS COMPLETELY UNAWARE THAT THIS COULD ACTUALLY HAPPEN. HAD THIS HAPPENED 10 MINUTES EARLIER WHEN I WAS DRIVING ON A HIGHWAY AND I LOST CONTROL, I MIGHT NOT BE HERE TYPING THIS MESSAGE. IT IS ALSO ONLY ON THE FRONT DRIVER SIDE CROSSMEMBER THAT HAS ALL THE ROT. THE PASSENGER SIDE LOOKS FAIRLY NORMAL, WHICH I DON'T UNDERSTAND WHY. SOMETHING WITH THE FRONT DRIVER SIDE WAS CLEARLY IGNORED IF IT IS ONLY AFFECTED ON THAT SIDE. THERE IS ALSO COMPLAINTS AND POSTS ONLINE ABOUT THE SAME ISSUE, SO IT IS NOT JUST AFFECTING ME. THERE IS ALSO A RECALL FOR THE SAME EXACT ISSUE, SUBFRAME CROSSMEMBER ROT, FOR THE 2002-2007 LANCER, BUT THIS SHOULD HAVE BEEN EXTENDED TO 2008 OR HIGHER BECAUSE THIS IS A SERIOUS ISSUE AND PEOPLE COULD LOSE THEIR LIVES OVER THIS. ALSO, MY CAR WAS BUILT IN 2007, SO IT'S POSSIBLE THAT I MAY BE AFFECTED IN THE RECALL FOR THE 2002-2007 GROUP, BUT MY CAR IS CLASSIFIED AS A 2008. IT ALSO ONLY HAS JUST OVER 32,000 MILES, THIS SHOULDN'T HAVE HAPPENED.

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. WHILE DRIVING 5 MPH, AN ABNORMAL NOISE WAS HEARD WHILE THE FRONT DRIVER'S TIRE FACED THE OPPOSITE DIRECTION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CROSS MEMBER SUBFRAME WAS CORRODED, FRACTURED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.

AT 50 KM/H, WHEN TURNING THE STEERING WHEEL TO THE LEFT OF 90 DEGREE, THE VEHICLE WAS NOT TURNING AND GOING STRAIGHT FORWARD. SOME SOUND OF TIRE-METAL WAS BEING HEARD FROM THE FRONT LEFT WHEEL. WITH SOMEONE OUTSIDE, WE WERE SEEING AT LOW SPEED THAT THE WHEEL WAS ROTATING OFF AXIS AND EVEN TOUCHING THE CAR BODY. AFTER BEING TOWING TO A CANADIAN TIRE, THE TECHNICIAN MENTIONED THAT THE CROSS MEMBER WAS SO ROTTEN IT WAS ACTUALLY BREAKING IN TWO PARTS AND IT WAS SO DANGEROUS, HE COULD NOT LET ME GO WITHOUT PART REPLACEMENT. THE MECHANIC TECHNICIAN TOLD ME THAT OTHER LANCER HAD THE PROBLEM EVEN A 2009 LANCER. THEY REFERRED ME TO THE TRANSPORT CANADA RECALL # 2016317, HOWEVER THIS ONE IS ONLY FOR LANCER 2003 TO 2006 (AND ALSO OUTLANDERS). NOTE THAT MY PROBLEM WAS THE SAME CAR PART AS THE RECALL MENTIONED ABOVE. I CALLED THE DEALER SHIP TO VERIFY THE CROSS MEMBER CAR PART VS THE OLDER MODEL AND THE PART NUMBER WAS DIFFERENT. I'M WONDERING HOW DIFFERENT FROM 2003 TO 2006 THE CART PART IS! THEY ALSO MENTIONED THAT DODGE CALIBER HAS THE SAME CAR PART IN PROBLEM WITH EXTENDED WARRANTY. I FOUND THIS ARTICLE RELATED TO THIS HTTPS://CHRYSLER.OEMDTC.COM/457/FRONT-AND-REAR-CROSSMEMBER-CORROSION-X69-WARRANTY-EXTENSION-2008-2012-DODGE-CALIBER-JEEP-COMPASSPATRIOT/2

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. WHILE DRIVING APPROXIMATELY 30 MPH, THE CROSS MEMBER AND K FRAME FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER. THE VEHICLE WAS PLACED ON A LIFT, INSPECTED THE VEHICLE, AND DIAGNOSED THAT THERE WAS EXTENSIVE RUST AND CORROSION. THE DEALER INDICATED THAT THE PARTS NEEDED TO BE REPLACED. THE VEHICLE WAS LEFT AT THE DEALER. THE CONTACT WAS WAITING ON A RESPONSE FROM THE MANUFACTURER TO DETERMINE IF THE CONTACT WOULD APPROVE THE DEALER'S REPAIR. THE VIN WAS EXCLUDED FROM A MANUFACTURER RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

ON WEDNESDAY MORNING 4/24/2013 AFTER NIGHT SHIFT I WENT OUTSIDE TO START MY CAR 5-10 MINUTES EARLY JUST LIKE ANY OTHER TIME PRIOR TO DRIVING. I PUT MY CAR IN GEAR TO PULL AWAY AND A SERVICE SIGNAL WENT OFF STATING "MAINTNENCE REQUIRED" WITH A DEPICTION OF A TRANSAXEL AND THE FRONT SUSPENSION IN "MOTION". I THEN PUT THE CAR IN NEUTRAL AND APPLIED THE EMERGENCY BREAK TO INSPECT. THE AWC FUNCTION WOULD NOT WORK, "TARMAC" TO "GRAVEL" TO "SNOW". THE NEXT DAY I BROUGHT MY VEHICLE TO D'AMBROSIO MITSUBISHI FOR THEIR TECHNICIANS TO LOOK AT IT AND REPAIR IT. THEY DID THE USUAL MAINTNENCE OIL CHANGE, FLUID CHECK, TIRE ROTATION ETC LIKE I HAVE DONE EVER 2500 MILES. THE TECHNICIANS DISCOVERED THE S-AWC PUMP HAD SEIZED UP AND THAT THE PUMP NEEDED TO BE REPLACED; HE STATED IT WOULD COST $2500.00 TO REPLACE, I ASKED WHAT I HAD DONE TO CAUSE SUCH A CATASTROPHIC EVENT; THE SERVICE MANAGER ADVISED ME THAT IT WAS A FLAW CAUSED BY MITSUBISHI AND THERE WAS NOTHING I HAD DONE OR DID NOT DO TO CAUSE THIS. I THEN LEFT AND HAVE NO IDEA WHAT I'M GOING TO DO NOW THAT I HAVE A FRONT WHEEL DRIVE CAR THAT IS MEANT TO BE A FULL TIME ALL WHEEL DRIVE CAR, NOW ITS SITTING UNDER A TARP AND I TAKE THE BUS OR GET A RIDE. *TR

TL*THE CONTACT OWNS A 2008 MITSUBISHI LANCER. WHENEVER THE BRAKE PEDAL IS DEPRESSED, THE CONTACT HEARS A LOUD SCRUBBING SOUND COMING FROM THE ROTORS. WHEN THE VEHICLE IS TURNED RIGHT OR LEFT, THE FRONT END OF THE VEHICLE MAKES A POPPING SOUND. THE FIRST TIME THE VEHICLE WAS TAKEN TO THE DEALER THEY REPLACED THE FRONT DRIVER'S SIDE WHEEL BEARING DUE TO A RECALL. THE SECOND TIME THE VEHICLE WAS TAKEN TO THE DEALER REGARDING THE FRONT PASSENGER SIDE WHEEL BEARING. ON THE THIRD VISIT, THE FRONT PASSENGER SIDE WHEEL BEARING WAS REPLACED AND BOTH FRONT ROTORS WERE TURNED. THE VEHICLE HAS BEEN TAKEN TO THE DEALER APPROXIMATELY THREE TIMES REGARDING THIS FAILURE AND IT IS GRADUALLY BECOMING WORSE. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE CURRENT MILEAGE WAS 7,333 AND FAILURE MILEAGE WAS 6,800. UPDATED 10/14/08. *LJ UPDATED 10/16/08. *JB

MY CAR, MITSUBISHI LANCER GTS MODEL 2008 IS PULLING TO THE SIDE. I GOT THIS CAR NEW, IT WAS PULLING TO THE LEFT FROM THE BEGINNING. AFTER THEY DID AN ALIGNMENT, THE CAR IS PULLING TO THE RIGHT. THE AMOUNT OF PULLING IS VERY BIG, FOR EXAMPLE IF, AT 60-65MPH I RELEASE THE STEERING WHEEL IT ROTATES RIGHT INSTANTLY WITH A HALF A INCH, AND THE CAR CHANGES THE LANE TO THE RIGHT IN 3-4 SECONDS. I DON'T KNOW IF THE CAR OR THE TIRES ARE WRONG, BUT THIS IS VERY SERIOOS SAFETY CONCERN FOR ME. I'VE SEARCH ON THE INTERNET FOR PEOPLE WITH SIMILAR ISSUE, AND FOUND OUT THAT MOST OF THE PEOPLE WITH MITSUBISHI LANCER GTS HAVE THIS PROBLEM. SO I BELIEVE MITSUBISHI KNOWS ABOUT THIS PROBLEM BUT JUST DON'T WANT TO ADMIT IT. PLEASE SEE THIS LINK (15 PAGES): HTTP://FORUMS.EVOLUTIONM.NET/SHOWTHREAD.PHP?T=293784 . THANKS A LOT AND PLEASE CONTACT ME IF YOU NEED ADDITIONAL INFORMATION.*TR