Vehicle Speed Control. Review the 87 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

11 crash reports3 fire reports7 injury reports

What owners actually said

185 reports

80,000 miles · Feb 27, 2005

Vehicle Speed Control

Read full complaint

ACCELERATOR STICKS. THIS IS THE 2ND TIME WE HAVE ENCOUNTERED THIS PROBLEM. THE FIRST TIME WAS WITHIN THE 36K WARRANTY AND HAD IT COVERED. CANNOT REMEMBER IF THEY REPLACED THROTTLE BODY OR JUST CLEANED. IT OCCURRED AGAIN .. THIS TIME @ 80K. I HAD THEM REPLACE THE THROTTLE BODY (DEALER RECOMMENDATION FOR $459.82). I HAVE OWNED A TOTAL OF 4 VILLAGERS AND THIS IS THE FIRST TIME I HAVE EVER ENCOUNTERED ANYTHING LIKE THIS. IT IS A HAZARD BECAUSE YOU HAVE TO TAP THE PEDAL HARD TO GET IT TO GO. WHEN TAPPING HARD THERE IS THE POSSIBILITY OF HITTING ANOTHER CAR. AS FAR AS I AM CONCERNED THIS IS A DANGER. I NOTICE THAT MANY PEOPLE HAVE COMPLAINED ABOUT THIS SAME ISSUE. I CANNOT UNDERSTAND WHY FORD MOTOR IS NOT COMING UP WITH A SOLUTION OR COVERING THE COST ON THIS ISSUE? *JB

NHTSA ODI #10112242

28,000 miles · Jan 28, 2005

Vehicle Speed Control

Read full complaint

GAS PEDAL STICKS. YOU HAVE TO ACTUALLY STOMP ON THE ACCELERATOR TO GET IT TO MOVE. HAS DONE THIS SINCE I HAVE OWNED THE VEHICLE. DEALER HAS CLEANED THROTTLE CABLE 3 TIMES. INDICATES IT NEEDS NEW THROTTLE ASSEMBLY. TECHS WERE ADVISED (PER MY DEALER) FROM FORD TO ONLY CLEAN THROTTLE ASSEMBLY WHEN CONSUMER COMPLAINED. NOW AFTER MANY MILES AND NO WARRANTY THEY SUGGEST CHANGING THE COMPLETE ASSEMBLY AT MY COST. I UNDERSTAND THAT OHIO RESIDENTS HAVE A CLASS ACTION SUIT FOR THIS. HOW DO ALL OTHER OWNERS OF THESE VEHICLES FROM OTHER STATES PARTICPATE IN MAKING THE MANUFACTURER RESPONSIBLE FOR THIS DEFECT?

NHTSA ODI #10108132

Mileage unknown · Jan 4, 2005

Latches/locks/linkages

Read full complaint

IF THERE IS ANYTHING JUST EVEN SLIGHTLY HANGING OVER THE BACK HATCH WHEN IT IS CLOSED IT WILL NOT RELEASE (OPEN). A RECENT INCIDENT OCCURRED WHEN I HAD A PIECE OF CARDBOARD FROM A CLOTHES HANGER HANGING OVER THE EDGE OF WHERE THE BACK HATCH CLOSES. IT WOULD NOT REOPEN. I TOOK IT TO THE DEALER AND THEY COULDN'T GET IT OPEN. I FINALLY PULLED THE CARDBOARD OUT, PIECE BY PIECE, AND THEN THE HATCH WOULD OPEN. IT HAS DONE THIS WITH CLOTHING -- SHIRT SLEEVE, BLANKET, PENCIL, ETC. IF SOMETHING IS ON THE EDGE OF THE DOOR HATCH FLOOR, AND GETS STUCK IN THE HATCH, THE HATCH WILL NOT OPEN. FROM A SAFETY ASPECT, IF A CHILD OR SOMEONE ELSE'S FINGER GOT SLAMMED SHUT INTO THE HATCH, YOU WOULD NOT BE ABLE TO OPEN THE HATCH TO GET THE FINGER OUT!!!! IT DOES NOT HAVE TO BE SOMETHING THICK, NOR DOES IT HAVE TO BE BY THE LATCH -- IN FACT IT IS NEVER BY THE LATCH BECAUSE THE LATCH IS ON THE SIDES. THE CARDBOARD FROM THE HANGER WAS THE CIRCUMFERENCE OF A FINGER. NO ONE COULD GET IT OPEN -- THE CARDBOARD HAD TO BE RIPPED OUT FROM UNDER THE HATCH.*AK

NHTSA ODI #10105770

Mileage unknown · Nov 22, 2004

Vehicle Speed Control

WHILE ACCELERATING THE VEHICLE VIBRATED THEN JERKED ON IT'S OWN. THE CONSUMER HAD TAKE THE VEHICLE TO THE DEALER FOR INSPECTION, AND THE MECHANIC DETERMINED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE CONSUMER THEN INFORMED THE MECHANIC THAT THIS PROBLEM OCCURRED MORE THAN ONCE AND HAD NOT BEEN RESOLVED. *AK *SC

NHTSA ODI #10092876

55,000 miles · Oct 12, 2004

Vehicle Speed Control

THE ACCELERATOR PEDAL STICKS WHEN AT A STOP SIGN / TRAFFIC LIGHT OR COASTING IN TRAFFIC. I MUST PUSH VERY HARD ON THE PEDAL FOR THE ACCELERATOR TO MOVE. THIS HAPPENS SEVERAL TIMES A DAY. I FEEL THIS IS A SAFETY ISSUE. I FEEL LIKE I COULD POSSIBLY REAR END ANOTHER VEHICLE OR POSSIBLY BE REAR ENDED MYSELF. THIS PROBLEM MAKES THE V…

Read full complaint

NHTSA ODI #10095655

40,000 miles · Oct 12, 2004

Vehicle Speed Control

WHILE STOPPING AT A LIGHT AND ATTEMPTING TO ACCELERATE GAS PEDAL STUCK. AS A RESULT, VEHICLE SURGED FORWARD AND THE TIRES SPUN OUT. *AK THIS PROBLEM HAS OCCURRED REPEATEDLY SINCE ABOUT 40K MILES, CURRENTLY AT 82K MILES, THIS WOULD OCCUR AT LEAST ONE IN FIVE TIMES THE ACCELERATOR PEDAL WAS DEPRESSED. *SC

NHTSA ODI #10091781

59,500 miles · Oct 10, 2004

Vehicle Speed Control

GAS PEDAL ON MERCURY VILLAGER DOES NOT ALWAYS RESPOND AND WHEN IT DOES IT DOES SO RAPIDLY/HAS BEEN FIXED TWICE BY DEALER/DEALER STATES THAT IT IS A DESIGN FLAW AND WITHOUT REPLACEMENT OF CARB THERE IS NO CURE.

NHTSA ODI #10093891

72,000 miles · Sep 28, 2004

Vehicle Speed Control

WHILE DRIVING THE ACCELERATOR PEDAL STUCK. THE DEALERSHIP WAS NOTIFIED BUT DID NOT RESOLVE THE PROBLEM. *AK *NM

NHTSA ODI #10091888

71,200 miles · Sep 21, 2004

Vehicle Speed Control

WHILE DRIVING, THE ACCELERATOR PEDAL BECAME STUCK. *AK THE CONSUMER HAD TO STOMP ON THE ACCELERATOR CAUSING THE VEHICLE TO JUMP FORWARD. *TC *JB

NHTSA ODI #10089535

15,000 miles · Aug 26, 2004

Vehicle Speed Control

ACCELERATOR PEDAL STICKS. HAD THE THROTTLE ASSEMBLEY REPLACED IN 2001 AND NOW IT'S DOING THE SAME THING AGAIN.*AK

NHTSA ODI #10088642

Official recalls

00V292001 · Steering:rack And Pinion

Oct 10, 2000

VEHICLE DESCRIPTION: MINI VANS. ONE OR MORE OF THE FIVE BOLTS THAT MOUNT THE RACK AND PINION STEERING GEAR TO THE VEHICLE MAY HAVE BEEN INCORRECTLY TIGHTENED.

Consequence & remedy

Consequence: THERE COULD BE A LOOSENESS IN THE STEERING, WHICH MAY BE ACCOMPANIED BY NOISE OR VIBRATION.

Remedy: DEALERS WILL INSPECT THE VEHICLES AND, IF THE BOLTS ARE MISSING, WILL REPLACE THE STEERING GEAR MOUNTING BOLTS. ALL BOLTS WILL BE TIGHTENED TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN NOVEMBER 28, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

99V347001 · Exterior Lighting:tail Lights

Dec 10, 1999

VEHICLE DESCRIPTION: MINIVANS. THE TAIL LIGHT SOCKET MAY HAVE BEEN IMPROPERLY MOLDED, RESULTING IN THE LOCKING TAB HAVING INSUFFICIENT FORCE TO RETAIN THE BULB.

Consequence & remedy

Consequence: IF THE BULB FALLS OUT OF THE SOCKET, THE BRAKE OR TAIL LAMP FUNCTION CANNOT OCCUR.

Remedy: DEALERS WILL REPLACE THE TAIL LAMP SOCKETS.

99V205001 · Fuel System, Gasoline:storage:tank Assembly:mounting

Aug 3, 1999

VEHICLE DESCRIPTION: MINI VANS. THE FUEL TANK RETENTION STRAP (TWO STRAPS PER VEHICLE) CAN BREAK AT THE SPOT WELDS CAUSING AN UNDERBODY RATTLE.

Consequence & remedy

Consequence: THERE IS ALSO A POTENTIAL FOR FUEL TANK SEPARATION OR FUEL LEAK, INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL TANK RETENTION STRAPS.

99V056001 · Seats

Mar 30, 1999

VEHICLE DESCRIPTION: MINI VANS. THE AFFECTED VEHICLES MAY HAVE A SECOND ROW RIGHT HAND SIDE CAPTAIN CHAIR THAT HAS INADEQUATE LUBRICATION OF THE EASY ENTRY AND EXIT LATCH SYSTEM. IN SOME CASES, THE ACTUATOR SPRING IN THE LATCH COULD DEFORM AFTER REPEATED USE, CAUSING THE LATCH TO REMAIN IN THE UNLATCHED POSITION. IF THIS OCCURS, THE SEAT WILL SLIDE FREELY ON THE SEAT TRACK AND THE SPRINGS ON THE TRACK WILL MOVE THE SEAT TO THE EASY ENTRY POSITION TOWARD THE FRONT OF THE VEHICLE.

Consequence & remedy

Consequence: AN UNLATCHED SEAT TRACK COULD RESULT IN AN INCREASED RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE SEAT TRACK FOR THE SECOND ROW RIGHT HAND SIDE CAPTAIN'S CHAIR, WHICH INCLUDES THE EASY ENTRY AND EXIT LATCH MECHANISM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE04020 · Failing Headlights

Opened Feb 26, 2004 · Closed Jun 24, 2004

Status: closed (inferred from source dates) · Exterior Lighting:headlights

NISSAN AND FORD FOUND THAT THE ORIGINAL EQUIPMENT HEADLIGHT STAINLESS STEEL BULB TERMINALS MAY OVER TIME CAUSE ELEVATED CONTACT RESISTANCE AND OVERHEAT THE ELECTRICAL CONNECTOR HOUSING.THIS CAN RESULT IN A HEADLIGHT FLICKERING, BULB OUTAGE AND HEAT DEFORMATION TO THE HEADLIGHT CONNECTOR.IN APRIL 1999, THE SUPPLIER OF THE HEADLIGHT FOR NISSAN AND FORD CHANGED TO A BULB USING THE STAINLESS STEEL TERMINALS THAT DID NOT MEET ORIGINAL SPECIFICATIONS.ON JULY 17, 2000, THE SUPPLIER BEGAN USING A BULB MEETING THE VEHICLE MANUFACTURER'S SPECIFICATIONS.THIS PROBLEM CAN AFFECT INDEPENDENTLY EITHER HEADLIGHT BUT DOES NOT CAUSE SIMULTANEOUS FAILURE OF BOTH HEADLIGHTS. THE PROBLEM ALSO DOES NOT AFFECT FRONT PARKING LAMPS.AS A RESULT, THE COMPLAINTS TYPICAL REPORT SINGLE FAILURE OF ONE HEADLIGHT.THERE ARE NO CRASHES OR LOSS OF VEHICLE CONTROL REPORTED.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.