MY MERCURY VILLAGER WHILE LOCK IN MY GARAGE AND DOOR LOCK WE SMELL SMOKE OUTSIDE OF GARAGE WE HAD NOT USED THE GARAGE EXCEPT WEEK AGO WE FOUND THE WINDOW CRACK FRONT ALSO VENTS FRONT WERE ALL MELTED MOST DAMAGE IS LOCATED BEHIND THE HEATER AND RADIO ALSO NEAR THE ACCELERATOR PEDAL THAT PART OF THE DASH WAS ALSO BURNT ALL THE WIN…
Read full complaint
MY MERCURY VILLAGER WHILE LOCK IN MY GARAGE AND DOOR LOCK WE SMELL SMOKE OUTSIDE OF GARAGE WE HAD NOT USED THE GARAGE EXCEPT WEEK AGO WE FOUND THE WINDOW CRACK FRONT ALSO VENTS FRONT WERE ALL MELTED MOST DAMAGE IS LOCATED BEHIND THE HEATER AND RADIO ALSO NEAR THE ACCELERATOR PEDAL THAT PART OF THE DASH WAS ALSO BURNT ALL THE WINDOWS WERE ALSO FULLY CLOSED! WE CALLED THE POLICE THEY HAD NO SIGNS OF FORCE ENTRY THEY ALSO DETERMINED THE FIRE STARTED INSIDE DASH BETWEEN THE HEATER CONTROL AND THE RADIO. THE VEHICLE HAS NEVER BEEN SERVICE OR HAD ANY ITEM REPAIR OR REPLACED AS LONG AS WE OWN THE VEHICLE. *TR
NHTSA ODI #10191813
60,000 miles · Sep 18, 2005
Vehicle Speed Control
WHILE PULLING IN TO OUR GARAGE, MY FOOT WAS NOT ON THE GAS PEDAL, AND THE VAN ACCELERATED. I PUSHED THE BRAKE BUT THE VAN DID NOT STOP. THE VAN CRASHED IN TO THE BACK OF OUR GARAGE, MOVING THE HOUSE OFF OF THE CEMENT BLOCK. VAN IS CURRENTLY AT THE DEALERSHIP AND I WAS TOLD THAT "IT WILL GO TO SERVICE ON MONDAY FOR DIAGNOSTICS…
Read full complaint
WHILE PULLING IN TO OUR GARAGE, MY FOOT WAS NOT ON THE GAS PEDAL, AND THE VAN ACCELERATED. I PUSHED THE BRAKE BUT THE VAN DID NOT STOP. THE VAN CRASHED IN TO THE BACK OF OUR GARAGE, MOVING THE HOUSE OFF OF THE CEMENT BLOCK. VAN IS CURRENTLY AT THE DEALERSHIP AND I WAS TOLD THAT "IT WILL GO TO SERVICE ON MONDAY FOR DIAGNOSTICS". I AM SCARED TO DRIVE THIS VEHICLE AGAIN. I HAVE TWO SMALL CHILDREN AND IF THIS HAD HAPPENED ANYWHERE ELSE, THE ACCIDENT COULD HAVE BEEN MORE SEVERE/FATAL. I AM COMPLETING THIS REPORT IN HOPES THAT SOMEONE CAN LOOK IN TO THIS PROBLEM (I'VE READ OTHER CASES WITH THIS SAME PROBLEM) BECAUSE I AM SCARED TO DRIVE THE VEHICLE ANY LONGER. I'M HOPING THAT SOMEONE CAN HELP BEFORE SOMETHING WORSE HAPPENS. *NM
NHTSA ODI #10136860
Mileage unknown · Nov 17, 2004
Vehicle Speed ControlCrash
WHILE DRIVING THE VEHICLE SUDDENLY ACCELERATED ALTHOUGH THE DRIVER'S FOOT WAS NOT ON THE ACCELERATOR PEDAL. *NM ON A SECOND OCCASION THE VEHICLE ACCELERATED AND THE CONSUMER HIT A PARKED VEHICLE. THE VEHICLE WENT INTO REVERSE AND BACKED INTO A GARAGE DOOR. *TC *JB
NHTSA ODI #10101380
Mileage unknown · Jul 8, 2004
Power TrainService Brakes, HydraulicVehicle Speed Control
VERY STRONG SMELLING GAS FUMES INSIDE PASSENGER COMPARTMENT WHEN HEATER IS TURNED ON. WHILE DRIVING THE SPEED GAUGE WILL STOP WORKING AND THE CHECK ENGINE LIGHT WILL COME ON. BRAKES MAKE A GRINDING NOISE EVEN AFTER BEING REPLACED. CV BOOT IS LEAKING AND CRACKED. DRIVER SIDE AUTO-SEAT BELT SOMETIMES FAILS TO GO UP AND DOWN. REA…
Read full complaint
VERY STRONG SMELLING GAS FUMES INSIDE PASSENGER COMPARTMENT WHEN HEATER IS TURNED ON. WHILE DRIVING THE SPEED GAUGE WILL STOP WORKING AND THE CHECK ENGINE LIGHT WILL COME ON. BRAKES MAKE A GRINDING NOISE EVEN AFTER BEING REPLACED. CV BOOT IS LEAKING AND CRACKED. DRIVER SIDE AUTO-SEAT BELT SOMETIMES FAILS TO GO UP AND DOWN. REAR WINDSHIELD WIPER GETS STUCK IN UP POSITIONS WHEN TRING TO USE IT. *AK
NHTSA ODI #10080599
Mileage unknown · May 20, 2002
Vehicle Speed ControlCrash
VEHICLE ACCELERATED ON ITS OWN, CONSUMER APPLIED BRAKES, BUT VEHICLE CONTINUED. VEHICLE SIDE SWIPED A PARKED VEHICLE, THEN HIT A IRON FENCE. NO INJURIES, PLEASE ADD AMOUNT OF DAMAGE TO VEHICLE.*AK *JG
NHTSA ODI #8010103
Mileage unknown · Mar 22, 2001
Vehicle Speed Control
WHEN FIRST PRESSING ON GAS PEDAL GETS STUCK. THIS IS SAME PROBLEM AS RECALL ON FORD, EXPLORER, 1997, 00S58.*AK *SLC
NHTSA ODI #883787
Mileage unknown · Jul 28, 2000
Engine And Engine CoolingVehicle Speed Control
INTERMITTENTLY CRUISE CONTROL WILL DEACTIVATE BY ITSELF. DEALER HAS BEEN NOTIFIED.*AK CRUISE CONTROL DEACTIVATES ONLY AT HIGHER ELEVATIONS. THE VEHICLE HAS FUEL VAPOR LOCK PROBLEM ON HOT DAYS AND LONG DRIVES. *YH
NHTSA ODI #866241
Mileage unknown · Jan 19, 2000
Vehicle Speed ControlVisibility
IN COLD TEMP, VEHICLE IN IDLE,STRONG FUEL ODOR IN VEHICLE CABIN WHEN HEATER IS ON. *AK
NHTSA ODI #717579
Mileage unknown · Oct 14, 1999
Vehicle Speed Control
CONSUMER PICKED UP CAR FROM DEALER AND STARTED IT UP, VEHICLE SUDDENLY ACCELERATED OUT OF CONTROL, AND LANDED UO IN THE STREET. CONSUMER PUT CAR IN DRIVE, AND STOPPED IIT. VEHICLE ALMOST WENT INTO THE GARAGE. *AK
NHTSA ODI #850742
Mileage unknown · Sep 4, 1996
Vehicle Speed Control
FAILURE ON THE ACCELERATOR THROTTLE AND PEDAL, WHEN DRIVING THE VEHICLE SUDDENLY ACCELERATED OUT OF CONTROL. *AK
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
THE REAR LAMP SOCKET MAY NOT ILLUMINATE BECAUSE THE METAL CAN IN THE LAMP SOCKET MOVES OR SEPARATES FROM THE PLASTIC SOCKET HOUSING.
Consequence & remedy
Consequence: THIS CAN RESULT IN MALFUNCTION OF THE STOP OR REAR RUNNING LAMPS. CENTER HIGH MOUNT STOP LAMP FUNCTION IS UNAFFECTED. REAR LAMP MALFUNCTION CAN RESULT IN FOLLOWING DRIVERS NOT BEING ALERTED TO THE SUBJECT VEHICLE'S PRESENCE OR INTENDED ACTIONS, PARTICULARLY IN THE CASE IN WHICH BOTH LAMPS HAVE MALFUNCTIONED.
Remedy: DEALERS WILL INSTALL A REVISED REAR LAMP SOCKET AND WIRING ASSEMBLIES.
AN OUT-OF-SPECIFICATION CONDITION IN THE SEAT CABLE ROLLER PULLEY ASSEMBLY CAN ALLOW THE CABLE THAT CONNECTS THE SEAT ADJUST LEVER TO THE LATCH TO BE PINCHED IN THE ROLLER ASSEMBLY.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THIS CONDITION CAN PREVENT THE LATCH ON THE LEFT SIDE FROM FULLY ENGAGING THE SEAT RAIL. THIS DOES NOT COMPLY WITH THE REQUIREMENT OF FMVSS NO. 207, "SEATING SYSTEMS."
Remedy: DEALERS WILL REPLACE A COMPONENT IN THE THIRD ROW SLIDING BENCH SEAT LATCH ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA00014 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANTS CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUOROCARBON RUBBER HOSES WITH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WERE MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT TO DEGRADATION AND CRACKING.IN A LETTER DATED JANUARY 2, 2001, FORD NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFACTED VEHICLES.FORD WILL BEGIN NOTIFYING CUSTOMERS OF THE AFFECTED VEHICLES ON OR ABOUT THE WEEK OF FEBRUARY 12, 2001 TO RETURN THEIR VEHICLES TO DEALERS FOR REPLACEMENT OF THE FUEL TANK VENT HOSE WITH THE LATEST DESIGN LEVER PART.
SQ00008 · Unexpected Opening On Sliding Door
Opened May 12, 2000 · Closed Apr 1, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99077 · Fuel Tank Vent Hose Leakage
Opened Dec 28, 1999 · Closed May 22, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99015 · Fuel Rail Hose Fitting Leakage
Opened Jun 29, 1999 · Closed Apr 18, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE ENGINEERING ANALYSIS CLOSING REPORT COVERS 1993-1998 MERCURY VILLAGER AND NISSAN QUEST MINIVANS.THESE TWO MINIVANS SHARE A COMMON BODY PLATFORM AND POWER TRAIN.BASED ON THE LOW NUMBER OF REPORTED INCIDENTS AND THE ABSENCE OF A DEMONSTRABLE FAILURE TREND, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES IS NOT WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ENGINEERING CLOSING REPORT EA99-015 FOR DETAILS.
PE99013 · Fuel Rail Hose Fitting Leakage
Opened Feb 9, 1999 · Closed Jun 29, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
SINCE SEPTEMBER 1998, ODI HAS RECEIVED SEVEN COMPLAINTS OF FUEL ODOR OR LEAKAGE IN 1994 THROUGH 1995 MERCURY VILLAGER VEHICLES.FOUR OF THE LEAKS HAVE BEEN TRACED TO A SHORT SECTION OF HOSE THAT CONNECTS THE FUEL SUPPLY TUBE TO THE REAR OF THE FUEL RAIL.INFORMAITON CONTAINED IN THE REPORTS INDICATE THAT THE PROBLEM MAY BE DIFFICULT TO DIAGNOSE, WITH SEVERAL OWNERS ALLEGING MULTIPLE DEALER SERVICE REPAIRS.ADVANCED COMPRESSION SET IS EVIDENT IN A HOSE REMOVED FROM THE MOST RECENT COMPLAINT VEHICLE.
EA96005 · Battery Explosions
Opened May 30, 1996 · Closed May 29, 1997
Status: closed (inferred from source dates) · Electrical System
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.
1995 Mercury Villager Problems, Complaints & Recalls | Skip That Year
Illustration