I OWN A 1995 MERCURY VILLAGER. THE FRONT PASSENGER SIDE SEAT BELT BECAME UN-OPERATIONAL IN MARCH 2001. I CONTACTED MY DEALER AND MERCURY AT THE TIME, NEITHER WAS OF ANY HELP AND SHOWED NO CONCERN. I PAID $121 OUT OF POCKET TO REPLACE THE PART. NOW, IN FEBRUARY OF 2003 THE SAME LOCATIONS SEAT BELT IS UN-OPERATIONAL AGAIN. I…
Read full complaint
I OWN A 1995 MERCURY VILLAGER. THE FRONT PASSENGER SIDE SEAT BELT BECAME UN-OPERATIONAL IN MARCH 2001. I CONTACTED MY DEALER AND MERCURY AT THE TIME, NEITHER WAS OF ANY HELP AND SHOWED NO CONCERN. I PAID $121 OUT OF POCKET TO REPLACE THE PART. NOW, IN FEBRUARY OF 2003 THE SAME LOCATIONS SEAT BELT IS UN-OPERATIONAL AGAIN. I CONTACTED MY DEALER WHO TOLD ME TO CALL MERCURY. THEY WILL NOT HELP COVER A PART THAT IS MORE THAN 12 MONTHS OLD. WE WERE TOLD OVER AND OVER THAT IT'S THEIR POLICY. I HAVE OWNED ABOUT 6 VEHICLES IN MY YEARS OF DRIVING, THIS HAS NEVER HAPPENED TO ME BEFORE. A DEFECTIVE SEAT BELT SHOULD BE AT THE BOTTOM OF MY LIST OF CONCERNS REGARDING MY AUTOMOBILES. THE SEAT BELT ON THIS PASSENGER SEAT IS USED THE LEAST IN THE VAN BECAUSE I REQUIRE MY CHILD TO SIT IN THE MIDDLE ROW OF MY VAN AND 90% OF THE TIME MY WIFE OR I ARE TRANSPORTING OURSELVES ALONE OR ONE OF US WITH OUR CHILD. THE SEAT IS HARDLY EVER-USED OR BEING PUT THROUGH UNNECESSARY WEAR AND TEAR.*JB
NHTSA ODI #10008441
125,000 miles · Jan 18, 2003
Engine And Engine CoolingEquipment
HAVE HAD SEVERAL WATER PUMPS REPLACED IN OUR 1995 MERCURY VILLAGER. BEGINS LEAKING AFTER TWO TO FOUR WEEKS DRIVING IN COLD WEATHER. 4 REPLACED LAST WINTER, DROVE FINE DURING SUMMER, RECENTLY REPLACED AGAIN BY SAME REPAIR SHOP. EACH TIME THE WATER PUMP LEAKS BY THE SEALS IN THE PUMP. DEFECTIVE DESIGN?
NHTSA ODI #10002910
Mileage unknown · Jan 17, 2003
Equipment
WHEN DRIVING IN COLD WEATHER, CONSUMER STATES YOU CAN SMELL GAS FUMES IN THE CAB. CAUSE IS UNKNOWN. PLEASE PROVIDE ANY FURTHER INFORMATION. TS
NHTSA ODI #10004158
Mileage unknown · Aug 9, 2001
EquipmentInterior LightingStructure
DRIVER DOOR LOCK CONTROL FAILS TO LOCK OR UNLOCK 3 DOORS. ELECTRICAL SHORT CAUSING RADIO MEMORY TO CLEAR. THE REAR AC/HEATER STARTS AND STOPS WHEN DASH SWITCH IS IN THE "REAR" POSITION. *AK
NHTSA ODI #750141
Mileage unknown · Dec 17, 1999
EquipmentSeats
A $700 COMPONENT NEAR PASSENGER SEAT (2ND ROW) SHOULD NOT BLOW FROM ELECTICAL SURGE, ELECTRICAL SHORT OR THE LIKE. WHERE IS THE FUSE, OR OTHER PROTECTIVE DEVICE TO PREVENT THIS FROM HAPPENING. AT THE DEALER I WAS NOT SHOWN DAMAGED PART NOR DO I REALLY DO NOT KNOW IF ELECTICAL OR FIRE DAMAGED THE BLOWER UNIT.
NHTSA ODI #716155
Mileage unknown · May 1, 1997
Engine And Engine CoolingEquipment
EXHAUST FUMES ENTERING INTO VEHICLE.
NHTSA ODI #516867
Mileage unknown · Dec 4, 1996
Electrical SystemEngine And Engine CoolingEquipment
POWER DOOR LOCKS FAILED; ALSO ELECTRICAL DISPLAY FUNCTIONS MODULE FAILURE/ FRONT END MISALIGNMENT/ENGINE NOISE/FUEL PUMP NOISE/ LEAF SPRING FAILURE AND REPLACED A/C FAN MOTOR. *AK
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
THE REAR LAMP SOCKET MAY NOT ILLUMINATE BECAUSE THE METAL CAN IN THE LAMP SOCKET MOVES OR SEPARATES FROM THE PLASTIC SOCKET HOUSING.
Consequence & remedy
Consequence: THIS CAN RESULT IN MALFUNCTION OF THE STOP OR REAR RUNNING LAMPS. CENTER HIGH MOUNT STOP LAMP FUNCTION IS UNAFFECTED. REAR LAMP MALFUNCTION CAN RESULT IN FOLLOWING DRIVERS NOT BEING ALERTED TO THE SUBJECT VEHICLE'S PRESENCE OR INTENDED ACTIONS, PARTICULARLY IN THE CASE IN WHICH BOTH LAMPS HAVE MALFUNCTIONED.
Remedy: DEALERS WILL INSTALL A REVISED REAR LAMP SOCKET AND WIRING ASSEMBLIES.
AN OUT-OF-SPECIFICATION CONDITION IN THE SEAT CABLE ROLLER PULLEY ASSEMBLY CAN ALLOW THE CABLE THAT CONNECTS THE SEAT ADJUST LEVER TO THE LATCH TO BE PINCHED IN THE ROLLER ASSEMBLY.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THIS CONDITION CAN PREVENT THE LATCH ON THE LEFT SIDE FROM FULLY ENGAGING THE SEAT RAIL. THIS DOES NOT COMPLY WITH THE REQUIREMENT OF FMVSS NO. 207, "SEATING SYSTEMS."
Remedy: DEALERS WILL REPLACE A COMPONENT IN THE THIRD ROW SLIDING BENCH SEAT LATCH ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA00014 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANTS CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUOROCARBON RUBBER HOSES WITH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WERE MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT TO DEGRADATION AND CRACKING.IN A LETTER DATED JANUARY 2, 2001, FORD NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFACTED VEHICLES.FORD WILL BEGIN NOTIFYING CUSTOMERS OF THE AFFECTED VEHICLES ON OR ABOUT THE WEEK OF FEBRUARY 12, 2001 TO RETURN THEIR VEHICLES TO DEALERS FOR REPLACEMENT OF THE FUEL TANK VENT HOSE WITH THE LATEST DESIGN LEVER PART.
SQ00008 · Unexpected Opening On Sliding Door
Opened May 12, 2000 · Closed Apr 1, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99077 · Fuel Tank Vent Hose Leakage
Opened Dec 28, 1999 · Closed May 22, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99015 · Fuel Rail Hose Fitting Leakage
Opened Jun 29, 1999 · Closed Apr 18, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE ENGINEERING ANALYSIS CLOSING REPORT COVERS 1993-1998 MERCURY VILLAGER AND NISSAN QUEST MINIVANS.THESE TWO MINIVANS SHARE A COMMON BODY PLATFORM AND POWER TRAIN.BASED ON THE LOW NUMBER OF REPORTED INCIDENTS AND THE ABSENCE OF A DEMONSTRABLE FAILURE TREND, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES IS NOT WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ENGINEERING CLOSING REPORT EA99-015 FOR DETAILS.
PE99013 · Fuel Rail Hose Fitting Leakage
Opened Feb 9, 1999 · Closed Jun 29, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
SINCE SEPTEMBER 1998, ODI HAS RECEIVED SEVEN COMPLAINTS OF FUEL ODOR OR LEAKAGE IN 1994 THROUGH 1995 MERCURY VILLAGER VEHICLES.FOUR OF THE LEAKS HAVE BEEN TRACED TO A SHORT SECTION OF HOSE THAT CONNECTS THE FUEL SUPPLY TUBE TO THE REAR OF THE FUEL RAIL.INFORMAITON CONTAINED IN THE REPORTS INDICATE THAT THE PROBLEM MAY BE DIFFICULT TO DIAGNOSE, WITH SEVERAL OWNERS ALLEGING MULTIPLE DEALER SERVICE REPAIRS.ADVANCED COMPRESSION SET IS EVIDENT IN A HOSE REMOVED FROM THE MOST RECENT COMPLAINT VEHICLE.
EA96005 · Battery Explosions
Opened May 30, 1996 · Closed May 29, 1997
Status: closed (inferred from source dates) · Electrical System
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.
1995 Mercury Villager Problems, Complaints & Recalls | Skip That Year
Illustration