Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
1825–50K
3050–75K
1875–100K
16100–150K
8150K+
98 reports with mileage · 160 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports4 fire reports15 injury reports
What owners actually said
258 reports
80,000 miles · Feb 28, 2004
Seat Belts
THE DRIVERS SIDE SEAT BELT ON MY 99 MERCURY SABLE DOES NOT LATCH AND LOCK ALL THE TIME. IT GOES IN AND ACTS LIKE IT LATCHES (SEAT BELT LIGHT GOES OUT) UNTIL A FAIR AMOUNT OF FORCE IS APPLIED TO THE SEAT BELT AND IT RELEASE'S FROM THE SEAT BELT LATCH. I'VE HAD THIS HAPPEN MULTITUDES OF TIMES EVEN THOUGHT I TRY AND REMEMBER TO DOU…
Read full complaint
THE DRIVERS SIDE SEAT BELT ON MY 99 MERCURY SABLE DOES NOT LATCH AND LOCK ALL THE TIME. IT GOES IN AND ACTS LIKE IT LATCHES (SEAT BELT LIGHT GOES OUT) UNTIL A FAIR AMOUNT OF FORCE IS APPLIED TO THE SEAT BELT AND IT RELEASE'S FROM THE SEAT BELT LATCH. I'VE HAD THIS HAPPEN MULTITUDES OF TIMES EVEN THOUGHT I TRY AND REMEMBER TO DOUBLE CHECK THAT THE SEAT BELT IS SECURE.*AK
NHTSA ODI #10060011
Mileage unknown · Feb 12, 2004
Engine And Engine CoolingFire
THE VEHICLE CAUGHT FIRE IN THE ENGINE COMPARTMENT THEN BECAME FULLY ENGULFED. *PH *SC
NHTSA ODI #10058075
50,448 miles · Feb 11, 2004
Engine And Engine Cooling
WHILE DRIVING IN HEAVY RAIN STORM, ENGINE CRANKSHAFT PULLEY ASSY BROKE CAUSING THE LOSS OF POWER STEERING IMMEDIATELY, I STRUGGLED TO MAINTAIN CONTROL OF VEHICLE. I HAD REPAIRED AT LOCAL SHOP IN LONG ISLAND ,NY , MECHANIC SAID NEW REPLACEMENT UNIT WAS MUCH DIFFERENT THAN ORIGINAL INDICATING THAT THERE WAS PROBLEM WITH DESIGN OF…
Read full complaint
WHILE DRIVING IN HEAVY RAIN STORM, ENGINE CRANKSHAFT PULLEY ASSY BROKE CAUSING THE LOSS OF POWER STEERING IMMEDIATELY, I STRUGGLED TO MAINTAIN CONTROL OF VEHICLE. I HAD REPAIRED AT LOCAL SHOP IN LONG ISLAND ,NY , MECHANIC SAID NEW REPLACEMENT UNIT WAS MUCH DIFFERENT THAN ORIGINAL INDICATING THAT THERE WAS PROBLEM WITH DESIGN OF ORIGINAL UNIT.HAD I NOT BEEN ABLE TO STEER VEHICLE THERE COULD HAVE BEEN A COLLISION RESULTING IN INJURIES , ETC. I CHECKED RECALLS & THERE WERE NON RELATED TO THIS MECHANICAL FAILURE. I PAID $309.91 FOR REPAIRS TO VEHICLE. VIN# [XXX], I RETAINED BROKEN ORIGINAL PULLEY & BRACKET ASSEMBLY. *AK UPDATED 07/26/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10057026
58,000 miles · Feb 3, 2004
Seat Belts
SEAT BELT RETRACTORS ARE FAILING IN ORDER OF MOST FREQUENT USE (E.G. DRIVER, FRONT PASSENGER, REAR PASSENGERS). THE DRIVER'S BELT RETRACTOR FAILS TO PULL THE SEAT BELT BACK INTO THE COLUMNAR STORAGE AREA 100% OF THE TIME (FRONT PASSENGER BELT 50% AND REAR PASSENGERS ~10%). THIS PRESENTS A SAFETY HAZARD AS THE BELTS WILL NOT PRO…
Read full complaint
SEAT BELT RETRACTORS ARE FAILING IN ORDER OF MOST FREQUENT USE (E.G. DRIVER, FRONT PASSENGER, REAR PASSENGERS). THE DRIVER'S BELT RETRACTOR FAILS TO PULL THE SEAT BELT BACK INTO THE COLUMNAR STORAGE AREA 100% OF THE TIME (FRONT PASSENGER BELT 50% AND REAR PASSENGERS ~10%). THIS PRESENTS A SAFETY HAZARD AS THE BELTS WILL NOT PROVIDE THE LIFE SAVING TENSION REQUIRED DURING AN ACCIDENT. THE BELT HANGS LIMP OVER THE WEARER. SEAT BELTS ARE REQUIRED TO BE WORN BY LAW. YET, AUTO MANUFACTURERS ARE NOT REQUIRED TO WARRANTY THESE PARTS FOR THE LIFE OF THE CAR. THE GREAT MAJORITY OF MANUFACTURERS ONLY WARRANT SEAT BELTS FOR 3 YEARS OR 36000 MILES. AS CONSUMERS, ARE WE TO BELIEVE THAT THIS MEANS MANUFACTURERS ONLY EXPECT THE SEAT BELTS TO FUNCTION DURING THIS TIME PERIOD. THIS IS ABSURD AND SHOULD BE CHANGED VIA LEGISLATION REQUIRING AUTO MAKERS TO WARRANTY LEGALLY REQUIRED SAFETY DEVICES FOR THE LIFE OF THE CAR. IT WOULD FORCE MANUFACTURERS TO MAKE THESE PARTS TO LAST INSTEAD OF ENGINEERING THEM TO LAST UNTIL JUST AFTER THE WARRANTY PERIOD IS OVER.*AK
NHTSA ODI #10056392
Mileage unknown · Jan 29, 2004
Visibility
I OWN A 1999 MERCURY SABLE. WHILE I AM DRIVING, THE WINDSHIELD WIPERS TURN ON BY THEMSELVES. THIS IS A RECURRING PROBLEM THAT STARTED SOMETIME LAST FALL. TO TURN THEM OFF, I HAVE TO TURN THEM ON AND OFF SEVERAL TIMES.*AK
NHTSA ODI #10055173
Mileage unknown · Jan 17, 2004
Fuel System, Other
MY CAR WILL ONLY START SOMETIMES. IT DOES NOT GET FUEL TO THE FUEL BAR. THIS HAS HAPPENED SEVERAL TIMES. IT NEVER QUITS WHILE RUNNING. SOMETIMES IF YOU GO BACK A HALF HOUR LATER IT STARTS. *CB
NHTSA ODI #10054354
108,000 miles · Jan 15, 2004
Power Train
HESITATION IN TRANSMISSION. EXCESSIVE LEAK IN TRANS FLUID, MADE A LARGE PUDDLE. HAD A WOBBLE AS VEHICLE ACCELERATED. HAD FRONT TRANS SEAL AND AXLE SEALS REPLACE, AS WELL AS ONE AXLE
NHTSA ODI #10070794
58,500 miles · Jan 5, 2004
Seat Belts
I PURCHASED THE USED VEHICLE APRIL 03. EARLY AUGUST, I WENT OUT TO LUNCH WITH A FRIEND-WHEN HE ATTEMPTED TO PUT ON THE VEHICLE SEAT BELT IN THE FRONT PASSENGER SEAT IT WOULD NOT WORK. WE DROVE HIS CAR INSTEAD. I THOUGHT IT WAS A FLUKE. I DECIDED TO CHECK THE INTERNET AND LOCATED THIS PROBLEM AS A MANUFACTURER RECALL AND FIGURED …
Read full complaint
I PURCHASED THE USED VEHICLE APRIL 03. EARLY AUGUST, I WENT OUT TO LUNCH WITH A FRIEND-WHEN HE ATTEMPTED TO PUT ON THE VEHICLE SEAT BELT IN THE FRONT PASSENGER SEAT IT WOULD NOT WORK. WE DROVE HIS CAR INSTEAD. I THOUGHT IT WAS A FLUKE. I DECIDED TO CHECK THE INTERNET AND LOCATED THIS PROBLEM AS A MANUFACTURER RECALL AND FIGURED IT WOULD BE NO PROBLEM FOR THE DEALER TO TAKE CARE OF IT. THIS PROBLEM CONTINUED TO HAPPEN BUT BECAUSE OF MY WORK SCHEDULE I WAS UNABLE TO GET THE VEHICLE TO THE DEALER BECAUSE OF THE HOURS OF THE SERVICE DEPARTMENT. FROM AUGUST TO DATE NO ONE HAS BEEN ABLE TO RIDE IN THE FRONT SEAT. I WAS ON VACATION AND I CONTACTED THE DEALER TO SCHEDULE A SERVICE APPOINTMENT. I TOOK THE CAR IN ON 12/30/03 AND WAS TOLD THAT I NEEDED TO PAY A $75 DIAGNOSTIC FEE AS NO INFORMATION CAME UP FOR THIS VEHICLE INDICATING A RECALL OR A WARRANTY. THE WARRANTY SITUATION WAS CORRECTED BUT I RECEIVED A MESSAGE FROM TONIA COOPER (SERVICE DEPARTMENT) AFTER I FAXED OVER THE RECALL INFORMATION FROM NHTSA THAT MY VEHICLE WOULD NOT BE COVERED UNDER THE RECALL. I THOUGHT THIS WAS ABSURD; I AM EXPERIENCING THE SAME PROBLEM THAT IS NOTED ON ALL OF THE DOCUMENTATION OF THE RECALL BUT BECAUSE FORD NEGLECTED TO INCLUDE MY VIN NUMBER NO ONE WOULD HELP ME. WHAT'S WORSE IS THAT I CALLED FORDS' CUSTOMER RELATIONS ON 12/30/03 AND SPOKE WITH SYED WHO REFUSED TO GIVE ME A LAST NAME OR AN ID# AND HE TOLD ME THERE WAS NOTHING I COULD DO AND NO ONE OUTSIDE OF CUSTOMER RELATIONS AT THE DEALERSHIP THAT I COULD CONTACT TO GET THIS MATTER RESOLVED. I FIND IT MOST IRRITATIONG THAT NO ONE COULD CONCEIVE THE NOTION THAT THIS VIN# (& PERHAPS OTHERS) WERE ERRONEOUSLY OMITTED FROM THE RECALL. I LOOKED AT THE 3 COMPLAINTS FROM OTHER OWNERS & ONE HAS A VIN# VERY SIMILIAR TO MINE. THANK YOU FOR YOUR ASSISTANCE IN THIS MATTER, I ONLY WISH THAT I COULD HAVE RESOLVED THIS MATTER WITH FORD DIRECTLY. PASSENGER SAFETY & MICHIGAN'S "CLICK IT OR TICKET IT" LAW HAS MAKES THIS AN EXTREMEMLY IMPORTANT ISSUE!*AK
NHTSA ODI #10052381
Mileage unknown · Nov 7, 2003
Engine And Engine Cooling
PROBLEM FIRST NOTICED AS ENGINE OVERHEATED AND A COOLANT LEAK OCCURRED... DEBRIS IN COOLING SYSTEM CREATES A BLOCKAGE AND HEATER WORKS INTERMITTENTLY. STILL OVERHEATS AFTER RADIATOR FLUSHES TO CLEAN SYSTEM. I HAVE BEEN ADVISED BY THE MECHANIC TO EITHER SELL THE CAR OR REPLACE THE ENTIRE COOLING SYSTEM. *LA
NHTSA ODI #10045646
Mileage unknown · Sep 4, 2003
Seat Belts
PROBLEMS WITH SAFETY BELT BECOMING UNDONE AFTER BEING SECURED. *MR WHEN THE SEAT BELT LATCH WAS PUSHED INTO THE SOCKET FIRMLY IT OCCASIONALLY POPPED OUT. IT HAD TO BE PUSHED INTO POSITION THEN JUGGLED IN ORDER FOR IT TO LATCH CORRECTLY. THE BELT WOULD ALSO TIGHTEN SO SNUGLY ON THE OCCUPANT THAT THEY COULD NOT LEAN FORWAR…
Read full complaint
PROBLEMS WITH SAFETY BELT BECOMING UNDONE AFTER BEING SECURED. *MR WHEN THE SEAT BELT LATCH WAS PUSHED INTO THE SOCKET FIRMLY IT OCCASIONALLY POPPED OUT. IT HAD TO BE PUSHED INTO POSITION THEN JUGGLED IN ORDER FOR IT TO LATCH CORRECTLY. THE BELT WOULD ALSO TIGHTEN SO SNUGLY ON THE OCCUPANT THAT THEY COULD NOT LEAN FORWARD TO ADJUST THE DASH CONTROLS OR SEE THROUGH THE MIRRORS. *SCC *NLM
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequence & remedy
Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.
Consequence & remedy
Consequence: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.
Consequence & remedy
Consequence: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
PE02080 · Front Suspension Coil Spring Fracture
Opened Oct 22, 2002 · Closed Apr 29, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (2)
Suspension
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
1999 Mercury Sable Problems, Complaints & Recalls | Skip That Year
Illustration