NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
33 reportsClear category filter100,000 miles · Jan 10, 2005
Steering
REPORT OF CATASROPIC FAILURE OF STERING SYSTEM ON 1999 MECURY SABLE / RACK AND PINION GEAR FRACTURE/ SEEMS THERE IS MAJOR DEFALT WITH STERING SYSTEM, TOTAL CRACK IN FRAME /GEAR SYSTEM, ALL HAD TO BE REPLACED, DIDNT SEE ANY RECALLS, MECHANIC WHO FIXED SAY THIS NEED TO BE REPORTED TO MANAFUTURE, MILAGE IS 100K, NO ACCIDENTS IN V…
Read full complaint
REPORT OF CATASROPIC FAILURE OF STERING SYSTEM ON 1999 MECURY SABLE / RACK AND PINION GEAR FRACTURE/ SEEMS THERE IS MAJOR DEFALT WITH STERING SYSTEM, TOTAL CRACK IN FRAME /GEAR SYSTEM, ALL HAD TO BE REPLACED, DIDNT SEE ANY RECALLS, MECHANIC WHO FIXED SAY THIS NEED TO BE REPORTED TO MANAFUTURE, MILAGE IS 100K, NO ACCIDENTS IN VEHICLE, JUST FAILED WHILE DRIVING. *AK
NHTSA ODI #10106056
69,000 miles · Dec 12, 2004
Electrical SystemSteering
ON SEVERAL OCCASIONS, AFTER DRIVING MY 1999 MERCURY SABLE STATION WAGON IN MODERATE TO HEAVY RAIN, I LOSE POWER STEERING DURING TURNS. THE ALTERNATOR LIGHT ALSO COMES ON. I BELIEVE THE PROBLEM IS RELATED TO EXCESSIVE BELT SLIPPAGE FROM WATER. IT GOES AWAY IF I STOP FOR A FEW SECONDS TO LET THE BELT REGAIN TRACTION. THIS COND…
Read full complaint
ON SEVERAL OCCASIONS, AFTER DRIVING MY 1999 MERCURY SABLE STATION WAGON IN MODERATE TO HEAVY RAIN, I LOSE POWER STEERING DURING TURNS. THE ALTERNATOR LIGHT ALSO COMES ON. I BELIEVE THE PROBLEM IS RELATED TO EXCESSIVE BELT SLIPPAGE FROM WATER. IT GOES AWAY IF I STOP FOR A FEW SECONDS TO LET THE BELT REGAIN TRACTION. THIS CONDITION OCCURS UNEXPECTEDLY IS A RISK TO LOSS OF CONTROL DURING THE PERIOD OF TIME WITHOUT POWER STEERING. *JB
NHTSA ODI #10102810
36,270 miles · Dec 8, 2004
Seat BeltsSteering
REAR RIGHT PASSENGER SEAT BELT DID NOT RETRACT. DEALER STATED THE VEHICLE WAS NOT INCLUDED IN THE NHTSA RECALL 99V25000. ALSO, RACK AND PINION STEERING HAD TO BE REPLACED BECAUSE OF A SEAL LEAK.*AK *TC
NHTSA ODI #10101044
Mileage unknown · Sep 14, 2004
Steering
WHILE DRIVING STEERING WHEEL FEELS REAL LOOSE, ND MAKES A LOUD NOISE. DEALER REPLACED THE TIE ROD AT CONSUMER'S EXPENSE OF $200. *AK *MR
NHTSA ODI #10087493
37,500 miles · Aug 23, 2004
Steering
POWER STEERING FAILED WHILE DRIVING. CONSUMER HEARD A WINDING COMING FROM THE FRONT. CONSUMER PULLED OVER, LIFTED UP THE HOOD, AND NOTICED POWER STEERING FLUID WAS DRY INSIDE OF THE CANISTER PUMP. CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO A LOCAL REPAIR SHOP FOR STEERING FLUID. THEN, CONSUMER TOOK VEHICLE TO DEALER FOR …
Read full complaint
POWER STEERING FAILED WHILE DRIVING. CONSUMER HEARD A WINDING COMING FROM THE FRONT. CONSUMER PULLED OVER, LIFTED UP THE HOOD, AND NOTICED POWER STEERING FLUID WAS DRY INSIDE OF THE CANISTER PUMP. CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO A LOCAL REPAIR SHOP FOR STEERING FLUID. THEN, CONSUMER TOOK VEHICLE TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT RACK PINION FAILED, AND NEEDED TO BE REPLACED. CONSUMER INFORMED THE MECHANIC THAT PROBLEM RECURRED. *AK
NHTSA ODI #10089469
67,099 miles · Jul 16, 2004
Steering
VEHICLE IS 1999 MERCURY SABLE,POWER STEERING PUMP STARTED MAKING NOISE. EXAMINING PUMP SHOWED NO LEAKS ALTHOUGH FLUID WAS LOW. FLUID ADDED TO PROPER LEVEL. WITHIN DRIVING 2 MILES PUMP AGAIN MADE NOISE. BACKING UP CAR ALLOWED VISUAL CONFIRMATION OF FLUID LEAK ON GROUND. ALTHOUGH SOME FLUID WAS IN STEERING PUMP, POWER ASSIST …
Read full complaint
VEHICLE IS 1999 MERCURY SABLE,POWER STEERING PUMP STARTED MAKING NOISE. EXAMINING PUMP SHOWED NO LEAKS ALTHOUGH FLUID WAS LOW. FLUID ADDED TO PROPER LEVEL. WITHIN DRIVING 2 MILES PUMP AGAIN MADE NOISE. BACKING UP CAR ALLOWED VISUAL CONFIRMATION OF FLUID LEAK ON GROUND. ALTHOUGH SOME FLUID WAS IN STEERING PUMP, POWER ASSIST WAS LOST WHILE DRIVING MAKING THE CAR HARD TO STEER AND CONTROL. TRIP TO MECHANIC REVEALED RACK AND PINION FAILURE AND MASSIVE FLUID LEAK. MILAGE ON VEHICLE IS 67,100 MILES. MECHANIC FEELS PREMATURE FAILURE SHOULD NOT HAVE OCCURED AT 67K MILES. PRICE TO REPLACE IS APPROX $500 TO $800 SHOULD HYDRAULIC HOSES ALSO NEED TO BE REPLACED. *AK
NHTSA ODI #10081232
37,800 miles · Mar 11, 2004
Steering
THE STEERING RACK FAILED WITH NOT VISIBLE INDICATION OF FLUID LOSS. THE PLUG ON THE RACK BLEW-OUT WITHOUT WARNING, CAUSING THE STEERING TO BECOME MANUAL REQUIRING VEHICLE TOWING. THE CAR HAS BEEN DUTIFULLY MAINTAINED WITH NO INDICATION OF FAILURE WHEN INSPECTED. FORD MOTOR CO. HAS DENIED ANY RESPONSIBILITY.*AK
NHTSA ODI #10061971
Mileage unknown · Aug 1, 2003
Engine And Engine CoolingExterior LightingPower TrainCrashInjury
PROBLEMS WITH ABS. *MR THE VEHICLE WAS IN TWO ACCIDENTS DUE TO THE INABILITY TO CONTROL THE VEHICLE DURING NORMAL DRIVING CONDITIONS, WHERE THE ABS DID NOT WORK. THE VEHICLE WAS IN FOR REPAIR 7 TIMES. THE FOLLOWING ARE REPAIRS AND OR PROBLEMS THE VEHICLE EXPERIENCED: TORQUE CONVERTER REPLACED AFTER TRANSMISSION FLUID WAS F…
Read full complaint
PROBLEMS WITH ABS. *MR THE VEHICLE WAS IN TWO ACCIDENTS DUE TO THE INABILITY TO CONTROL THE VEHICLE DURING NORMAL DRIVING CONDITIONS, WHERE THE ABS DID NOT WORK. THE VEHICLE WAS IN FOR REPAIR 7 TIMES. THE FOLLOWING ARE REPAIRS AND OR PROBLEMS THE VEHICLE EXPERIENCED: TORQUE CONVERTER REPLACED AFTER TRANSMISSION FLUID WAS FOUND LOW, EXHAUST LEAK FIXED, WASHER FLUID WOULD SPRAY WHEN THE TURN SIGNAL AND LIGHTS WERE ON, SHAKING WHEN THE BRAKES WERE APPLIED/RESURFACED ROTORS, TRUNK LEAKED WATER, REPLACED MULTI-FUNCTION SWITCH TO FIX WASHER FLUID PROBLEM, ABS NOT WORKING WHEN THERE WAS A PANIC STOP, LEFT AND RIGHT SPINDLE ASSEMBLY WAS REPLACED, FRONT END ROTORS WERE REPLACED AGAIN, WHEEL ALIGNMENT, THE ABS DID NOT ENGAGE AND CAUSED AN ACCIDENT, AND REPLACED LEFT SIDE OUTER TIE ROD END. *SCC *JB
NHTSA ODI #10031939
66,000 miles · Apr 8, 2003
Steering
A LOUD NOISE CAME FROM THE REAR OF VEHICLE, AND THE VEHICLE LOST POWER STEERING FLUID. THE PROBLEM WAS DETERMINED TO BE A CRACKED STEERING RACK AND WAS REPLACED. *JB *SCC
NHTSA ODI #10015443
Mileage unknown · Mar 26, 2003
Steering
DEFECTIVE RACK AND PINION STEERING CAUSED NOISE WHILE DRIVING. *AK *NLM
NHTSA ODI #10011437
Official recalls
5Jul 15, 2004
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Sep 20, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequence & remedy
Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
Nov 9, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.
Consequence & remedy
Consequence: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.
Sep 1, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.
Aug 25, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.
Consequence & remedy
Consequence: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
PE02080 · Front Suspension Coil Spring Fracture
Opened Oct 22, 2002 · Closed Apr 29, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (2)
Suspension
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Illustration