Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Equipment. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports1 fire reports0 injury reports

What owners actually said

4 reports

Mileage unknown · Dec 23, 2023

EngineService BrakesUnknown Or OtherFire

Read full complaint

At approximately 104 miles into a recent trip in our RV, while traveling at highway speed under cruise control, we noticed a strange odor. Almost at the same moment we immediately lost engine and braking power. The check engine light came on. We then noticed smoke coming from the engine compartment and noxious fumes had begun to enter the cabin area. After pulling to the side of the highway by use of the emergency brake, we were able to exit the vehicle. Flames could be seen coming from the engine bay and quickly engulfed the RV giving my wife, myself, and our dog only enough time to exit and get a safe distance away. The RV burned to basically nothing but the frame left.

NHTSA ODI #11561668

15,000 miles · Apr 27, 2022

Electrical System

Read full complaint

The contact owns a 2019 Mercedes-Benz Sprinter 3500. The contact stated that while seated in the swivel chair inside the vehicle, she turned the swivel chair around to watch the television and several unknown warning lights started flashing on and off and the vehicle would not start. The contact stated that an independent mechanic was contacted and arrived at the residence to service the vehicle. An unknown repair was performed and the vehicle was able to be started. The vehicle was taken to the local dealer and the contact was informed that the seat wiring harness needed to be replaced. The vehicle was repaired however, the contact was concerned that by using electrical tape in the repair, the repair was not properly completed. The contact stated that while researching the failure, she became aware of NHTSA Campaign Number: 21V410000 (Electrical System, Back Over Prevention) which she related to the failure. The manufacturer was notified of the failure. The approximate failure mileage was 15,000.

NHTSA ODI #11462472

15,000 miles · Dec 17, 2021

EquipmentTrailer Hitches

Read full complaint

The contact owns a 2020 Tiffin Wayfarer Motorhome built on a 2019 Mercedes-Benz Sprinter 3500/4500 chassis. The contact stated that while driving approximately 55-65 MPH, the water tank fell onto the exhaust system. The contact received notification of NHTSA campaign numbers: 21V610000 (Trailer Hitches) and 21V753000 (Equipment). The contact called the local dealer who stated additional hours were needed to complete the repairs. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was notified however, declined the repairs. Parts distribution disconnect. The approximate failure mileage was 15,000.

NHTSA ODI #11444190

21,130 miles · Mar 25, 2021

Power TrainCrash

ACCIDENT ON 10/15/2020, UNOCCUPIED VEHICLE ROLLED FROM A PARKED POSITION DOWN A HILL AND STRUCK A HOUSE. THE VEHICLE IS DESIGNED TO HAVE THE TRANSMISSION AUTOMATICALLY SHIFT TO PARK WHEN THE DRIVER'S DOOR IS OPEN, AND THIS SYSTEM WAS FUNCTIONAL AT THE TIME OF THE INCIDENT. DISENGAGEMENT OF THE PARKING PAWL WAS THE CAUSE OF THE…

Read full complaint

NHTSA ODI #11404891

Official recalls

23V100000 · Electrical System:wiring:fuses And Circuit Breakers; Visibility:defroster/defogger/hvac System:fan/motor

Feb 17, 2023

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter VS30 and Freightliner Sprinter VS30 vehicles. The heating, ventilation, and air conditioning (HVAC) blower motor circuit may be inadequate, which can allow the wiring harness to overheat.

Consequence & remedy

Consequence: A wiring harness that overheats increases the risk of a fire.

Remedy: Owners are advised to only operate the HVAC front blower in manual (not automatic) mode whenever the engine is on. Do not use the maximum blower or lowest/highest temperature settings until the remedy is performed. Dealers will relocate and replace the fuse and wiring harness, free of charge. Owner notification letters were mailed June 26, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is 8297010.

Additional source detail variants (2)

Electrical System:wiring:fuses And Circuit Breakers

Consequence: A wiring harness that overheats increases the risk of a fire.

Remedy: Owners are advised to only operate the HVAC front blower in manual (not automatic) mode whenever the engine is on. Do not use the maximum blower or lowest/highest temperature settings until the remedy is performed. Dealers will relocate and replace the fuse and wiring harness, free of charge. Owner notification letters were mailed June 26, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is 8297010.

Visibility:defroster/defogger/hvac System:fan/motor

Consequence: A wiring harness that overheats increases the risk of a fire.

21V360000 · Electronic Stability Control (esc):control Module:software

May 17, 2021

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter vehicles equipped with the camper upfit option. The Electronic Stability Control (ESP) software was not updated for vehicles with a higher center of gravity.

Consequence & remedy

Consequence: The ESP may not respond as intended during certain driving scenarios, increasing the risk of a crash.

Remedy: Dealers will update the software, free of charge. Owner notification letters were mailed on July 2, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3HOLAPLI.

21V241000 · Steering:hydraulic Power Assist:hose, Piping, And Connections

Apr 6, 2021

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach and cause hydraulic fluid to leak.

Consequence & remedy

Consequence: A hydraulic fluid leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will install a screw-type clamp, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is NV3LETULPX.

21V237000 · Equipment:other:labels

Apr 5, 2021

Daimler Vans USA, LLC (DVUSA) is recalling one 2019 Mercedes Benz Sprinter vehicle. The VIN number listed on the vehicle's dash board, certification label, and body-in-white do not match. As such, this vehicle fails to comply with the requirements of 49 CFR Part 567, "Certification."

Consequence & remedy

Consequence: The consumer may not receive information about open safety-recall campaigns, increasing the risk of injury, a crash, or fire.

Remedy: DVUSA will notify the owner, and a dealer will replace the VIN listed on the vehicle's dash board and certification label, free of charge. The recall began May 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3VINCHA.

20V756000 · Equipment:other:owners/service/other Manual

Dec 8, 2020

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter vehicles. These vehicles may have been delivered with a version of the printed and digital operator's manual that may be inaccurate and/or incomplete.

Consequence & remedy

Consequence: If the operator relies on the provided owner's manual, the information about vehicle functions and other safety relevant information may be inaccurate and/or incomplete, which could lead to improper operation of the vehicle and potentially increase the risk of a crash or injury.

Remedy: DVUSA will notify owners, and dealers will replace the printed version of the operator's manual with the latest version and update the software of the digital version, free of charge. DVUSA distributed owners an interim notification on January 22, 2021. The recall began March 17, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3PRIDIBA.

20V453000 · Fuel System, Gasoline:delivery:fuel Pump

Aug 4, 2020

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The affected Sprinter vehicles from platform 907 (VS30) might have an open port on the fuel delivery module (fuel pump).

Consequence & remedy

Consequence: An open port on the fuel pump module may result in fuel leaking onto the roadway, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will check for the additional nozzle on the fuel pump and install a closure onto the nozzle as needed, free of charge. The recall began September 18, 2020. Owners may contact DVUSA customer service at 1-800-367-6372. MBUSA's number for this recall is VS3KRASTUF.

20V426000 · Suspension:rear:springs:leaf Spring Assembly:leaf

Jul 27, 2020

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The incorrect leaf spring shims may have been installed between the rear axle and the leaf springs possibly affecting the vehicle's handling. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Consequence & remedy

Consequence: The incorrect leaf spring shims may negatively affect vehicle handling, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will replace the leaf spring shims on both sides, renew the spring brackets, check the rubber buffers for wear, renewing them if necessary, and adjust the headlamps, free of charge. The manufacturer has not yet provided a schedule for recall notification. DVUSA issued owners an interim notification on September 18, 2020. The recall began October 1, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LEFSPRI.

20V427000 · Suspension:front:stabilizer Bar; Suspension:rear

Jul 27, 2020

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter vehicles. The chassis may be missing the additional stabilization required for its cargo capacity. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Consequence & remedy

Consequence: If the vehicle is operated without the additional stabilization, vehicle handling could be affected, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will upgrade the chassis by replacing the stabilizer bar on the front axle and replacing shock absorbers and installing a stabilizer bar on the rear axle, free of charge. DVUSA issued owners an interim notification on September 18, 2020. The recall began October 1, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FAHRBA.

Additional source detail variants (2)

Suspension:rear

Consequence: If the vehicle is operated without the additional stabilization, vehicle handling could be affected, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will upgrade the chassis by replacing the stabilizer bar on the front axle and replacing shock absorbers and installing a stabilizer bar on the rear axle, free of charge. DVUSA issued owners an interim notification on September 18, 2020. The recall began October 1, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FAHRBA.

Suspension:front:stabilizer Bar

Consequence: If the vehicle is operated without the additional stabilization, vehicle handling could be affected, increasing the risk of a crash.

20V322000 · Air Bags:side/window; Electrical System:wiring; Seats

Jun 3, 2020

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Spinter vans (platform 970 (VS30)), equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.

Consequence & remedy

Consequence: If the wiring harness is damaged, the side air bag within the seat may deploy inadvertently or not deploy as designed in the event of a crash, increasing the risk of injury to vehicle occupants.

Remedy: DVUSA will notify owners, and an authorized Mercedes-Benz or Freightliner Sprinter dealer will inspect the wire harness routing for both front seats and will repair the wiring and add clips or cable ties as needed, free of charge. The recall began August 24, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSIK.

Additional source detail variants (3)

Seats

Consequence: If the wiring harness is damaged, the side air bag within the seat may deploy inadvertently or not deploy as designed in the event of a crash, increasing the risk of injury to vehicle occupants.

Remedy: DVUSA will notify owners, and an authorized Mercedes-Benz or Freightliner Sprinter dealer will inspect the wire harness routing for both front seats and will repair the wiring and add clips or cable ties as needed, free of charge. The recall began August 24, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSIK.

Air Bags:side/window

Electrical System:wiring

20V180000 · Equipment:other:owners/service/other Manual

Mar 26, 2020

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The Operator's Manual may not contain the correct information about how the automatic parking function ("Auto-P") operates.

Consequence & remedy

Consequence: If the driver relies on the Auto-P function as described in the Operator's Manual, vehicle rollaway or movement may occur, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will provide the correct description of the Auto-P function for the Operator's Manual, free of charge. The recall began May 18, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BAUTOP.

20V181000 · Service Brakes, Air:supply:hoses, Lines/piping, And Fittings; Structure:frame And Members:underbody Shields

Mar 25, 2020

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rear part of the fender liner on the front axle may contact and chafe the brake hose, possibly resulting in a loss of brake fluid.

Consequence & remedy

Consequence: Loss of brake fluid can extend the distance needed to stop the vehicle, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect and replace the brake hoses, as necessary. Additionally, the fender liners will be modified. All services will be performed free of charge. The recall began May 8, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BRADVER.

Additional source detail variants (2)

Structure:frame And Members:underbody Shields

Consequence: Loss of brake fluid can extend the distance needed to stop the vehicle, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect and replace the brake hoses, as necessary. Additionally, the fender liners will be modified. All services will be performed free of charge. The recall began May 8, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BRADVER.

Service Brakes, Air:supply:hoses, Lines/piping, And Fittings

Consequence: Loss of brake fluid can extend the distance needed to stop the vehicle, increasing the risk of a crash.

19V908000 · Equipment

Dec 19, 2019

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The lashing rails on the side walls may not have been properly installed, possibly resulting in the lashing rails detaching.

Consequence & remedy

Consequence: If the lashing rails disconnect, the cargo could become unsecured, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will correctly affix the lashing rails to the side walls, free of charge. DVUSA issued owners an interim notification on February 7, 2020. The recall began April 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3ZUSCHI.

19V121000 · Exterior Lighting:fog Lights

Feb 22, 2019

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter VS30 vehicles equipped with LED rear fog lights. The lights may not illuminate, despite the rear fog light switch being turned on.

Consequence & remedy

Consequence: The lack of functioning rear fog lamps prevents the enhanced visibility of the vehicle to other drivers on the road, increasing the risk of crash.

Remedy: DVUSA will notify owners, and dealers will update the software settings of the control unit body controller, free of charge. The recall began April 18, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.

19V070000 · Steering:gear Box:shaft Sector

Jan 31, 2019

Daimler Vans USA, LLC (Daimler Vans) is recalling certain 2019 Mercedes-Benz Sprinter VS30 vehicles. The steering shaft that connects to the steering gear may disconnect without warning.

Consequence & remedy

Consequence: The steering shaft disconnecting from the steering gear can cause a sudden loss of steering control, increasing risk of a crash.

Remedy: Daimler Vans will notify owners, advising them to stop driving the vehicle immediately. Dealers will inspect the bolts connecting the steering shaft to the steering gear, fully tightening and/or adjusting them, as necessary, free of charge. The recall began February 15, 2019. Owners may contact Daimler Van's customer service at 1-800-367-6372. Daimler Van's number for this recall is 2019010006.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE21019 · Vehicle Rolls Away While In Park

Opened Aug 2, 2021 · Closed May 27, 2022

Status: closed (inferred from source dates) · Power Train:automatic Transmission

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) opened this PE after receiving 11 Vehicle Owner Questionnaires (VOQs) alleging that Model Year (MY) 2019 Mercedes-Benz (MB) Sprinter vans, configured for use as Amazon delivery vehicles or ambulances, roll away shortly after being shifted to park using the Auto-P function. A rollaway vehicle with no operator behind the steering wheel could potentially strike pedestrians, moving or parked vehicles or buildings, resulting in injury, fatality and/or property damage. Analysis of data provided by MB in response to the ODI Information Request (IR) letter showed a high failure rate. Following discussions with ODI about the failures, MB decided to conduct a safety recall. On December 15, 2021, Daimler Vans USA, LLC filed recall 21V-972 covering 48,400 model year (MY) 2019-2020 Mercedes-Benz (MB) Sprinter vans. With recall 21V-972, this investigation is closed. The affected vehicle population determined by MB is Sprinter vehicles (VS30, Platform 907) produced between June 5, 2018 and November 30, 2020 with a manual parking brake and a 7-speed automatic transmission that was manufactured between May 1, 2018 and October 31, 2019, in the Hedelfingen transmission plant in Germany.Further use of Agency resources does not appear to be warranted. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers:11360500, 11404893, 11404894, 11360505, 11404417, 11405798, 11405804, 11404969, 11404838, 11404891, 11415509, 11428353, 11428296, 11298470, 11428219, 11405803, 11427068, 11428216, 11428296, 11429905, 11447877, 11452051

Additional source detail variants (2)

Power Train:automatic Transmission