NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
10 reportsClear category filterMileage unknown · Oct 24, 2025
Electrical System
How does the digital display suddenly disappear from your dashboard? Mercedes has lost its respect for being a High Quality brand. Too many recalls,. Too many issues that vehicles less costly never have such as 1. Out of alignment at 0 mileage resulting in worn out tires at 12k miles. Realignment that was useless at mb specs res…
Read full complaint
How does the digital display suddenly disappear from your dashboard? Mercedes has lost its respect for being a High Quality brand. Too many recalls,. Too many issues that vehicles less costly never have such as 1. Out of alignment at 0 mileage resulting in worn out tires at 12k miles. Realignment that was useless at mb specs resulting in third set of tires. 2. Pcv regulator valve triggers engine code p052e which means a $3000 repair bill that's not covered on commercial vans but covered on passenger vans with the same engine. 3. Digital display on dashboard gone. Yet cars in the 60's with digital screens still working. Thanks Mercedes for the Quality and commitment you have to your customers.
NHTSA ODI #11695398
Mileage unknown · Jun 22, 2024
Electrical SystemEngine
Code P052E-71 Valve for crankcase ventilation has a malfunction Code P06DA-00 Actuation of the valve in the combustion engine has an electrical fault or open circuit. These codes have been reported on too many times on forums to not have these issues recalled and fixed and paid for by Mercedes. This expensive problem should n…
Read full complaint
Code P052E-71 Valve for crankcase ventilation has a malfunction Code P06DA-00 Actuation of the valve in the combustion engine has an electrical fault or open circuit. These codes have been reported on too many times on forums to not have these issues recalled and fixed and paid for by Mercedes. This expensive problem should not have occurred with such little mileage and have to be fixed by the consumer
NHTSA ODI #11595927
Mileage unknown · Aug 31, 2023
Electrical SystemEngine
CHECK ENGINE LIGHT checked and diagnostic code P052E71 showed that the Valve for Crankcase Ventilation has a malfunction. The actuator is blocked, P06DA00 the Actuation of the valve of the oil pump in the combustion engine has an electrical fault or open circuit. The problem is prolific on the Metris vans and the repair costs ex…
Read full complaint
CHECK ENGINE LIGHT checked and diagnostic code P052E71 showed that the Valve for Crankcase Ventilation has a malfunction. The actuator is blocked, P06DA00 the Actuation of the valve of the oil pump in the combustion engine has an electrical fault or open circuit. The problem is prolific on the Metris vans and the repair costs extremely high for such a lemon sensor and can cause catastrophic failure and damage to the engine.
NHTSA ODI #11541905
Mileage unknown · Jun 29, 2023
Air BagsElectrical SystemSeat Belts
The wiring harness for the seatbelt pretensioner wore through in its normal factory installed location and shorted out, causing the air bag light to come on. No modifications have ever been done to the vehicle to disturb this path and causing wire chafing. It is highly doubtful the pretensioner would have worked either, as 3 o…
Read full complaint
The wiring harness for the seatbelt pretensioner wore through in its normal factory installed location and shorted out, causing the air bag light to come on. No modifications have ever been done to the vehicle to disturb this path and causing wire chafing. It is highly doubtful the pretensioner would have worked either, as 3 out of the 4 wires had their insulation worn through. This was diagnosed by the dealership and video of the issue was provided at https://r7788463.m.reyrey.net/app/?ref=aO9XDMndQtSq554Czq1dQg%3D%3D&sys=e1b63ec6-8626-424a-b7a7-80e9ade1db58 I have had this fixed, but the text messages with the dealership lead me to believe that this is not the first time they have seen and repaired the issue.
NHTSA ODI #11529629
Mileage unknown · Oct 31, 2022
Electrical SystemLane Departure
Electrical failure by mercedes metris is intermittent but frequent. There are multiple times where car will indicate that blind spot alert is inoperable. Similarly, it appears that indicator on same side and automatic door locks on that side do not work. It will sometimes reboot and work intermittently for a period of time be…
Read full complaint
Electrical failure by mercedes metris is intermittent but frequent. There are multiple times where car will indicate that blind spot alert is inoperable. Similarly, it appears that indicator on same side and automatic door locks on that side do not work. It will sometimes reboot and work intermittently for a period of time before recurring.
NHTSA ODI #11491608
Mileage unknown · Aug 6, 2021
Electrical SystemService BrakesWheels
Two failures of Wheel Speed Sensors. Right Front was first and just caused the computer to shut down anti lock breaking system. Most recent was Left Rear and caused transimission to go into “Limp”
NHTSA ODI #11428050
55,000 miles · Jan 3, 2020
Electrical SystemFire
BATTERY CAUGHT FIRE AND MELTED DOWN. VEHICLE WAS DRIVEN FOR ABOUT 2.5-3HRS ON 12/26 AND THEN PARKED FOR 2 HRS, WHEN I WENT TO START VEHICLE IT WAS TOTALLY DEAD, ALL ELECTRONICS BLACK AND CAR WOULD NOT TURN OVER, I THEN NOTICES A SMALL AMOUNT OF SMOKE COMING FROM PASSENGER SEAT WHERE BATTERY IS STORED. I EXITED THE VEHICLE THINKI…
Read full complaint
BATTERY CAUGHT FIRE AND MELTED DOWN. VEHICLE WAS DRIVEN FOR ABOUT 2.5-3HRS ON 12/26 AND THEN PARKED FOR 2 HRS, WHEN I WENT TO START VEHICLE IT WAS TOTALLY DEAD, ALL ELECTRONICS BLACK AND CAR WOULD NOT TURN OVER, I THEN NOTICES A SMALL AMOUNT OF SMOKE COMING FROM PASSENGER SEAT WHERE BATTERY IS STORED. I EXITED THE VEHICLE THINKING IT WAS JUST A SMALL SHORT AND WOULD HAVE IT TOWED. I THEN NOTICED SMOKE BILLOWING OUT OF VEHICLE SO CALLED 911 AND FIRE DEPT CAME OUT, BATTERY WAS LITERALLY MELTING, THE FIREMEN WERE ABLE TO DISCCONECT BATTERY AND STOP THE MELTDOWN PREVENTING THE CAR FROM GOING UP IN FLAMES, I CAN ONLY IMAGINE WHAT WOULD HAVE HAPPENED WHILE DRIVING.
NHTSA ODI #11296913
9,000 miles · Jun 10, 2017
Electrical System
I HAVE A 2016 METRIS PASSENGER VAN WITH 14000 MILES THAT THE MECHANICAL/ANALOG SPEEDOMETER SHOWS INCORRECT SPEED SOMETIMES. IT ONLY HAPPENS AFTER THE VAN HAS BEEN TRAVELING WITH SPEEDS OVER 60 MPH + I NOTICE THE SPEEDOMETER SHOWING ABOUT A 20 MPH SLOWER SPEED, THEN OVER A FEW MIN. THE SPEED SLOWLY KEEPS DROPPING UNTIL 0 MPH. T…
Read full complaint
I HAVE A 2016 METRIS PASSENGER VAN WITH 14000 MILES THAT THE MECHANICAL/ANALOG SPEEDOMETER SHOWS INCORRECT SPEED SOMETIMES. IT ONLY HAPPENS AFTER THE VAN HAS BEEN TRAVELING WITH SPEEDS OVER 60 MPH + I NOTICE THE SPEEDOMETER SHOWING ABOUT A 20 MPH SLOWER SPEED, THEN OVER A FEW MIN. THE SPEED SLOWLY KEEPS DROPPING UNTIL 0 MPH. THE TOTAL TIME TO 0 MPH IS ABOUT 15 MIN. AFTER COMING TO A COMPLETE STOP THE SPEEDOMETER FUNCTIONS PROPERLY. ONLY THE MECHANICAL SPEEDOMETER IS AFFECTED, THE DIGITAL DISPLAYS CORRECT SPEED. THIS HAS HAPPENED 10 TIMES THAT I KNOW OF.
NHTSA ODI #10994279
1,800 miles · Jun 8, 2017
Electrical System
THE REARVIEW CAMERA FROZE WHILE I WAS BACKING UP. BY "FROZE" I MEANT THE PICTURE BECAME STATIC WHILE THE VAN WAS MOVING BACK. THIS IS VERY DANGEROUS BECAUSE IT WILL MISLEAD THE DRIVER ON WHAT'S OR WHAT'S NOT ON THE PATH OF MOVING DIRECTION. THE ISSUE PERSIST WHEN I MOVED THE CAR BACK AND FORTH. IT WENT AWAY AFTER PARKING THE…
Read full complaint
THE REARVIEW CAMERA FROZE WHILE I WAS BACKING UP. BY "FROZE" I MEANT THE PICTURE BECAME STATIC WHILE THE VAN WAS MOVING BACK. THIS IS VERY DANGEROUS BECAUSE IT WILL MISLEAD THE DRIVER ON WHAT'S OR WHAT'S NOT ON THE PATH OF MOVING DIRECTION. THE ISSUE PERSIST WHEN I MOVED THE CAR BACK AND FORTH. IT WENT AWAY AFTER PARKING THE VAN IN GARAGE FOR A FEW HOURS. I AM VERY CONCERNED THAT IT MAY HAPPEN AGAIN AND MAY CAUSE SERIOUS ACCIDENCE.
NHTSA ODI #10993981
15,000 miles · Feb 21, 2017
Electrical SystemElectronic Stability Control (esc)Service Brakes
MERCEDES CLAIMES THAT THE METRIS IS ABLE TO TOW 5000LBS. WE BOUGHT THE VEHICLE NEW WITH THE TOW PACKAGE FACTORY INSTALLED. MERCEDES NEVER DISCLOSED THE FACT THAT IT'S WIRING HARNESS INCLUDED IN THE PACKAGE DOES NOT OPERATE ELECTRIC TRAILER BRAKES AND THAT NO FACTORY OR THIRD PARTY OPTION IS AVAILABLE. WE ALMOST HAD AN ACCIDENT D…
Read full complaint
MERCEDES CLAIMES THAT THE METRIS IS ABLE TO TOW 5000LBS. WE BOUGHT THE VEHICLE NEW WITH THE TOW PACKAGE FACTORY INSTALLED. MERCEDES NEVER DISCLOSED THE FACT THAT IT'S WIRING HARNESS INCLUDED IN THE PACKAGE DOES NOT OPERATE ELECTRIC TRAILER BRAKES AND THAT NO FACTORY OR THIRD PARTY OPTION IS AVAILABLE. WE ALMOST HAD AN ACCIDENT DUE TO OUR INABILITY TO STOP QUICKLY ENOUGH. THATS HOW WE FOUND OUT THAT THE FACTORY INSTALLED TRAILER WIRING HARNESS DOES NOT OPERATE ELECTRIC BRAKES. MERCEDES SHOULD HAVE WARNED US ABOUT THIS ISSUE. THE FACTORY TRAILER WIRING HARNESS INCLUDES A 7 WIRE CONNECTOR, BUT IS ONLY WIRED FOR 6. IT CONTROLS BRAKE LIGHTS,TURN SIGNALS, RUNNING LIGHTS BUT NOT ELECTRIC BRAKES. I FILED A COMPLAINT WITH MERCEDES CORPORATE AND STATED HOW THIS IS A SAFETY ISSUE. CUSTOMERS MAY WRONGLY ASSUME THAT THEIR ELECTRIC TRAILER BRAKES ARE BEING ACTIVATED WHEN APPLYING THE VEHICLES BRAKES. WITHOUT TRAILER BRAKES, MOST TOW PAYLOADS ARE LIMITED TO 2500LBS. 5000LBS IS WAY BEYOND THE SAFE LIMIT. MERCEDES STATED THAT THERE IS NO WAY FOR THE METRIS TO ACTIVATE ELECTRIC BRAKES. I BELIEVE THAT MERCEDES NEEDS TO WARN CUSTOMERS OF THIS SPECIFIC DESIGN FLAW. MOST LIGHT DUTY TRAILERS AND CAMPERS IN THE USA USE ELECTRIC BRAKES. OUR ALMOST ACCIDENT HAPPENED ON THE I35 SOUTH OF WACO TX. WE WERE AT HIGHWAY SPEED WHEN THE TRAFFIC CAME TO A SUDDEN STOP. LUCKILY WE HAD A LARGE ENOUGH DISTANCE BETWEEN US AND THE CARS STOPPING AHEAD. WE HAD A CAR AT THE LAST MOMENT SWERVE INTO OUR LANE AND STOP. NOW WE WERE TRYING TO COME TO AN EMERGENCY STOP. WE HAD TO DEPART OUR LANE TO KEEP FROM REAR ENDING THE CAR. WE LATER FOUND OUT THAT OUR TRAILER BRAKE WE NOT BEING ACTIVATED AND THAT WAS THE CAUSE OF OUR INCREASED STOPPING DISTANCE.
NHTSA ODI #10956097
Official recalls
13Jul 7, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2018 Mercedes-Benz Metris vans. The value for the maximum combined load weight capacity of the tires is incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire and Loading Information."
Consequence & remedy
Consequence: An overloaded vehicle may cause tire failure, increasing the risk of a crash.
Remedy: Dealers will install corrected labels on the B-pillar and fuel filler door. Dealers will also inspect and replace incorrect tires, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed beginning April 19, 2024. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2LASTRE.
Feb 22, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2018 Mercedes-Benz Metris vehicles. A defective memory chip in the rearview camera may cause the display image to freeze.
Consequence & remedy
Consequence: A frozen rearview image does not show the live view of what is currently behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed February 10, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2RU54KAM.
Feb 8, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2021 Mercedes-Benz Metris vehicles. The brake fluid reservoir may be incorrectly mounted, which can allow it to detach.
Consequence & remedy
Consequence: A detached brake fluid reservoir can leak brake fluid, increasing the risk of a crash.
Remedy: Dealers will inspect and repair the brake fluid reservoir mounting, as necessary, free of charge. Owner notification letters were mailed on May 2, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2BE42BRE.
Feb 5, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2020 Mercedes-Benz Metris and 2019-2020 Mercedes-Benz Sprinter vehicles. The software design of the communication module may fail to communicate the correct vehicle location for the emergency call system (eCall) in the event of a crash.
Consequence & remedy
Consequence: Failure of the eCall system may result in emergency responders being dispatched to the wrong location, increasing the risk of injury following a crash.
Remedy: DVUSA will notify owners, and dealers will update the software communication module for the automatic emergency call system, free of charge. The recall began on May 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSXHERMPOS.
Oct 8, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2019 Mercedes-Benz Metris vehicles. The integrated backup battery compartment located underneath the front passenger's seat may not have its own cover, potentially exposing the battery when the seat is moved forward.
Consequence & remedy
Consequence: If conductive material, such as metal, unintentionally drops into the opening and contacts the terminals on the battery, an electrical short can occur, increasing the risk of a fire.
Remedy: DVUSA will notify owners, and Mercedes-Benz dealers will install covers over the battery compartment area, free of charge. DVUSA issued owners an interim notification on December 2, 2019. The recall began March 9, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2SITZAB.
Apr 10, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Metris vehicles sold, or ever registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington DC, West Virginia and Wisconsin. The aluminum bolts that attach the power steering gear assist motor to the gear housing may corrode and fracture causing a reduction or complete loss of power steering assist.
Consequence & remedy
Consequence: Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the aluminum bolts with steels bolts, free of charge. DTNA issued owners an interim notification on June 3, 2019. The recall began November 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2SCHRALU.
Additional source detail variants (2)
Steering:electric Power Assist System
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Metris vehicles sold, or ever registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington DC, West Virginia and Wisconsin. The aluminum bolts that attach the power steering gear assist motor to the gear housing may corrode and fracture causing a reduction or complete loss of power steering assist.
Consequence: Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the aluminum bolts with steels bolts, free of charge. DTNA issued owners an interim notification on June 3, 2019. The recall began November 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2SCHRALU.
Steering
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Metris vehicles sold, or ever registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington DC, West Virginia and Wisconsin. The aluminum bolts that attach the power steering gear assist motor to the gear housing may corrode and fracture causing a reduction or complete loss of power steering assist.
Consequence: Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the aluminum bolts with steels bolts, free of charge. DTNA issued owners an interim notification on June 3, 2019. The recall began November 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2SCHRALU.
Nov 29, 2018
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Mercedes-Benz Metris vehicles. The fuel hose in the engine compartment may leak at the lower connecting point of the transition hose, between the underbody fuel line and the Schrader valve and/or where the fuel line connects to the fuel pump.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: DVUSA will notify owners, and dealers will replace the affected hose and clamp, free of charge. The recall is expected to begin January 25, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.
May 22, 2018
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2017 Mercedes-Benz Metris vehicles. The transmission support may not have been properly tightened to the vehicle body, potentially resulting in damage to the driveshaft.
Consequence & remedy
Consequence: Damage to the driveshaft could cause a loss of power to the wheels, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will inspect the transmission support mounting bolts, replacing and tightening them as necessary, free of charge. The recall began July 11, 2018. Owners may contact DVUSA customer service at 1-877-762-8267.
Sep 22, 2017
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2017 Mercedes-Benz Metris vans. These vehicles have electrical power steering control units with improperly welded contact pins.
Consequence & remedy
Consequence: The improperly welded pins may lose contact, deactivating the power steering assist and increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the electric power steering rack, free of charge. An interim notice is expected to be mailed on November 17, 2017. A second notice will be mailed to owners when parts become available. Owners may contact Daimler's customer service at 1-877-762-8267.
Apr 21, 2017
Daimler Vans USA, LLC (DVUSA) is recalling certain 2013-2014 Freightliner Sprinter and 2016 Mercedes-Benz Metris vehicles. During vehicle servicing, the affected vehicles received software updates that may conflict with some of the vehicle's computers.
Consequence & remedy
Consequence: The improper software may cause problems with the electronic stability control system, the air bag control unit or the engine management software. These problems can result in an increased risk of a crash or an increased risk of injury in the event of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz and Freightliner dealers will update the affected control units on the vehicles, free of charge. An interim notice was sent to owners on July 12, 2017. The recall began on September 1, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Apr 10, 2017
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Metris vehicles. The affected vehicles have front seat seatbelt pretensioners that may not function properly in the event of a crash.
Consequence & remedy
Consequence: If the front seat seatbelt pretensioners do not function properly, the seat occupants may not be adequately restrained in the event of a crash, increasing the risk of injury.
Remedy: DVUSA will notify owners, and dealers will replace the front seat belts, free of charge. An interim notification was mailed to owners on June 9, 2017. A second notice was mailed on July 7, 2017, to tell owners that the remedy is now available. Owners may contact DVUSA customer service at 1-877-762-8267.
Mar 7, 2017
Daimler Vans USA LLC (DVUSA) is recalling certain 2016-2017 Mercedes-Benz Metris vehicles. These vans were to be equipped with the Blind Spot Monitoring (BSM) feature, however, the installed instrument cluster and steering wheel does not support the function, and thus, the BSM system does not work on the vehicle.
Consequence & remedy
Consequence: If a vehicle is in the driver's blind spot, but the BSM system does not warn the driver, there would be an increased risk of a crash.
Remedy: DVUSA will notify owners, and dealers will install the correct instrument cluster and steering wheel to enable the BSM function, free of charge. Interim notices informing owners of the safety risk were mailed on May 8, 2017. Owners will receive a second notice when the remedy becomes available. The recall began on May 26, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
May 24, 2016
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes Benz Metris vehicles manufactured from September 1, 2015, through December 31, 2015. The affected vehicles have rear differential gears that may have been improperly welded.
Consequence & remedy
Consequence: The weld may fail and result in a loss of power to the wheels, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the rear differential gears, free of charge. The recall began on August 11, 2016. Owners may contact DVUSA customer service at 1-877-762-8267.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18002 · Low Pressure Fuel Supply Hose Leak
Opened Mar 13, 2018 · Closed Jun 18, 2019
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
On November 27, 2018, Daimler Vans USA, LLC submitted a Defect Information Report (DIR) to NHTSA describing two engine compartment fuel hose connection defects in certain model year (MY) 2016 and 2017 Mercedes-Benz Metris vehicles (Recall 18V-837).The recall scope includes approximately 12,383 Metris vehicles manufactured from March 2, 2015 (SOP) to March 15, 2017.The defects may result in leakage from an upper hose connection that feeds the high-pressure fuel pump or from a lower hose connection of the fuel transition hose between the underbody fuel line and the Shrader valve.The upper connection defect was caused by thermal aging of the hose material (Veritas hose), resulting in a loss of elasticity over time.The thermal aging of the hose leads to a progressive reduction of sealing performance, which is most evident at low ambient temperatures.The problem was corrected by changing to a hose with better material properties (ContiTech hose).The lower connection defect was caused by a manufacturing process problem, where the hose clamp may have been installed using an incorrect tool.The recall remedy involves replacing the upper and lower hoses and clamps, as necessary, and ensuring proper installation. The Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-002 to investigate nine (9) complaints (VOQs) reporting incidents of gasoline odor or leakage in nine (9) model year (MY) 2016 Mercedes-Benz Metris vans (subject vehicles).Eight (8) of the VOQs indicated that the problem occurred in cold ambient temperatures, either during engine warm-up after a cold start or after the vehicle had been parked and shutoff. Two (2) of the consumers have indicated to ODI that the problems were diagnosed by dealer service technicians as the upper hose connection defect.As part of PE18-002, ODI analyzed information related to the incidents reported to the Office by consumers and analyzed the information provided by Daimler Vans in response to ODI's information request letter.The fuel hose leak field experience shown in the Failure Report section of this resume all involve vehicles covered by the Daimler Vans recall.This Preliminary Evaluation is closed with recall 18V-837.VOQs associated with the investigation: 10936026, 10936184, 10991876, 11054491, 11057992, 11063437, 11063829, 11104437, 11138922, 11139024, 11140844, 1150262, 11152201.
Illustration