NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
13 reportsMileage unknown · Jul 22, 2019
Service Brakes
TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ ML500. THE CONTACT STATED THAT THE ABS INDICATOR KEPT RANDOMLY ILLUMINATING AND THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN IT WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE REMAINED PARKED FOR OVER A YEAR DUE TO THE RI…
Read full complaint
TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ ML500. THE CONTACT STATED THAT THE ABS INDICATOR KEPT RANDOMLY ILLUMINATING AND THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN IT WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE REMAINED PARKED FOR OVER A YEAR DUE TO THE RISK OF A POTENTIAL CRASH. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #11233768
Mileage unknown · Feb 14, 2018
Engine
ENGINE KEEPS GETTING OVER-HEATED EVEN AFTER A NEW ENGINE FAN HAS BEEN REPLACED. HOWEVER, AFTER ITS REPLACEMENT I TOOK IT TO TWO MERCEDES DEALERSHIP TO RE-INSPECT AND MAKE ADJUSTMENT TO THEIR INSTALLMENT OF THE FAN BUT IT KEEPS GETTING OVERHEATED. I ALSO HAD A NEW WATER COOLANT TANK INSTALLED BUT IT IS ALSO LEAKING OUT THE COOLAN…
Read full complaint
ENGINE KEEPS GETTING OVER-HEATED EVEN AFTER A NEW ENGINE FAN HAS BEEN REPLACED. HOWEVER, AFTER ITS REPLACEMENT I TOOK IT TO TWO MERCEDES DEALERSHIP TO RE-INSPECT AND MAKE ADJUSTMENT TO THEIR INSTALLMENT OF THE FAN BUT IT KEEPS GETTING OVERHEATED. I ALSO HAD A NEW WATER COOLANT TANK INSTALLED BUT IT IS ALSO LEAKING OUT THE COOLANT AND SHOWING THE WARNING LIGHT. THESE EVENTS HAPPEN AFTER I TOP UP THE COOLANT TANK AND DRIVE AROUND 50 MILES, THEN THE OVERHEATING STARTS AND THE TANK STARTS BECOMING EMPTY.
NHTSA ODI #11072930
169,650 miles · Mar 12, 2017
EngineSteering
LOSS OF POWER STEERING DRIVING ON THE FREEWAY DUE TO SUDDEN BREAK OF IDLER ARM PULLEY AND SUBSEQUENT SHREDDING OF BELT. PROBLEM IS THE PULLEY IS MADE OF PLASTIC AND CRACKED IN TWO, LEAVING 1/2 THE PULLEY AND SHREDDING THE BELT. THIS OCCURRED AT DRIVING SPEED OF 50 MPH AND MILEAGE AROUND 169,650 ON 2003 ML500. THIS WAS VERY DANGE…
Read full complaint
LOSS OF POWER STEERING DRIVING ON THE FREEWAY DUE TO SUDDEN BREAK OF IDLER ARM PULLEY AND SUBSEQUENT SHREDDING OF BELT. PROBLEM IS THE PULLEY IS MADE OF PLASTIC AND CRACKED IN TWO, LEAVING 1/2 THE PULLEY AND SHREDDING THE BELT. THIS OCCURRED AT DRIVING SPEED OF 50 MPH AND MILEAGE AROUND 169,650 ON 2003 ML500. THIS WAS VERY DANGEROUS. I WAS ABLE TO PULL OFF THE FREEWAY AS I WAS DRIVING IN THE LANE NEAREST FREEWAY EXITS. ALMOST IMPOSSIBLE BUT ABLE TO STEER INTO A PARKING LOT. LUCKY IT WAS 'RUSH' HOUR AND TRAFFIC WAS SLOW ON SURFACE STREETS. INCREDIBLE SAFETY ISSUE DUE TO DIFFICULTY TO STEER WITHOUT POWER STEERING. CAR IS REGULARLY MAINTAINED BY GERMAN MECHANIC FAMILIAR WITH REPAIR OF MB ENGINES IN GERMANY.
NHTSA ODI #10960216
150,000 miles · Jul 22, 2016
Electrical SystemEngineSteering
TAKATA RECALL. POWER STEERING BRAKE ISSUE, POWER STEERING HOSE BECAME DETACHED DURING VEHICLE OPERATION, COULD NOT STEER VEHICLE. TRANSMISSION AND RADIO DRAIN, CAR CUT OFF ON ME DURING DRIVING.
NHTSA ODI #10887829
81,000 miles · Jun 26, 2015
Fuel System, GasolineService Brakes
TL* THE CONTACT OWNS A 2003 MERCEDES BENZ ML500. WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND INTERMITTENTLY. THE ABS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 81,000...UPDATED 08/06/15 *BF…
Read full complaint
TL* THE CONTACT OWNS A 2003 MERCEDES BENZ ML500. WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND INTERMITTENTLY. THE ABS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 81,000...UPDATED 08/06/15 *BF THE CONSUMER STATED TWO LINES FROM THE RESERVOIR TO THE HYDRAULIC PRESSURE REGULATOR FAILED. FURTHER INVESTIGATION REVEALED ALL THE BRAKE LINES HAD SEVERE PITTING AND CORROSION , AS WELL AS THE FUEL LINES. UPDATED 08/13/15*JB UPDATED 8/28/15*CN UPDATED 09/01/15*LJ UPDATED 09/08/15*JB UPDATED 10/01/15*LJ UPDATED 10/31/2017*CN
NHTSA ODI #10730545
98,000 miles · Aug 15, 2014
Seats
LAST TIME I USED THE HEATED SEATS, TURNED THEM ON THE WAR I ALWAYS HAVE, BUT DRIVING DOWN THE ROAD MY LEG FELT LIKE IT WAS ON FIRE. ONE SPOT IN MY SEAT BECAME EXTREMELY HOT AND WAS SMOKING. IMMEDIATELY I TURNED THE SEATS OFF AND HAVE NEVER USED THEM AGAIN. CALLED DEALER TO ASK IF THERE WAS A RECALL, BUT NO. *TR
NHTSA ODI #10622602
111,000 miles · Aug 15, 2014
Electrical SystemEngine
DRIVING 45MPH ON HIGHWAY, CAR SHUTS OFF COMPLETELY. TOWED TO CLOSEST GAS STATION, WHO PUT A COMPUTER ON IT TO FIND OUT IT WAS THE CRANK SHAFT SENSOR. AFTER COMPLETELY COOLING IT WILL START AGAIN, BUT IN LESS THAN 10 MIN IT CUTS OFF. *TR
NHTSA ODI #10622600
133,000 miles · Mar 20, 2013
Electrical SystemFire
TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ ML500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, SMOKE EMITTED FROM THE DRIVER'S SEAT. THE VEHICLE WAS TAKEN TO THE DEALER BUT WAS NEITHER DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 133,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10503789
Mileage unknown · Jun 8, 2012
Engine
NOTES TAKEN ON PHONE BY BOWMAN, ODI, NHTSA: VEHICLE SHUTS OFF AFTER IMPACT WITH IRREGULAR ROAD SURFACES CONDITION SUCH AS POTHOLE, TRANSVERSING A CHANGE ROAD GRADES / SURFACES SUCH AS SPEED BUMPS, ETAL. VEHICLE CAN BE IMMEDIATELY RESTARTED AFTER SHUT-OFF. ONE INCIDENT ALLEGEDLY OCCURRED WHEN ATTEMPTING TO MERGING ONTO INTER…
Read full complaint
NOTES TAKEN ON PHONE BY BOWMAN, ODI, NHTSA: VEHICLE SHUTS OFF AFTER IMPACT WITH IRREGULAR ROAD SURFACES CONDITION SUCH AS POTHOLE, TRANSVERSING A CHANGE ROAD GRADES / SURFACES SUCH AS SPEED BUMPS, ETAL. VEHICLE CAN BE IMMEDIATELY RESTARTED AFTER SHUT-OFF. ONE INCIDENT ALLEGEDLY OCCURRED WHEN ATTEMPTING TO MERGING ONTO INTERSTATE.
NHTSA ODI #10461541
97,000 miles · Nov 16, 2011
SeatsFireInjury
TL* THE CONTACT OWNS A 2003 MERCEDES BENZ ML 500. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT SMELLED A BURNING ODOR AS HIS LEFT PANT LEG CAUGHT ON FIRE. THE CONTACT SUSTAINED A SMALL BURN TO THE LEG. THE CONTACT STOPPED THE VEHICLE AND NOTICED SPARKS AND A SMALL FLAME COMING THROUGH A SMALL HOLE ON THE FRONT PASSENGER'S SEA…
Read full complaint
TL* THE CONTACT OWNS A 2003 MERCEDES BENZ ML 500. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT SMELLED A BURNING ODOR AS HIS LEFT PANT LEG CAUGHT ON FIRE. THE CONTACT SUSTAINED A SMALL BURN TO THE LEG. THE CONTACT STOPPED THE VEHICLE AND NOTICED SPARKS AND A SMALL FLAME COMING THROUGH A SMALL HOLE ON THE FRONT PASSENGER'S SEAT. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH WATER AND WAS TREATED FOR THE SMALL BURN. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.
NHTSA ODI #10436061
Illustration