INITIALLY WHEN THIS PROBLEM OCCURRED, I DISCOVERED THE DOOR HANDLE MECHANISM IS MADE OF POT METAL AND NOT OF A VERY STRONG NATURE FOR THE FREQUENT USE IT GETS. CHECKING WITH THE DEALER I FIND IT WILL COST $300 TO FIX. TO SAVE MONEY I RESEARCHED USED PART PLACES. I DISCOVERED THIS IS A WIDE SPREAD PROBLEM AND DOOR HANDLES ARE …
Read full complaint
INITIALLY WHEN THIS PROBLEM OCCURRED, I DISCOVERED THE DOOR HANDLE MECHANISM IS MADE OF POT METAL AND NOT OF A VERY STRONG NATURE FOR THE FREQUENT USE IT GETS. CHECKING WITH THE DEALER I FIND IT WILL COST $300 TO FIX. TO SAVE MONEY I RESEARCHED USED PART PLACES. I DISCOVERED THIS IS A WIDE SPREAD PROBLEM AND DOOR HANDLES ARE RARE TO COME BY AS MOST ARE ALREADY BOUGHT UP. I HAVE SEARCHED NORTHERN AS WELL AS SOUTHERN CA, AND WILL NOW TRY IN TX. I FEEL THIS IS A SAFETY ISSUE BECAUSE MY 2 YEAR OLD WAS LOCKED IN THE CAR THE OTHER DAY AND THE HANDLE OF COURSE BEING BROKEN WOULDN'T OPEN. LUCKILY I WAS ABLE TO PUT SOMETHING DOWN THROUGH THE GLASS TO OPEN IT FROM THE INSIDE. THIS IS OBVIOUSLY A DEFECTIVE PART, IS THERE ANYWAY TO HAVE IT FIXED BY THE DEALER?.
THE FRONT SAFETY BELT BUCKLE RELEASE BUTTONS CAN BREAK. THESE RED PLASTIC RELEASE BUTTONS ARE MARKED "PRESS." IF A BUTTON BREAKS, PIECES CAN FALL INTO THE BUCKLE ASSEMBLY CAUSING THE BUCKLE TO OPERATE IMPROPERLY.
Consequence & remedy
Consequence: THE SAFETY BELTS WOULD NOT PROVIDE ADEQUATE PROTECTION TO AN OCCUPANT IN A VEHICLE CRASH.
Remedy: OWNERS SHOULD PROMPTLY CHECK THE CONDITION AND OPERATION OF BOTH FRONT SAFETY BELT BUCKLES AND CAREFULLY INSPECT THE RED RELEASE BUTTON FOR ANY BREAKS OR CRACKS. THEY SHOULD ENSURE THAT BOTH BUCKLES ARE OPERATING PROPERLY BY INSERTING EACH LATCH PLATE INTO ITS BUCKLE, TUGGING ON THE BELT TO MAKE SURE THE LATCH IS SECURELY LOCKED, AND THEN PRESSING THE RELEASE BUTTON. THE LATCH PLATE SHOULD POP OUT OF THE BUCKLE WHEN THE BUTTON IS PRESSED. IF EITHER RELEASE BUTTON SHOWS A SIGN OF BREAKING OR CRACKING OR IF EITHER BUCKLE FAILS TO OPERATE PROPERLY, OWNERS SHOULD PROMPTLY CONTACT THEIR AUTHORIZED DEALER TO SCHEDULE AN APPOINTMENT TO HAVE THE BUCKLE REPLACED OR REPAIRED, FREE OF CHARGE. THE MANUFACTURER IS DEVELOPING A REMEDY DESIGNED TO PREVENT FAILURE OF THE BUTTONS THAT ARE NOT CURRENTLY BROKEN.
VEHICLES EQUIPPED WITH REAR BRAKE DRUMS TRANSPORTED BY TRAIN MAY EXPERIENCE SEPARATION OF THE BRAKE SHOE FROM THE WHEEL BRAKE CYLINDER PISTON.
Consequence & remedy
Consequence: SHOULD SEPARATION OCCUR, REPEATED BRAKE OPERATION MAYDAMAGE THE WHEEL BRAKE CYLINDER DUST BOOT, ALLOWING WATER OR DUST INTRUSION ANDSUBSEQUENT PISTON CONTAMINATION.
Remedy: ALL VEHICLES WILL BE INSPECTED AND IF NO SEPARATION IS FOUND GREASE WILL BE APPLIED TO THE COMPONENT INTERFACE TO LOWER FRICTION AND AVOID SUBSEQUENT RELATIVE MOTION. IF SEPARATION IS FOUND THE WHEEL BRAKE CYLINDER DUST BOOT WILL BE REPLACED.
Illustration