TL*THE CONTACT OWNS A 1993 LINCOLN TOWN CAR. THE CONTACT NOTICED SMOKE COMING FROM THE AIR CONDITIONING VENT WHEN SHE STARTED THE VEHICLE. WITHIN MINUTES, THE VEHICLE BURST INTO FLAMES. AN INSURANCE CLAIM WAS FILED, BUT THE CAUSE OF THE FIRE HAS NOT BEEN DETERMINED. THE VEHICLE IS CURRENTLY PARKED AT THE CONTACT'S RESIDENCE.…
Read full complaint
TL*THE CONTACT OWNS A 1993 LINCOLN TOWN CAR. THE CONTACT NOTICED SMOKE COMING FROM THE AIR CONDITIONING VENT WHEN SHE STARTED THE VEHICLE. WITHIN MINUTES, THE VEHICLE BURST INTO FLAMES. AN INSURANCE CLAIM WAS FILED, BUT THE CAUSE OF THE FIRE HAS NOT BEEN DETERMINED. THE VEHICLE IS CURRENTLY PARKED AT THE CONTACT'S RESIDENCE. THE MANUFACTURER STATED THAT THEY WILL NOT FILE A COMPLAINT OR PROVIDE ANY ASSISTANCE BECAUSE SHE FILED A CLAIM WITH HER INSURANCE COMPANY. A POLICE AND FIRE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 123,000.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SPEED CONTROL DEACTIVATION SWITCH CAN DEVELOP A RESISTIVE SHORT IN THE ELECTRICAL CIRCUIT THAT COULD POTENTIALLY RESULT IN AN UNDERHOOD FIRE. A FIRE IS POSSIBLE BOTH WHEN THE VEHICLE IS RUNNING AND WHEN THE VEHICLE ENGINE IS OFF. ALSO, THE SHORT COULD DISABLE THE SPEED CONTROL SYSTEM OR CAUSE THE BRAKE LIGHT FUSE TO OPEN.
Consequence & remedy
Consequence: A FIRE CAN ORIGINATE IN THE LEFT FRONT UNDERHOOD AREA.
Remedy: DEALERS WILL INSTALL A NEW SPEED CONTROL DEACTIVATION SWITCH AND CONNECTOR SHELL. OWNER NOTIFICATION BEGAN MAY 20, 1999.
VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Consequence & remedy
Consequence: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
IMPROPER INSTALLATION OF THE REAR BRAKE LINE AT THE POINT AT WHICH THE EXTENDED BRAKE LINE FIRST BENDS AND EXTENDS OVER THE LEFT REAR WHEEL AREA OF THE FRAME. IF NOT INSTALLED WITH SUFFICIENT CLEARANCE, CHAFING OF THE BRAKE LINE CAN OCCUR IN AN AREA ADJACENT TO THE REAR FLOOR PAN.
Consequence & remedy
Consequence: THE REAR BRAKE LINE CAN LEAK OR RUPTURE RESULTING IN REDUCED BRAKING CAPABILITY, LOSS OF REAR BRAKES, AND/OR LOSS OF BRAKE FLUID RESERVES IN THE MASTER BRAKE CYLINDER.
Remedy: DEALERS WILL INSPECT THE BRAKE LINE FOR PROPER INSTALLATION AND/OR DAMAGE AND REPLACE AS NECESSARY. ALSO A PROTECTIVE BOOT OR SLEEVE OVER THE BRAKE LINE WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
EA02025 · Speed Control Deactivation Switch Fires
Opened Sep 6, 2002 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available
RQ01002 · Engine Compartment Fires
Opened Sep 20, 2001 · Closed Sep 6, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA99006 · Under Hood Fires
Opened Mar 11, 1999 · Closed May 19, 1999
Status: closed (inferred from source dates) · Electrical System
ALLEGED THAT THE ENGINE COMPARTMENT FIRES ON THE DRIVER'S SIDE IN THE AREA OF THE LEFT FRONT WHEEL WELL AND THE BRAKE MASTER CYLINDER
PE98055 · Under Hood Fires
Opened Oct 27, 1998 · Closed Mar 11, 1999
Status: closed (inferred from source dates) · Electrical System
ALLEGED ENGINE COMPARTMENT FIRES ON THE DRIVER'S SIDE IN THE AREA OF THE LEFT FRONT WHEEL WELL AND THE BRAKE MASTER CYLINER.
PE93086 · Hood FLY-UP While Driving
Opened Oct 1, 1993 · Closed Feb 28, 1994
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1993 Lincoln Town Car Problems, Complaints & Recalls | Skip That Year
Illustration