2003 Lincoln Ls

CAR HESITATES ON ACCELERATION SINCE IT WAS NEW. TOOK THE CAR TO THE SELLING DEALER AND THEY COULD NOT FIND A PROBLEM. THE CONDITION GOT WORSE. WHEN TRAVELING DOWN THE HIGHWAY THE CAR STARTS BUCKING AND MISFIRING. TOOK THE CAR BACK TO THE SELLING LINCOLN DEALERSHIP (SESI LINCOLN MERCURY). THEY DEALERSHIP SAID THE DRIVERS DOOR NEEDED ADJUSTMENT. THIS MADE NO SENSE TO ME AND DID NOT FIX THE PROBLEM. THE CAR WENT OUT OF WARRANTY SHORTLY AFTER THAT. NOW CHECK ENGINE LIGHT COMES ON INTERMITTENTLY AND CAR HESITATES, BUCKS, STALLS AND RUNS ROUGH, MISFIRES AT HIGHWAY SPEEDS, AND MIL STARTS FLASHING. THE COWL PLASTIC PIECE HAS A POOR SEAL ON IT THAT LETS WATER ONTO THE ENGINE ELECTRICAL SYSTEM. FORD ISSUED A TECHNICAL SERVICE BULLETIN THAT ADDRESSES THIS ISSUE AND FORD ADMITS THAT SEALS NEED TO BE REPLACED. THIS MAY NOT BE THE ONLY PROBLEM WITH THIS CARS ELECTRICAL SYSTEM, BUT IT IS A BIG PROBLEM. THIS IS A DESIGN DEFECT, NOTHING A CUSTOMER CAN DO TO PREVENT THIS. FORD SHOULD HAVE RECALLED THESE CARS AND FIXED THEM AT NO COST. THE FACT THAT THEIR DEALERSHIPS WERE HIDING THE REAL REASON FOR THIS MISFIRE AND NOT REPAIRING THE VEHICLES UNDER WARRANTY IS BREECH OF CONTRACT. FORD SHOULD BE FINED AND PUNISHED AND FORCED TO RECALL AND REPAIR ALL OF THESE CARS. I AM AN ASE MASTER MECHANIC. I TEACH AUTOMOTIVE SERVICE TECHNOLOGY AT THE COLLEGE LEVEL. THIS SHOULD NOT BE HAPPENING. THE CAR WAS GARAGE KEPT AND VERY WELL MAINTAINED, IT LOOKS NEW. I FOUND THAT # 6 CYLINDER HAD A P0306 COIL MISFIRE DTC. I HAD TO REMOVE THE INTAKE MANIFOLD JUST TO SEE THE COIL ON PLUG SET UP ON THE PASSENGER SIDE BANK OF ENGINE. TURNS OUT THERE IS POOR SEALING OF THE WINDSHIELD COWL AREA AND WATER RUNS DIRECTLY ONTO THE ENGINE AND ENGINE ELECTRICAL SYSTEM. THE WATER SHORTS OUT THE COILS, SPARK PLUGS, COMPUTER AND ELECTRICAL SYSTEM. THE CAR IS NOT SAFE TO DRIVE. THIS CAN HAPPEN AT ANY TIME ESPECIALLY WHEN WET. *TR