2022 Kia Telluride

Description of the Problem: I noticed a crack suddenly appearing on my car’s windshield without any external impact, such as a rock or debris. The crack seems to have formed spontaneously, starting from the bottom edge and growing through the center of the glass, and there are no visible signs of external damage or impact points. This raises concerns about the quality or structural integrity of the windshield. It started early in the morning at about 6 inches but now has more than 12 inches and two ramifications. The car was parked in front of our garage and there were no extreme temperature changes. Concerns: I am worried that the windshield may have a manufacturing defect or material issue that could compromise the safety of the vehicle. This could pose a risk if the crack spreads or the windshield fails under stress.

The contact owns a 2022 Kia Telluride. The contact stated that while driving at an undisclosed speed, the rear windshield inadvertently shattered. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who was unable to diagnose the failure. The contact was informed that the manufacturer was aware of the issue. The vehicle was repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 37,000.

Subject: Urgent Safety Complaint Regarding Recall Delays for My Kia Vehicle Dear National Highway Traffic Safety Administration, I am reaching out to file a safety complaint regarding an ongoing recall issue with my Kia vehicle that has not been addressed, despite multiple attempts to have it resolved. Kia has been aware of the necessary recall for several months, and I recently scheduled an appointment with my local dealership to address these recalls. Unfortunately, the dealership canceled my appointment the day before, citing that they still do not have the necessary parts to complete the repair. This situation has escalated to a serious safety hazard, not only for my family and me but for others around us. Recently, while my vehicle was parked at my child’s school, I experienced a malfunction that caused the vehicle to roll forward while still in park. I was momentarily unaware of the movement and was horrified to realize it almost struck a mother and her child who were exiting the school. This has been a frightening and deeply disappointing experience, and I am concerned about the lack of urgency from Kia in addressing this issue. I urge NHTSA to look into this matter and take action as needed to ensure that Kia expedites the resolution of these critical safety recalls. This issue cannot wait any longer, as it poses a serious risk to public safety. Thank you for your attention to this matter. Sincerely, [XXX] Phone: [XXX] Email: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Sunroof is stuck in an open position unable to be closed. Upon attempting to open the sunroof, the deflector snapped off the assembly and the sunroof track broke. Took car to dealership (Raceway Kia, 4044 US-9, Freehold, NJ 07728) for service. Dealership indicated the sunroof is beyond repair and requires installation of an entirely brand new sunroof assembly at a cost of $5730 because it occurred outside the warranty (warranty expired at 60,000 miles and the car had 70,463 miles when sunroof broke). They were unable to manually close the sunroof as a temporary solution. Therefore, the sunroof remains open due to the broken track and is covered with plastic to avoid the elements. There were no prior symptoms indicating that the sunroof would break in this way. In fact, in three years of ownership, the sunroof was rarely used and only opened a handful of times before breaking. At this time of this writing, the sunroof is available for inspection while I look for more economical means of repair versus the dealership's plan to replace the entire assembly.

The sunroof in my 2022 Kia Telluride will not slide backwards to be completely open. It will slide about an inch then stop. Yesterday I took it to the local Kia dealership who tried to clean the tracks. They told me that didn’t work and that I would need to bring it back, leave it all day and pay close to $400 JUST to find the problem. Today I was taking a look again myself and noticed the deflector is broken. The cheap plastic has just broken right off and the piece is laying there lifeless. Because I travel for work, I am no longer under warranty. An estimate just for parts to fix everything is close to $4000! Without labor!! And, I did all of that research in 10 minutes which would have cost me $400 and a whole day without my car if I had done as they wanted. This is outrageous. My car is TWO years old and already things are breaking. I see in forums that this is NOT a new issue. Why isn’t Kia doing something about this? People don’t have thousands of dollars to just throw around when we already pay an arm and a leg for the car anyway! I am now stuck with a sunroof that doesn’t work properly unless Kia will PUT OUT A RECALL!!!!