IllustrationENGINE & ENGINE CHECK LIGHT & POWER/FUEL INJECTION SWITCH. BEEN IN THE SERVICE DEPARTMENT FOR CHECKUPS AND REPAIRS 5 TIMES FOR THE SAME THING. CAR IS DEAD, TIMING CHAIN BROKE AND THE BLOCK FROZED UP.
1997 Kia Sephia
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1997 Kia Sephia do not stand out strongly from the model-year median of 107.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sephia years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 15 of 205 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
30 crash reports5 fire reports20 injury reports
Engine And Engine Cooling complaints
44 reportsBRAKES ROTORS ARE PREMATURELY WEARING, CAUSE UNKNOWN. *AK ENGINE SURGES WHEN STOPPING AND SOME TIME SHUT DOWN WHEN STARTING. *YH
THIS VEHICLE IS A DEATH TRAP..FORD DEALER NOT VERY HELPFUL.LAST INCIDENT ALMOST CAUSED SERIOUS ACCIDENT. NO SAFETY DEFECT MENTIONED IN SUMMARY. *AK
SINCE CONSUMER OWNED CAR BRAKES HAD TO BE CHANGED FIVE TIMES. 3 BATTERIES HAD TO BE PUT IN. ENGINE LIGHT CAME ON ON INSTRUMENT PANEL, ANTI-FREEZE IS LEAKING AND THE ENGINE IS RUNNING ROUGH. *AK *SLC
I HAVE HAD NUMEROUS PROBLEMS WITH THIS. THE CHECK ENGINE LIGHT HAS COME ON, THE ROTORS HAD TO BE REPLACED TWICE AND THEY STILL MADE NOISE BUT THE DEALER SAID THERE WAS NOTHING ELSE THEY COULD DO, THE HINGE ON THE BACK DOOR FAILED, THE LEFT STRUT HAD TO BE REPLACED. THIS TIME THE ENTIRE BOTTOM OF THE CAR WAS DAMAGED THE CAR SKI…
Read full complaint
I HAVE HAD NUMEROUS PROBLEMS WITH THIS. THE CHECK ENGINE LIGHT HAS COME ON, THE ROTORS HAD TO BE REPLACED TWICE AND THEY STILL MADE NOISE BUT THE DEALER SAID THERE WAS NOTHING ELSE THEY COULD DO, THE HINGE ON THE BACK DOOR FAILED, THE LEFT STRUT HAD TO BE REPLACED. THIS TIME THE ENTIRE BOTTOM OF THE CAR WAS DAMAGED THE CAR SKIPPED WHEN IN DRIVE TO REVERSE AND THE BREAKS WOULD NOT ALLOW THE CAR TO COME TO A COMPLETE STOP. KIA NEEDS TO DO SOMETHING ABOUT THIS THESE CARS HAVE TOO MANY DEFECTS AND I'M SURE THEY HAVE MANY MOR PEOPLE JUST DON'T REPORT THEM ALL THE TIME
WHILE DRIVING ON HIGHWAY OR EXITING A RAMP VEHICLE WOULD STALL WITH ANY PRIOR WARNING OR REASON. HAVE TAKEN VEHICLE TO DEALERSHIP AT LEAST 8 TIMES FOR THE STALLING PROBLEM. PROBLEM WOULD BE ADJUSTED, BUT IT WOULD ALWAYS REAPPEAR. STALLING IS AN INTERMITTENT PROBLEM. *AK
WHILE DRIVING VEHICLE STALLED AND DIED, CAUSING A COLLISION WHICH RESULTED IN MINOR INJURIES. MANUFACTURER HAS BEEN NOTIFIED. STALLING HAS BEEN A REOCCURRING PROBLEM, DESPITE MANY REPAIRS DONE BY DEALER. *AK *ML
ONGOING PROBLEM WITH BATTERY FAILURE; DEALER NOTIFIED, AND REPLACED FAULTY BATTERY ON TWO OCCASIONS, AND PROBLEM REOCCURRED. ALSO, AND PROBLEM ENGINE HESITATION. DEALER NOTIFIED. *AK THE CONSUMER FOUND OUT RIGHT AFTER LEASING THE VEHICLE, THAT THE RADIO WAS INOPERABLE. THE VEHICLE BEGAN SQUEEKING IN THE REAR END WHEN TURNIN…
Read full complaint
ONGOING PROBLEM WITH BATTERY FAILURE; DEALER NOTIFIED, AND REPLACED FAULTY BATTERY ON TWO OCCASIONS, AND PROBLEM REOCCURRED. ALSO, AND PROBLEM ENGINE HESITATION. DEALER NOTIFIED. *AK THE CONSUMER FOUND OUT RIGHT AFTER LEASING THE VEHICLE, THAT THE RADIO WAS INOPERABLE. THE VEHICLE BEGAN SQUEEKING IN THE REAR END WHEN TURNING. THE HEATER MALFUNCTIONED. THE LEFT REAR STRUT ASSEMBLY FAILED CAUSING KNOCKING NOISE AT RIGHT REAR. THE O-RING FAILED CAUSEING THE DISTRIBUTOR LEAK AND THERE WAS LOSS OF POWER WHILE DRIVING. *YH
TRANSMISSION WAS REPLACED TWICE/ THE ENGINE SEIZED AT 30000 MILES/ THE BRAKES WARPED THREE TIMES AND WERE REPLACED 3 TIMES/ THE WINDOWS ARE HARD TO OPEN AND CLOSE/ THE BRAKE PEDAL IS EXTREMELY LOW. *AK
WHILE DRIVING AND SLOWING DOWN OR TURNING VEHICLE WOULD STALL. CONSUMER FELT THIS WAS A SAFETY ISSUE, TOOK VEHICLE TO DEALER, AND THEY WERE NOT HELPING. CONSUMER ALSO REPORTS SMELLING AGS FUMES INSIDE VEHICLE, AND CHECK ENGINE LIGHT FREQUENTLY FLASHING. *AK *ML
Official recalls
102V216000 · Seat Belts:front:buckle Assembly
Aug 16, 2002
ON CERTAIN PASSENGER VEHICLES, THE SAFETY BELT BUCKLE MAY "FALSE LATCH" AND EXPOSE THE DRIVER TO UNRESTRAINED MOVEMENT DURING A CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: OWNER NOTIFICATION BEGAN DECEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE02051 · Safety Belt Buckle Malfunction
Opened Jun 17, 2002 · Closed Sep 20, 2002
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.