2015 Kia Sedona

Driving at approx. 45 mph the engine locked up and failed causing the van to die and not be able to restart. There was no warnings, lights etc before failure. Luckily the road was empty to be able to navigate to the side of the road to avoid a dangerous situation. Should it have been a busy highway it would have put everyone at risk with a disabled vehicle not being able to move at speed. Kia Dealership investigated the failure and although there was lower oil and coolant level the manifold gasket test failed to meet the requirements for a Kia failure and remedy was a $9000 new engine.

Complete engine failure, knocking like crazy, fuel smell in the oil, The shop said the fuel in the oil broke it down and allowed the motor to fail. We were driving down the highway when it happened with family and kids which was not safe at all. No warning message at all, no check engine light, the shop has inspected and said it’s failed. The kia dealership has said many of the Kia’s have been recalled for engine failure but not ours? But others with the same motor have been.

While driving through an intersection with my family in the car, the engine suddenly failed without warning, leaving us stranded in a dangerous situation with incoming traffic. The engine began smoking, shaking violently, and emitting a strong odor, making the vehicle undrivable. We also received a notification to have the engine checked, and the check engine light was blinking. The vehicle is currently at a dealership in Belvidere, IL. KIA informed us that our VIN is not included in any existing recalls or lawsuits. This situation has caused significant hardship, as we now have no car to drive for work or daily activities.

We were going down the highway when the engine suddenly stalled. We had to shift lanes during heavy traffic without assisted steering or braking and no way to accelerate. This almost caused an accident just to get the car off the main traffic lanes. We were able to coast out an exit where the car came to a stop and had to be pushed of the road. When trying to restart the engine, it immediately seized. There were no warning lights or any indicators before the incident. The engine had been running perfectly fine before with no abnormal oil consumption, overheating problems or any other issues. The car was towed to a shop where the next day a terminal engine failure was diagnosed and we were informed that the engine would have to be replaced for about $8,000. The failure mileage was approximately 128,000.

Car engine overheated without any warning indicating that it was overheating. It just started smoking. Car is available for inspection upon request. Our safety was put at risk because in 95-degree weather, warm air was coming from AC when car sat idle. The root of the problem has not been confirmed by the dealer. Vehicle pictures were sent to insurance. No warning appeared before failure.

Engine light came on while in route for an oil change. Walmart automotive changed the oil and checked the light. Read p0014. Engine light went away after oil change. Drove fine for 4 days then went haywire on the interstate. Oil light started flashing then engine light. Lost all power. Had it towed home. It started with a loud knocking noise. Towed to Kia and there are metal fragments in my oil. Engine blown.

July 2021 family of 6 driving on vacation. 3 hours from home car started losing power. Dash lights were coming on and no lights were on at anytime before this. Vehicle had 68,000 miles at the time. Lost power would not accelerate for several minutes and car started smoking under the hood. Coolant was spraying everywhere. Family stuck on side of highway in middle of Pennsylvania and no exit for 15 miles. Had to walk to an unknown home to ask them to fill several bottles of water. Put water in the car. It would run about 5 minutes and overheat again. Finally got to a rest stop. Took to O'Reilly auto parts where we had new thermostat, coolant and fluid and other minor parts installed spending about $700. Drove 15 minutes car broke down again overheating. Trucker mechanic stopped to help but no luck. This was on a Sunday where everything was closed. We could not get a ride or a rental. Continued driving about 3 minutes at a time and constantly adding fluids made it to a hotel. Had to store the van for the week at the hotel. They agreed to keep it while we rented a van and went to Virginia beach. Van had to be towed home. Took to a garage near home where the mechanic said the heads needed replaced. Replaced head gaskets, head bolts. New thermostat, spark plugs, heli coil, coolant,oil and labor. They gave us a discounted rate of $2087.00. Drove home worked for few days and needed towed. Broke down again overheating on a main 3 lane busy road near home. This time repair shop said it would need a while new engine. While we paid $700 in parts on way to vacation. Had $1200 in car rental fees. $2100 in head gaskets shop repair fees. $600 in towing fees. And they were wanting $6000 for a new engine. I sat the van in my driveway for months paying the payments and eventually had to voluntarily repo at 70K miles. Car had 1 owner before us and car was regularly serviced. We had free service and oil for the first year we owned. Now being sued for the balance. Help!!!