NHTSA owner reports · September 18, 2026 snapshot.
Seats complaints
13 reportsClear category filterMileage unknown · Aug 21, 2015
Air BagsSeat BeltsSeatsCrashInjury
BEFORE THE INCIDENT THERE WERE ISSUES WITH THE REAR CAPTAIN CHAIRS SEAT BELT LATCH WHEN TRYING TO BUCKLE THEM. I HAVE THREE SMALL CHILDREN UNDER THE AGE OF 3 YEARS OF AGE AND IT IS VERY IMPORTANT AND CRUCIAL THAT SEAT BELTS ARE IN WORKING ORDER WITHOUT ISSUES FOR THE SAFETY OF THEIR WELL BEING. BEFORE THE INCIDENT THE SEATS THEM…
Read full complaint
BEFORE THE INCIDENT THERE WERE ISSUES WITH THE REAR CAPTAIN CHAIRS SEAT BELT LATCH WHEN TRYING TO BUCKLE THEM. I HAVE THREE SMALL CHILDREN UNDER THE AGE OF 3 YEARS OF AGE AND IT IS VERY IMPORTANT AND CRUCIAL THAT SEAT BELTS ARE IN WORKING ORDER WITHOUT ISSUES FOR THE SAFETY OF THEIR WELL BEING. BEFORE THE INCIDENT THE SEATS THEMSELVES IN THE REAR ROWS HAD ISSUES LATCHING AS WELL WHEN BEING INSTALLED. ON AUGUST 18, 2015 MYSELF AND THREE SMALL CHILDREN WERE IN A SEVERE HIGH IMPACT ACCIDENT AND NONE OF THE AIRBAGS HAD GONE OFF LIKE THEY NEVER EXISTED. MY KIDS AND I SUFFER FROM SEAT BELT ABRASIONS AND I SUFFER FROM BRUISING IN MULTIPLE PLACES FROM MY HEAD DOWN, SHOULDER PAIN AND BACK ISSUES. POLICE, PARAMEDIC'S, COLLISION CENTER, WITNESSES, AND MY INSURANCE COMPANY WERE ALL NOTIFIED OR HAD NOTIFIED ABOUT THE AIRBAGS. APPARENTLY, MY SEAT WHICH WAS THE DRIVER SEAT WAS ALSO COMPLETELY SNAPPED OFF AS WELL. UPDATED 08/26/15*BF
NHTSA ODI #10750433
130,000 miles · May 7, 2009
Seats
GOT INTO VAN TODAY TO DRIVE IT AND THE BACK OF THE SEAT BROKE FROM THE BOTTOM OF THE SEAT. *TR
NHTSA ODI #10267966
55,000 miles · Feb 27, 2008
Electrical SystemPower TrainSeats
2002 KIA SEDONA WITH STEERING FAILURE. CONSUMER STATES THAT MECHANIC TOLD HER THAT A BOLT FELL OUT AND COULD NOT BE REPLACED UNLESS THE ENTIRE STEERING SHAFT WAS REPLACED. CONSUMER STATES THAT WASN'T THE FIRST TIME THE STEERING HAS HAD PROBLEMS. *KB THE CONSUMER STATED DURING THE FIRST YEAR OF OWNING THE VEHICLE, THE TRANSMISS…
Read full complaint
2002 KIA SEDONA WITH STEERING FAILURE. CONSUMER STATES THAT MECHANIC TOLD HER THAT A BOLT FELL OUT AND COULD NOT BE REPLACED UNLESS THE ENTIRE STEERING SHAFT WAS REPLACED. CONSUMER STATES THAT WASN'T THE FIRST TIME THE STEERING HAS HAD PROBLEMS. *KB THE CONSUMER STATED DURING THE FIRST YEAR OF OWNING THE VEHICLE, THE TRANSMISSION FAILED ,THE DRIVERS SEAT MOTOR HAD TO BE REPLACED SEVERAL TIMES AND THE FUSE THAT CONTROLLED THE DASHBOARD LIGHTS MALFUNCTIONED ON A CONTINUOUS BASIS. *JB
NHTSA ODI #10219515
72,000 miles · Dec 12, 2007
Electrical SystemEquipmentSeatsFire
TL*THE CONTACT OWNS A 2002 KIA SEDONA. THE VEHICLE HAD BEEN PARKED FOR APPROXIMATELY 8-10 HOURS WHEN IT SUDDENLY CAUGHT FIRE. THE WIRING FUSE BOX CAUSED THE ENGINE, RADIO, AND WIPER/WASHER TO ACTIVATE. THE FIRE ORIGINATED IN THE INSTRUMENT PANEL. THE CONTACT WAS ABLE TO DOUSE THE FIRE WITH A FIRE EXTINGUISHER. THE VEHICLE W…
Read full complaint
TL*THE CONTACT OWNS A 2002 KIA SEDONA. THE VEHICLE HAD BEEN PARKED FOR APPROXIMATELY 8-10 HOURS WHEN IT SUDDENLY CAUGHT FIRE. THE WIRING FUSE BOX CAUSED THE ENGINE, RADIO, AND WIPER/WASHER TO ACTIVATE. THE FIRE ORIGINATED IN THE INSTRUMENT PANEL. THE CONTACT WAS ABLE TO DOUSE THE FIRE WITH A FIRE EXTINGUISHER. THE VEHICLE WAS LATER TOWED TO A DEALER AND THEY DID NOT PROVIDE A REASON AS TO WHY IT CAUGHT FIRE. THE CONTACT FOUND NUMEROUS COMPLAINTS ON THE SAME TYPE OF VEHICLE WITH IDENTICAL FAILURES. THE CURRENT AND FAILURE MILEAGES WERE 72,000. UPDATED 03/06/08. *LJ THE CONSUMER STATED THE RECALL WAS DONE, HOWEVER EVER SINCE THE REPAIR, THE SEATS NEVER WORKED CORRECTLY. THE CONSUMER HAD WORKED DONE ON THE AIR CONDITIONER. UPDATED
NHTSA ODI #10211579
44,000 miles · Dec 12, 2005
Seats
DT: THE CONTACT STATED THE DRIVER'S SEAT BROKE AND LEANED TO THE LEFT. THE DEALER SUGGESTED SOMEONE PULLED ON THE SEAT WHILE GETTING INTO THE BACK AND BROKE IT. THE MANUFACTURER OFFERED NO FREE REMEDY. *AK
NHTSA ODI #10144970
5,000 miles · Jan 21, 2005
Engine And Engine CoolingLatches/locks/linkagesSeats
I HAVE HAD NUMEROUS PROBLEMS WITH MY KIA SEDONA. WITHIN A FEW MONTHS OF OWNERSHIP THE HEAD GASKET BLEW AND IT WAS TOWED IN AND REPLACED. THEN THE WINDSHIELD BROKE DURING THE NIGHT IN THE GARAGE WITH NO WEATHER EXTREMES. I REPLACED THAT. IN 2 YEARS I'VE HAD 2 BLOWOUTS TO THE FRONT DRIVER'S TIRE. THE ONLY 2 IN MY WHOLE 30+ YEARS O…
Read full complaint
I HAVE HAD NUMEROUS PROBLEMS WITH MY KIA SEDONA. WITHIN A FEW MONTHS OF OWNERSHIP THE HEAD GASKET BLEW AND IT WAS TOWED IN AND REPLACED. THEN THE WINDSHIELD BROKE DURING THE NIGHT IN THE GARAGE WITH NO WEATHER EXTREMES. I REPLACED THAT. IN 2 YEARS I'VE HAD 2 BLOWOUTS TO THE FRONT DRIVER'S TIRE. THE ONLY 2 IN MY WHOLE 30+ YEARS OF DRIVING.DEALER SAYS ITS NOT THE CAR. THE FRONT WHEEL BEARINGS WERE REPLACED. IN DEC 2004 THE ENGINE WAS REPLACED, THE LUMBAR SUPPORT WAS BROKEN AND FIXED, THE DRIVER'S DOORHANDLE BROKE AND WAS FIXED BY KIA. JAN18 IT WAS BACK IN BECAUSE THE HOOD RELEASE WAS NOT WORKING. IT WAS FIXED AND WE PICKED UP THE VEHICLE 1/19. ON 1/21 THE GAS PEDAL STUCK, I BROUGHT IT IN AND THEY FIXED IT IMMEDIATELY. " THE COVER HAD FALLEN DOWN AND THEY TIED IT BACK UP." OBVIOUSLY NOT A GOOD JOB BECAUSE IT STUCK AGAIN ON THE WAY HOME AT 65MPH. I WAS FINALLY ABLE TO STOP THE CAR AND HAD IT TOWED BACK IN. I THINK IT IS A DEATH TRAP!
NHTSA ODI #10107689
Mileage unknown · Jul 14, 2004
Electrical SystemFuel System, GasolineSeats
MY KIA SODONA VAN AT 63,000 MILES BEGAN TO STALL AFTER INITIAL START. ENGINE HAS TO BE REVVED REPEATEDLY TO GET IT TO GO. TOOK IT IN AND WAS TOLD THE ALTERNATOR NEEDED REPLACING, 400+ DOLLARS AND A WHOLE DAY OF WAITING IT IS STILL NOT RUNNING RIGHT, IN FACT IT IS WORSE THAN BEFORE. WAS TOLD TO BRING IT BACK IN, MAY HAVE A FUEL P…
Read full complaint
MY KIA SODONA VAN AT 63,000 MILES BEGAN TO STALL AFTER INITIAL START. ENGINE HAS TO BE REVVED REPEATEDLY TO GET IT TO GO. TOOK IT IN AND WAS TOLD THE ALTERNATOR NEEDED REPLACING, 400+ DOLLARS AND A WHOLE DAY OF WAITING IT IS STILL NOT RUNNING RIGHT, IN FACT IT IS WORSE THAN BEFORE. WAS TOLD TO BRING IT BACK IN, MAY HAVE A FUEL PROBLEM. WAS THE ALTERNATOR EVEN BAD?!! OTHER THINGS CONTINUE TO BREAK OR FALL APART ON THE VAN. HEAD SUPPORTS ARE BROKEN ON TWO SEATS, WILL NOT STAY UP. IF IN A CRASH WOULD NOT HAVE THE SUPPORT THESE ARE SUPPOSED TO GIVE! ONE OF THE SIDE DOORS WILL NOT CLOSE PROPERLY. WAS TOLD IT WOULD BE AROUND 100 DOLLARS TO CHANGE OUT A BALL BEARING IN THE DOOR! THESE ARE NOT COVERED UNDER THE WONDERFUL BOGUS 100,000 MILE WARRANTY. *AK
NHTSA ODI #10081047
19,000 miles · Mar 11, 2004
Air BagsSeat BeltsSeatsCrash
WHILE DRIVING 50 MPH VEHICLE WAS INVOLVED IN A COLLISION. UPON IMPACT, DUAL AIR BAGS DID NOT DEPLOY, AND SEAT BELT BROKE. ACCORDING TO THE CONSUMER THE SEAT BELT RETRACTOR DID NOT LOCK DURING THE EVENT. DRIVER SUSTAINED NECK INJURIES DURING THE ROLLOVER CRASH. *AK THE BACK SEAT HAD BECOME DISLODGED DURING THE ACCIDENT. RE…
Read full complaint
WHILE DRIVING 50 MPH VEHICLE WAS INVOLVED IN A COLLISION. UPON IMPACT, DUAL AIR BAGS DID NOT DEPLOY, AND SEAT BELT BROKE. ACCORDING TO THE CONSUMER THE SEAT BELT RETRACTOR DID NOT LOCK DURING THE EVENT. DRIVER SUSTAINED NECK INJURIES DURING THE ROLLOVER CRASH. *AK THE BACK SEAT HAD BECOME DISLODGED DURING THE ACCIDENT. RECALL#03V135000. *SC *JB
NHTSA ODI #10050280
34,000 miles · Dec 15, 2003
Seats
LOCKING MECHANISM FOR REAR SEAT HEAD RESTARIANTS (4) HAVE FAILED. FAILURE DOES NOT ALLOW THE HEAD RESTRAINT TO BE ADJUSTED AND LOCKED IN A POSITION ABOVE THE SEAT BACK.*AK
NHTSA ODI #10049760
15,100 miles · Dec 1, 2003
Seats
WHILE DRIVING SEAT BACK RECLINER BOLT BROKE. DRIVER'S SEAT BACK FELL BACK, CAUSING THE DRIVER TO LOSE CONTROL TEMPORARILY.*AK
NHTSA ODI #10049809
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Illustration