Air Bags. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

11 crash reports1 fire reports6 injury reports

Structure complaints

1 reports

Clear category filter

Mileage unknown · Oct 5, 2015

Service BrakesStructure

Read full complaint

TL* THE CONTACT OWNS A 2007 KIA RIO. THE CONTACT STATED THAT THE BRAKE PEDAL WAS HARD WHEN APPLIED AND HESITATED TO RESPOND. THE CONTACT ALSO NOTICED THAT THE VEHICLE HAD A DRASTIC REDUCTION IN SPEED. THE VEHICLE WAS NOT INCLUDED IN A MANUFACTURERS RECALL RELATED TO THE FAILURE. THE VEHICLE WAS DIAGNOSED AT AN UNKNOWN LOCATION WHERE IT WAS DIAGNOSED THAT THE BRAKE SYSTEM HAD EXTENSIVE RUST AND CORROSION. THE VEHICLE WAS NOT SAFE TO DRIVE AND NEEDED TO BE REPAIRED. THE VEHICLE WAS TAKEN TO TWO DIFFERENT REPAIR FACILITY'S FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ODI #10779802

Official recalls

12V244000 · Air Bags:frontal:sensor/control MODULE-INACTIVE

May 31, 2012

KIA IS RECALLING CERTAIN MODEL YEAR 2006-2008 RIO VEHICLES, MANUFACTURED FROM FEBRUARY 20, 2005, THROUGH DECEMBER 9, 2007. THE FRONT PASSENGER SEAT OCCUPANT SENSOR MAT CAN EXPERIENCE FATIGUE CRACKING. IF SUFFICIENT CRACKING OCCURS, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) WILL CEASE TO FUNCTION SUCH THAT THE SYSTEM WILL NOT BE ABLE TO DETECT WHETHER A CHILD PASSENGER IS IN THE SEAT AND THE AIRBAG WILL DEPLOY DURING A CRASH NECESSITATING DEPLOYMENT.

Consequence & remedy

Consequence: AIR BAG DEPLOYMENT WITH A CHILD IN THE FRONT PASSENGER SIDE SEAT INCREASES THE RISK OF INJURY TO THAT CHILD.

Remedy: KIA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE OCS SEAT SENSOR MAT, FREE OF CHARGE. THE RECALL BEGAN ON JULY 26, 2012. OWNERS MAY CONTACT KIA CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.