Engine And Engine CoolingFuel System, GasolineService Brakes, Hydraulic
DT*: THE CONTACT STATED THAT SINCE THE VEHICLE WAS PURCHASED ON JANUARY 19TH 2005, IT HAS BEEN EXPERIENCING PROBLEMS WITH THE CARBURETOR AND A BAD ODOR THAT COMES FROM THE ENGINE. THE VEHICLE WAS ALSO SOLD TO THE CONTACT WITHOUT NOTIFICATION OF RECALL DEFECT TO THE CARBURETOR. THE VEHICLE WAS TAKEN TO THE DEALERS TO HAVE A PAR…
Read full complaint
DT*: THE CONTACT STATED THAT SINCE THE VEHICLE WAS PURCHASED ON JANUARY 19TH 2005, IT HAS BEEN EXPERIENCING PROBLEMS WITH THE CARBURETOR AND A BAD ODOR THAT COMES FROM THE ENGINE. THE VEHICLE WAS ALSO SOLD TO THE CONTACT WITHOUT NOTIFICATION OF RECALL DEFECT TO THE CARBURETOR. THE VEHICLE WAS TAKEN TO THE DEALERS TO HAVE A PART REPLACED TO REMEDY PROBLEMS WITH THE CARBURETOR BUT VEHICLE CONSISTENTLY EXPERIENCES THE SAME PROBLEMS. THE VEHICLE WAS TAKEN BACK ON TEN OTHER OCCASIONS FOR SERVICES RELATED TO THE PROBLEM. THE VEHICLE WAS THAN TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE PROBLEM WAS RELATED TO FUEL INJECTION SYSTEM. THE MANUFACTURER WAS NOTIFIED AND PROVIDED A REFERRAL TO ANOTHER DEALERS FOR SERVICE. THE VEHICLE HAS BEEN TAKEN TO THE RECOMMENDED DEALER FOR SERVICE. THE ENGINE LIGHT ILLUMINATED, HOWEVER THE DEALER REFUSED TO ADDRESS THE PROBLEM. THE VEHICLE WAS PULLING TO THE RIGHT, AN ALIGNMENT WAS PERFORMED. THE CONSUMER HEARD A WIND NOISE WHILE DRIVING. THE BRAKES WERE MAKING A LOUD NOISE. UPDATED 08/01/06. *JB
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, IF THE CHILD SEAT IS NOT PROPERLY INSTALLED, PERSONAL INJURY OR DEATH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE LOWER ANCHORS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 30, 2006. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL DISTRIBUTOR AND MAIN FUEL TUBE ASSEMBLIES. THE RECALL BEGAN JUNE 18, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Kia Rio Problems, Complaints & Recalls | Skip That Year
Illustration