Latches/locks/linkages. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

8 crash reports2 fire reports5 injury reports

Visibility complaints

5 reports

Clear category filter

Mileage unknown · Apr 13, 2010

Visibility

PASSENGER MIRROR FALLS OFF. *TR

NHTSA ODI #10325434

110,120 miles · Jul 16, 2009

Visibility

RUSTING OF WINDSHIELD WIPERS. *TR

NHTSA ODI #10277037

9,000 miles · Jan 6, 2005

Visibility

VEHICLE IS EXPERIENCING PROBLEMS WITH THE DEFROSTER. WHEN THE VEHICLE IS IN THE ELEMENTS THE WINDOWS ON THE LEFT SIDE FOG UP BADLY, CONSUMER MUST ROLL THE WINDOW DOWN TO SEE WHAT IS ON LEFT SIDE. CONSUMER TOOK THE VEHICLE TO THE DEALER, AND WAS TOLD THAT THE VEHICLE WAS OPERATING FINE. *AK...*AK

NHTSA ODI #10106925

31 miles · Jun 27, 2003

Visibility

Read full complaint

THE DESIGN OF THE LARGE OVER VIEW MIRROR, ONLY ALLOWED THE CONSUMER TO SEE HALF OF THE FRONT WINDSHIELD. *JB THE FRONT WINDSHIELD VISIBILITY TO THE RIGHT WAS BLOCKED BY THE FRONT REARVIEW MIRROR DUE TO LARGE SIZE OF THE MIRROR AND INABILITY TO LOWER THE DRIVERS SEAT ENOUGH AND ALMOST HIT THE OTHER VEHICLE. THE REAR VIEW MIRROR BLOCKED THE VISIBILITY OF THE RIGHT HALF OF THE WINDSHIELD AND DID NOT SEE THE VEHICLE TRAVELING FROM RIGHT TO LEFT UNTIL IT WAS IN FRONT OF THE CONSUMER. SCC *JB

NHTSA ODI #10020412

Mileage unknown · May 30, 2003

Visibility

THE LOCATION OF THE DRIVER SIDE MIRROR AND SUN VISOR IS OBSTRUCTING THE VIEW THROUGH THE WINDSHIELD. THIS RESULTS IN POOR VISIBILITY, ALMOST CAUSING AN ACCIDENT. SEAT CANNOT BE LOWERED TO CORRECT THIS PROBLEM.*AK

NHTSA ODI #10021932

Official recalls

09V183000 · Suspension:front

May 27, 2009

KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR.

Consequence & remedy

Consequence: CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy: KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.

04V180000 · Fuel System, Gasoline:storage:tank Assembly

Apr 12, 2004

SOME PASSENGER VEHICLES MAY CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.

Consequence & remedy

Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN JUNE 25, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.