I WAS DRIVING IN THE MOUNTAINS AND NOTICED AN UNUSUAL NOISE UNDER MY JEEP AND GOT OUT TO CHECK IT OUT AND FOUND THAT MY FRAME HAD CRACKED UNDER THE PASSENGER SEAT WHERE THE CONTROL ARM IS WELDED TO THE FRAME. AFTER LOOKING MORE CLOSELY, THE FRAME HAS COMPLETELY RUSTED THROUGH AND IS A HOLE HAS DEVELOPED FOR APPROXIMATELY 20 INCH…
Read full complaint
I WAS DRIVING IN THE MOUNTAINS AND NOTICED AN UNUSUAL NOISE UNDER MY JEEP AND GOT OUT TO CHECK IT OUT AND FOUND THAT MY FRAME HAD CRACKED UNDER THE PASSENGER SEAT WHERE THE CONTROL ARM IS WELDED TO THE FRAME. AFTER LOOKING MORE CLOSELY, THE FRAME HAS COMPLETELY RUSTED THROUGH AND IS A HOLE HAS DEVELOPED FOR APPROXIMATELY 20 INCHES ALONG THE CENTER OF THE BOTTOM OF THE FRAME RAIL AND UP AND THROUGH WHERE THE CONTROL ARM BRACKET IS WELDED TO THE FRAME. THERE IS ONLY ABOUT 1 INCH OF WELD STILL HOLDING ON THE OUTSIDE BRACKET. I WAS AFRAID TO DRIVE HOME. FROM THE LOOKS OF THE RUST, THE ENTIRE FRAME COULD BUCKLE AT ANY TIME. I AM NOT A ROCK CRAWLER AND DO NOT ABUSE MY JEEP. IT IS ALL STOCK AND HAS REALLY ONLY BEEN DOWN DIRT ROADS AND NOT TRAILS. UPON SEARCHING ONLINE, I FOUND THAT MANY OTHER WRANGLER OWNERS ARE EXPERIENCING A SIMILAR PROBLEM SEVERAL ACTUALLY HAD THEIR CROSSOVER SUPPORT FOR THE TRANSMISSION FALL OUT OF THE VEHICLE. I KNOW THESE VEHICLES ARE 10 YEARS OLD BUT WE ARE TALKING ABOUT THE FRAME HERE. THIS IS UNSAFE AND CERTAINLY A MANUFACTURER DEFECT OR DESIGN OVERSIGHT. AFTER ALL, IT IS A JEEP WHICH IS EXPECTED TO GET SOME USE OFF ROAD. I CAN'T IMAGINE WHAT IT WOULD BE LIKE IF I TRULY SPENT SOME TIME OFF ROAD. PLEASE TAKE THE NECESSARY STEPS TO AT LEAST LET OWNERS KNOW THERE COULD BE A PROBLEM. I NORMALLY DON'T LOOK UNDER MY VEHICLE AND THIS COULD HAVE EASILY GONE UNNOTICED AND COMPROMISED THE ENTIRE FRAME STRUCTURE IF I HAD AN ACCIDENT. *TR
NHTSA ODI #10490066
160,000 miles · Feb 18, 2012
SteeringSuspensionWheels
JEEP FRONT END WOBBLES WHEN HITTING A BUMP AT HIGHWAY SPEEDS. AKA DEATH WOBBLE. MUST SLOW DOWN IMMEDIATELY, LOSS OF CONTROL.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN SPORT UTILITY VEHICLES, WATER AND IMPURITIES CAN ENTER INTO THE IGNITION SWITCH, CAUSING A SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH WITH A REDESIGNED SWITCH. OWNER NOTIFICATION BEGAN APRIL 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration