I FEEL WRANGLER ARE ADVERTISED AS RUGGED - BUT THEY ARE ANYTHING BUT RUGGED!! LOTS OF TROUBLE. CHRYSLER DID NOTHING TO HELP EXCEPT OFFER COSTLY REPAIRS (NEW SEAT FOR $1,200 THAT WAS CHEAPLY MADE, FIX DOOR LOCKS FOR $200 THAT KEPT BREAKING AND WINDOWS THAT WOULD NOT ROLL UP OR DOWN EASILY) THAT I FELT SHOULD NOT HAVE BEEN AT MY …
Read full complaint
I FEEL WRANGLER ARE ADVERTISED AS RUGGED - BUT THEY ARE ANYTHING BUT RUGGED!! LOTS OF TROUBLE. CHRYSLER DID NOTHING TO HELP EXCEPT OFFER COSTLY REPAIRS (NEW SEAT FOR $1,200 THAT WAS CHEAPLY MADE, FIX DOOR LOCKS FOR $200 THAT KEPT BREAKING AND WINDOWS THAT WOULD NOT ROLL UP OR DOWN EASILY) THAT I FELT SHOULD NOT HAVE BEEN AT MY EXPENSE. CHRYSLER'S ANSWERS WHEN I COMPLAINED WERE - I USED EXCESSIVE FORCE ALL THE TIME. THE DRIVERS SEAT BROKE - FIRST TIME I RECLINDED IT. AFTER TEARING IT APART - IT WAS OBVIOUSLY MADE VERY CHEAPLY - ONE THIN METAL PART GOING UP THE BACK OF THE SEAT. HOW IS THAT GOING TO HOLD ANYONE IN CASE OF REAR IMPACT OR RECLINING THE SEAT WITHOUT BREAKING?? SAME WITH THE PLASTIC PARTS FOR THE WINDOW ROLLER (EASILY BREAKABLE) AND WHO DESIGNED THE STUPID PART (BAR AND PIN) FOR THE DOOR LOCKS. OH YEAH, AND MY ENGINED DIED ONCE - $200 IN NEW WIRING AND TOE BILLS. THEY TOLD ME I MUST HAVE BEEN OFFROAD RUFFING IT - EXCESSIVE FORCE AGAIN. I NEVER TOOK THE JEEP OFFROAD EVER - BUT OF COURSE THEY WOULD NOT BELIEVE ME. ALSO, I HAVE REPLACED THE FRONT WINDSHIELD 3 TIMES NOW. MY MAIN POINT IS CHRYSLER FAILED ME - SOLD ME A VERY CHEAPLY MADE VEHICLE AND DID NOT STAND BEHIND THEIR CHEAP PRODUCT. I FELL I AM THE BEST OR WORSE ADVERTISER FOR THIS VEHICLE THEY HAVE AND I MAKE SURE TO FULLY EXPLAIN ALL THE PROBLEMS I HAVE EXPERIENCED WITH MY WRANGLER.
NHTSA ODI #734177
Mileage unknown · Mar 20, 2000
Engine And Engine CoolingLatches/locks/linkagesVisibility
EXHAUST MANIFOLD - REAR STUD ON DRIVER'S SIDE HAS BROKEN OFF LEADING TO AN EXHAUST LEAK. CAUSES NOISE AND EXCESS O2 IN EXHAUST SYSTEM SIGNAL COMPUTER TO INCREASE FUEL RICHNESS WHICH TAXES THE CATALYTIC CONVERTER, CAUSING EARLY FAILURE. CATALYTIC CONVETER HAS BEEN REPLACED THREE TIMES AS RESULT. DOOR LOCKS - THE DOOR LOCKS ON …
Read full complaint
EXHAUST MANIFOLD - REAR STUD ON DRIVER'S SIDE HAS BROKEN OFF LEADING TO AN EXHAUST LEAK. CAUSES NOISE AND EXCESS O2 IN EXHAUST SYSTEM SIGNAL COMPUTER TO INCREASE FUEL RICHNESS WHICH TAXES THE CATALYTIC CONVERTER, CAUSING EARLY FAILURE. CATALYTIC CONVETER HAS BEEN REPLACED THREE TIMES AS RESULT. DOOR LOCKS - THE DOOR LOCKS ON BOTH THE PASSENGER AND DRIVER SIDE HAVE BROKEN, MAKING IT IMPOSSIBLE TO UNLOCK DOOR FROM OUTSIDE WITH KEY. BY TURNING KEY, THE LOCK BEGINS TO DISENGAGE, BUT NOT ENOUGH TO UNLOCK DOOR. THIS CREATES NEED TO LEAVE WINDOWS DOWN CONTINUOUSLY IN ORDER TO GAIN ACCESS TO VEHICLE BY OPENING DOOR FROM INSIDE THROUGH WINDOW. MAJOR SECURITY ISSUE!
NHTSA ODI #720352
Mileage unknown · Feb 28, 2000
Visibility
WINDSHIELD IS DAMAGED DUE TO BOND FAILURE. YH
NHTSA ODI #551106
Mileage unknown · Sep 10, 1996
Power TrainService Brakes, HydraulicVisibility
ANTILOCK BRAKES LOCK UP, CAUSING DRIVER TO LOSE CONTROL OF VEHICLE.
NHTSA ODI #508486
Mileage unknown · Aug 19, 1996
EquipmentLatches/locks/linkagesVisibility
WHILE CONSUMER WAS DRIVING, PASSENGER'S SIDE DOOR FLEW OPEN.*AK LOCKS ON DOORS HAVE FAILED THREE TIMES, DOOR HAS FLEW OPEN WHILE DRIVING BECAUSE OF FAILURE. WINDOWS FALL DOWN IN DOOR CHANNEL, CONSUMER HAS TAKEN THIS PROBLEM TO THE DEALER ON SEVEN OCCASIONS. AIR CONDITIONER LEAKS INSIDE VEHICLE AND HAS BEEN TO DEALER ON THREE …
Read full complaint
WHILE CONSUMER WAS DRIVING, PASSENGER'S SIDE DOOR FLEW OPEN.*AK LOCKS ON DOORS HAVE FAILED THREE TIMES, DOOR HAS FLEW OPEN WHILE DRIVING BECAUSE OF FAILURE. WINDOWS FALL DOWN IN DOOR CHANNEL, CONSUMER HAS TAKEN THIS PROBLEM TO THE DEALER ON SEVEN OCCASIONS. AIR CONDITIONER LEAKS INSIDE VEHICLE AND HAS BEEN TO DEALER ON THREE OCCASIONS. *SLC
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS, THE PARKING BRAKE CAN SELF-RELEASE WITHOUT WARNING.
Consequence & remedy
Consequence: THIS COULD ALLOW THE VEHICLE TO ROLL AWAY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A PARKING BRAKE ASSEMBLY WITH A STRONGER PAWL RETURN SPRING. OWNER NOTIFICATON BEGAN SEPTEMBER 30, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH PLASTIC FUEL TANKS. THE FUEL TANK SENDING UNIT GASKET CAN CRACK CAUSING FUEL AND FUEL VAPOR LEAKS.
Consequence & remedy
Consequence: FUEL AND FUEL VAPOR LEAKED FROM THE FUEL TANK CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Remedy: REPLACE THE FUEL TANK SENDING UNIT GASKET.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA01003 · Parking Brake Resulting In Rollaway
Opened Jan 11, 2001 · Closed Mar 25, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE00038 · Parking Brake
Opened Sep 15, 2000 · Closed Jan 11, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ALLEGED THE THE PARKING BRAKE FAIL TO HOLD THE VEHICLE STATIONARY WHEN APPLIED, AND THE VEHICLE ROLLED AWAY
EA99014 · Brake Roter Disc/hud Separation
Opened Jun 28, 1999 · Closed Mar 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ODI HAS RECEIVED 6 REPORTS ON FUEL LEAKAGE AND 3 REPORTS ON ALLEGED REMEDY FAILURE REPORTS
PE95049 · Rear Axle Shaft Separation
Opened Aug 17, 1995 · Closed Jan 26, 1996
Status: closed (inferred from source dates) · Suspension
THIS INVESTIGATION WAS OPENED TO EXAMINE THE FAILURE MODE AND THE RISK TO MOTOR VEHICLE SAFETY POSED BY ALLEGATIONS OF REAR AXLE SEPARATIONS.THE REAR AXLE SHAFT AND HOUSING DESIGN IS TYPICAL OF THOSE IN WHICH THE WEIGHT OF THE VEHICLE IS CARRIED ON THE AXLE HOUSING.THE LEFT AND RIGHT AXLE SHAFTS, SUPPORTED BY ROLLER BEARINGS, ARE SITUATED INSIDE THE AXLE HOUSING.THE INBOARD SPLINED END OF THE AXLE SHAFT RECEIVES POWER TRANSMITTED FROM THE DIFFERENTIAL ASSEMBLY, PROVIDING TORQUE TO THE REAR WHEELS.THE ALLEGATIONS ARE THAT THE AXLE SHAFT FAILS, RESULTING IN THE SEPARATION OF A WHEEL AND AXLE HUB ASSEMBLY OR THE ENTIRE AXLE SHAFT AND WHEEL ASSEMBLY, DEPENDING ON THE LOCATION OF THE AXLE SHAFT FAILURE.AS IDENTIFIED BY CHRYSLER, THE SUBJECT REAR AXLES ARE DANA 35C AND 35CM MODELS, WHICH HAVE BEEN USED ON THE SUBJECT VEHICLES SINCE THE 1990 MODEL YEAR.A SAFETY DEFECT TREND WITH RESPECT TO THE SUBJECT AXLE SHAFTS HAS NOT BEEN IDENTIFIED.SEE HARD COPY RESUME FOR FULL TEXT OF SUMMARY.
Illustration