NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
297 reportsClear category filter40,190 miles · Dec 17, 2018
Electrical SystemEnginePower Train
I'VE HAD A SERVICE SHIFTER MESSAGE APPEAR NUMEROUS TIMES AND THEN DISAPPEAR. WHEN I WOULD TAKE IT IN TO GET LOOKED AT I WAS TOLD THAT THERE WAS NO RECORD OF THAT CODE BEING DISPLAYED IN THE CAR LOG/MEMORY AND THAT THE SERVICE DEPARTMENT AT THE DELEARSHIP COULDN'T FIND ANYTHING WRONG WITH IT. UPON DOING RESEARCH ON THIS MESSAGE …
Read full complaint
I'VE HAD A SERVICE SHIFTER MESSAGE APPEAR NUMEROUS TIMES AND THEN DISAPPEAR. WHEN I WOULD TAKE IT IN TO GET LOOKED AT I WAS TOLD THAT THERE WAS NO RECORD OF THAT CODE BEING DISPLAYED IN THE CAR LOG/MEMORY AND THAT THE SERVICE DEPARTMENT AT THE DELEARSHIP COULDN'T FIND ANYTHING WRONG WITH IT. UPON DOING RESEARCH ON THIS MESSAGE I FOUND THAT MANY OTHER PEOPLE HAVE HAD THIS SAME PROBLEM AND IF LEFT UNCHECKED CAN CAUSE THE VECHICLE TO SHIFT INTO PARK WHILE IN MOTION CAUSING LOSS OF CONTROL AND ACCIDENTS. I HAVE RECEIVED THIS MESSAGE WHILE BOTH STATIONARY JUST WHEN I TURNED THE CAR ON, AND ALSO WHILE IN MOTION ON A ROAD.
NHTSA ODI #11161945
52,000 miles · Dec 11, 2018
Electrical SystemEngineVehicle Speed Control
TAKATA RECALL MY 2016 JEEP CHEROKEE WILL SHUT OFF WHILE IN MOTION. THE CAR DIED WHILE GOING THROUGH AN INTERSECTION. I WAS ABLE TO COAST INTO A SAFE PLACE, BUT CAR WOULD NOT RESTART AGAIN AFTER FOR A FEW HOURS. MY HUSBAND WAS DRIVING THE CAR AND CAME TO A STOP AT AN INTERSECTION WHEN THE CAR DIED AGAIN. THE CAR STARTED ROLLING B…
Read full complaint
TAKATA RECALL MY 2016 JEEP CHEROKEE WILL SHUT OFF WHILE IN MOTION. THE CAR DIED WHILE GOING THROUGH AN INTERSECTION. I WAS ABLE TO COAST INTO A SAFE PLACE, BUT CAR WOULD NOT RESTART AGAIN AFTER FOR A FEW HOURS. MY HUSBAND WAS DRIVING THE CAR AND CAME TO A STOP AT AN INTERSECTION WHEN THE CAR DIED AGAIN. THE CAR STARTED ROLLING BACKWARDS AND HE ALMOST HIT THE CAR BEHIND HIM. THIS IS NOT SAFE. WE HAVE A ONE MONTH OLD CHILD, AND I DO NOT FEEL SAFE PUTTING HER IN THE CAR. *DT*JB
NHTSA ODI #11160782
Mileage unknown · Nov 17, 2018
Electrical System
THE TURN SIGNAL RIGHT STARTED TO GO OFF TOOK IT TO DEALER THEY REPAIR THIS HAPPEN S4 TIMES IN 2 YRS NOW THE LEFT SIDE IS DOING IT AND THE RIGHT SIDE ALSO THEY SAID IS NOT UNDER WARRANTY AND ITS GOING TO COST ME 1200 DOLLARS TO REPLACE THE TURN SIGNAL ASSEMBLY EACHI TS NOT A PART THAT IS MOVED ITS A PLUG.
NHTSA ODI #11152147
16,000 miles · Oct 15, 2018
Electrical SystemPower Train
I PURCHASED MY VEHICLE NEW. SINCE HAVING IT THE PANEL WHICH DISPLAYS THE RADIO WILL RANDOMLY GO BLACK. I'VE ALSO HAD SEVERAL ISSUES WITH ACCELERATION. SOMETIMES IF I'M AT A RED LIGHT AND THEN IT TURNS GREEN THE CAR WILL REV AND NOT MOVE ANYWHERE FOR ABOUT 30 SECONDS. YESTERDAY WHILE I WAS ON THE HIGHWAY MY SPEED DROPPED FROM 60 …
Read full complaint
I PURCHASED MY VEHICLE NEW. SINCE HAVING IT THE PANEL WHICH DISPLAYS THE RADIO WILL RANDOMLY GO BLACK. I'VE ALSO HAD SEVERAL ISSUES WITH ACCELERATION. SOMETIMES IF I'M AT A RED LIGHT AND THEN IT TURNS GREEN THE CAR WILL REV AND NOT MOVE ANYWHERE FOR ABOUT 30 SECONDS. YESTERDAY WHILE I WAS ON THE HIGHWAY MY SPEED DROPPED FROM 60 TO 40 VERY FAST AND I WAS NOT ABLE TO ACCELERATE AT ALL AND HAD TO PULL OVER ON THE SIDE OF THE ROAD AND MY TRANSMISSION LIGHT CAME ON. I'VE ALSO BEEN DRIVING BEFORE AND WHEN I HIT THE BRAKE IT MAKES A NOISE LIKE ITS SHIFTING SUPER LOUD AND THE BRAKE CLICKS. MY VEHICLE IS IN FOR SERVICE RIGHT NOW BUT I DONT FEEL SAFE DRIVING IT AT ALL. IT ONLY HAS 16,000 MILES ON IT AND SHOULDN'T BE HAVING ALL OF THESE ISSUES WITH SUCH LOW MILEAGE. YESTERDAY NOT BEING ABLE TO ACCELERATE ON THE HIGHWAY WAS SCARY AND DANGEROUS.
NHTSA ODI #11140360
27,000 miles · Oct 1, 2018
Electrical SystemPower Train
WHILE DRIVING ON HIGHWAY, AUTOMATIC 9 SPEED TRANSMISSION SEEMED TO LOSE ALL ACCELERATION AT AROUND 60MPH. THE "SERVICE TRANSMISSION" NOTIFICATION APPEARED ON THE DISPLAY, AND THE VEHICLE STARTED DECELERATING UNTIL IT WAS NECESSARY TO PULL OVER AND PARK. PROBLEM SEEMED FIXED AFTER AN ENGINE RESTART, BUT OCCURRED AGAIN AT HIGHER…
Read full complaint
WHILE DRIVING ON HIGHWAY, AUTOMATIC 9 SPEED TRANSMISSION SEEMED TO LOSE ALL ACCELERATION AT AROUND 60MPH. THE "SERVICE TRANSMISSION" NOTIFICATION APPEARED ON THE DISPLAY, AND THE VEHICLE STARTED DECELERATING UNTIL IT WAS NECESSARY TO PULL OVER AND PARK. PROBLEM SEEMED FIXED AFTER AN ENGINE RESTART, BUT OCCURRED AGAIN AT HIGHER SPEED (60MPH). I DON'T KNOW WHY 2016 VEHICLES WERE NOT INCLUDED IN THE S55 RECALL, IT IS THE SAME ISSUE.
NHTSA ODI #11132685
12,000 miles · Sep 25, 2018
Electrical SystemService Brakes
EACH TIME I HAVE BEEN DRIVING THE VEHICLE WHEN THE BRAKES FAILED WITHOUT WARNING THE LAST TIME (4TH TIME) MY CAR WAS IN THE SHOP BECAUSE THE TRANMISSION SEAL HAD A LEAK. WHILE THE MECHANIC WAS TEST DRIVING THE CAR THE BRAKES FAILED WITH HIM. WHEN I HAVE HAD BEEN DRIVING THE JEEP AND THE BRAKES FAILED I WAS PULLING INTO DIFF…
Read full complaint
EACH TIME I HAVE BEEN DRIVING THE VEHICLE WHEN THE BRAKES FAILED WITHOUT WARNING THE LAST TIME (4TH TIME) MY CAR WAS IN THE SHOP BECAUSE THE TRANMISSION SEAL HAD A LEAK. WHILE THE MECHANIC WAS TEST DRIVING THE CAR THE BRAKES FAILED WITH HIM. WHEN I HAVE HAD BEEN DRIVING THE JEEP AND THE BRAKES FAILED I WAS PULLING INTO DIFFERENT LOCATIONS AND THE BRAKES WOULD FAIL AND NOT STOP THE CAR. THE BRAKE WERE AS HARD AS A ROCK AND JUST SIMPLY WOULD NOT STOP THE CAR. I FEEL AFTER 4 TIMES THIS CAR IS NOT REPAIRABLE AND I AM NOW MENTALLY ANQUISHED WITH DRIVING IT I AM AFRAID THE BRAKES WILL FAIL AGAIN AND I MIGHT GET INTO AN ACCIDENT BECAUSE OF THE BRAKE ISSUE AND POSSIBLY GET HURT, KILLED, KILL SOMEONE ELSE THIS IS WITHOUT A DOUBT A SAFETY ISSUE. THE MECHANIC AT THE DEALERSHIP HAS EVEN SAID THE CAR IS NOT SAFE. I HAVE A CASE NUMBER WITH THE CHRYSLER MANUFACTURER ON THE CASE. IT IS# 35139860
NHTSA ODI #11131478
200 miles · Sep 21, 2018
Electrical SystemUnknown Or OtherVehicle Speed Control
I HAVE HAD TRANSMISSION ISSUES SINCE BUYING THE VEHICLE. I HAVE BEEN TO THE DEALER ABOUT 3 OR 4 TIMES TO HAVE THE ISSUE FIXED AND IT WAS NEVER FIXED. LOW POWER, HESITATIONS IN ACCELERATION, RANDOMLY DROPPING SPEED WHILE ACCELERATION, AND COMPLETE LOSS OF POWER. IT HAPPENS WHEN IN MOTION AT ALL SPEEDS BUT MOSTLY AT SPEEDS UNDER 4…
Read full complaint
I HAVE HAD TRANSMISSION ISSUES SINCE BUYING THE VEHICLE. I HAVE BEEN TO THE DEALER ABOUT 3 OR 4 TIMES TO HAVE THE ISSUE FIXED AND IT WAS NEVER FIXED. LOW POWER, HESITATIONS IN ACCELERATION, RANDOMLY DROPPING SPEED WHILE ACCELERATION, AND COMPLETE LOSS OF POWER. IT HAPPENS WHEN IN MOTION AT ALL SPEEDS BUT MOSTLY AT SPEEDS UNDER 40 MPH. IT ALL CONTINUES TO THIS DAY AND I HAVE ALL BUT GIVEN UP ON GETTING CHRYSLER TO TAKE RESPONSIBILITY. I AM SOMETIMES EVEN AFRAID TO DRIVE THE VEHICLE WHEN ONE OR MORE OF THESE SYMPTOMS HAPPENS. CHRYSLER NEEDS TO TAKE RESPONSIBILITY. AS A CONSUMER I AM ENTITLED TO GET WHAT I PAY FOR!
NHTSA ODI #11130637
14,000 miles · Sep 7, 2018
Electrical SystemPower Train
I'VE HAD THE JEEP LESS THAN 2 YEARS . ONLY 14000 MILES ON IT . THE TRANSMISSION STARTED JERKING AND LUNDGING WHEN IT DOWN SHIFTED OR STARTED OFF FROM A STOP. MY DAUGHTER AND I WHERE COMING BACK FROM THE HUMAN SOCIETY. WHILE DRIVING AT ABOUT 50 MPH I HAD TO SLOW DOWN FOR ON COMING TRAFFIC.THE JEEP SHIFTED TO A LOWER GEAR AND LUNG…
Read full complaint
I'VE HAD THE JEEP LESS THAN 2 YEARS . ONLY 14000 MILES ON IT . THE TRANSMISSION STARTED JERKING AND LUNDGING WHEN IT DOWN SHIFTED OR STARTED OFF FROM A STOP. MY DAUGHTER AND I WHERE COMING BACK FROM THE HUMAN SOCIETY. WHILE DRIVING AT ABOUT 50 MPH I HAD TO SLOW DOWN FOR ON COMING TRAFFIC.THE JEEP SHIFTED TO A LOWER GEAR AND LUNGED SO FIERCELY I THOUGHT THE TRANSMISSION HAD FALLEN OFF THE VEHICLE. THE VEHCLE IMMEDIATELY SHUT DOWN. I WAS AT A COMPLETE STOP. LIGHTS STARTED FLASHING SERVICE TRANSMISSION. I HAD NO POWER TO MOVE. IM ON AN OVER PASS WITH TRAFFIC AND THERES NO WHERE TO GO IN THE MIDDLE OF TRAFFIC. BY CHANCE THE JEEP WAS ABLE TO START AND ACCELERATE TO 5MPH AND GET TO A SAFE PLACE TO PULL OVER. IT WAS A VERY SERIOUS HAZARD FOR ME AND MY DAUGHTER AND OTHER DRIVERS WE BASICALLY GLIDED TO A COMPLETE STOP IN THE MIDST OF TRAFFIC WHILE DOING 50MPH. THAN STARTING IT UP AND ONLY DOING 4 TMPH. THIS WAS CLEARLY A VERY DANGEROUS SITUATION. I DONT FEEL SAFE OR CONFENDENT. I PAID A PREMIUM PRICE FOR A VEHICLE THAT SHOULD BE DEPENDABLE AND SAFE. NOW THE JEEP WONT START. THE REAR BUTTON TO CLOSE THE HATCH HAS QUIT WORKING. THE START BUTTON WILL NOT START THE CAR AT ALL. WHEN IT STARTED TO MALFUNCTION. IT WOULD HESATATE AS IF THE BATTERY WHERE DEAD. WHEN IT DID START THE SETTINGS 'CLIMATE CONTROL WOULD BE SET TO DEFROST. THE A WOULD SHOW UP ON THE FACE WITHOUT BEING PRESSED. AND EVENTUALLY THE SCREEN WOULD NOT REACT TO TOUCH AT ALL. AND THE RADIO WOULDNT PLAY. BUT ALL ELISE SEEMED TO WORK WITHOUT A PROBLEM. THE WINDOWS WORKED FINE THE LIGHTS WHERE BRIGHT. THERE WASNT A PROBLEM WITH THE BATTERY. I AM APPLAUDED THAT JEEP WOULD THINK THIS IS ACCEPTABLE FOR A NEW VEHICLE IM THE COMSUMER. I PAID FOR A PRODUCT THAT HAS TO AND IS A TO CERTAIN EXPECTATIONS.
NHTSA ODI #11128008
67,000 miles · Sep 5, 2018
Electrical SystemPower TrainService Brakes
THE DRIVER INFORMATION CENTER SAYS SERVICE SHIFTER. WHEN ACTIVE, THE MANUAL SHIFT DOESN'T WORK BUT FORWARD REVERSE AND PARK DO NOT SEEM TO BE AFFECTED. IF YOU STOP SHUT OFF THE VEHICLE AND RESTART, IT CLEARS. IT STARTED DOING THIS 6-9 MONTHS AGO ONCE IN A WHILE BUT NOW DOES IT SEVERAL TIMES A DAY DEPENDING ON AMOUNT OF DRIVIN…
Read full complaint
THE DRIVER INFORMATION CENTER SAYS SERVICE SHIFTER. WHEN ACTIVE, THE MANUAL SHIFT DOESN'T WORK BUT FORWARD REVERSE AND PARK DO NOT SEEM TO BE AFFECTED. IF YOU STOP SHUT OFF THE VEHICLE AND RESTART, IT CLEARS. IT STARTED DOING THIS 6-9 MONTHS AGO ONCE IN A WHILE BUT NOW DOES IT SEVERAL TIMES A DAY DEPENDING ON AMOUNT OF DRIVING. WE BROUGHT IT INTO THE DEALER TO HAVE IT CHECKED AND THEY SAID THERE WAS NO CODES OR PHYSICAL PROBLEMS BUT COULD REPLACE THE SHIFTER TO SEE IF THIS WOULD FIX THE PROBLEM. WE ELECTED NOT TO DO THIS AT THE PRESENT TIME. WE HAVE HEARD OF ACCIDENTS FROM THIS SO WE JUST WANTED TO NOTIFY YOU THAT IT IS HAPPENING. WE WOULD LIKE TO ADDRESS THIS BEFORE AN ACCIDENT OCCURS.
NHTSA ODI #11124640
32,000 miles · Sep 5, 2018
Electrical SystemUnknown Or Other
THE SHIFT REPORTS SERVICE SHIFTER ALL THE LIGHTS TURN ON, HAS NOT SHIFTED ON US
NHTSA ODI #11124485
Official recalls
9May 11, 2023
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Additional source detail variants (2)
Structure:body:hatchback/liftgate
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Electrical System:wiring: Rear Compartment/trunk
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Apr 27, 2023
Chrysler (FCA US, LLC) is recalling certain 2016-2017 Jeep Cherokee vehicles. The power transfer unit (PTU) may become damaged and disengage the transmission and differential, resulting in a loss of drive power or loss of park function.
Consequence & remedy
Consequence: A loss of drive power can increase the risk of a crash. A loss of park function can cause an unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update, free of charge. Owner notification letters were mailed May 11, 2023. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is 45A. This recall expands previous recall number 20V-343.
Jun 11, 2020
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence & remedy
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Additional source detail variants (2)
Power Train:driveline:differential Unit
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Power Train:automatic Transmission
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Dec 21, 2017
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.
Aug 10, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence & remedy
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Additional source detail variants (2)
Seats:mid/rear Assembly
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Seats
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
May 11, 2016
Chrysler Group LLC (Chrysler) is recalling certain model year 2016 Jeep Cherokee vehicles manufactured October 3, 2015, to March 22, 2016. The right halfshaft may have been incorrectly manufactured causing it to fracture without warning.
Consequence & remedy
Consequence: A fractured halfshaft may disconnect from the drive axle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the right halfshaft, free of charge. The recall began on June 30, 2016. Owners may contact Chrysler's customer service at 1-800-853-1403. Chrysler's recall number is S39.
May 11, 2016
Chrysler Group LLC (Chrysler) is recalling certain model year 2016 Jeep Cherokee vehicles manufactured September 30, 2015, to October 2, 2015. The left halfshaft may have been incorrectly manufactured causing it to fracture without warning.
Consequence & remedy
Consequence: A fractured halfshaft may disconnect from the drive axle, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the left halfshaft, free of charge. The recall began on June 30, 2016. Owners may contact Chrysler's customer service at 1-800-853-1403. Chrysler's recall number is S38.
Dec 9, 2015
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Cherokee vehicles manufactured February 18, 2015, to September 10, 2015 and equipped with the power liftgate option. In the affected vehicles, water may leak into the Power Liftgate Control Module and result in a high resistance short circuit.
Consequence & remedy
Consequence: A short circuit in the module increases the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the module and connectors for corrosion, replacing the damaged components as necessary. The mastic shield will be removed and the module will be covered with a water shield. These repairs will be performed free of charge. The recall began on February 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R67. This recall is superseded by NHTSA recall 23V-338.
Additional source detail variants (2)
Structure:body:hatchback/liftgate
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Cherokee vehicles manufactured February 18, 2015, to September 10, 2015 and equipped with the power liftgate option. In the affected vehicles, water may leak into the Power Liftgate Control Module and result in a high resistance short circuit.
Consequence: A short circuit in the module increases the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the module and connectors for corrosion, replacing the damaged components as necessary. The mastic shield will be removed and the module will be covered with a water shield. These repairs will be performed free of charge. The recall began on February 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R67. This recall is superseded by NHTSA recall 23V-338.
Electrical System:wiring: Rear Compartment/trunk
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Cherokee vehicles manufactured February 18, 2015, to September 10, 2015 and equipped with the power liftgate option. In the affected vehicles, water may leak into the Power Liftgate Control Module and result in a high resistance short circuit.
Consequence: A short circuit in the module increases the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the module and connectors for corrosion, replacing the damaged components as necessary. The mastic shield will be removed and the module will be covered with a water shield. These repairs will be performed free of charge. The recall began on February 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R67. This recall is superseded by NHTSA recall 23V-338.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE22009 · Electronic Parking Brake Water Ingress
Opened Jul 22, 2022 · Closed Oct 29, 2023
Status: closed (inferred from source dates) · Parking Brake:electrical; Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Parking Brake:electrical
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration