REAR DRIVERSIDE TIRE (BF GOODRICH RADIAL LONG TRAIL T/A) ON AN ISUZU RODEO RAPIDLY SEPARATED WHILE TRAVELING ON THE HIGHWAY. AS A RESULT, THE VEHICLE ROLLED OVER 1-1/4 TIMES. ROOF OF THE VEHICLE CAVED IN AS WELL AS THE WINDSHIELD CAUSING HEAD INJURIES TO ONE OCCUPANT OF 5 IN THE VEHICLE. ALL 5 OCCUPANTS SUSTAINED INJURIES AND…
Read full complaint
REAR DRIVERSIDE TIRE (BF GOODRICH RADIAL LONG TRAIL T/A) ON AN ISUZU RODEO RAPIDLY SEPARATED WHILE TRAVELING ON THE HIGHWAY. AS A RESULT, THE VEHICLE ROLLED OVER 1-1/4 TIMES. ROOF OF THE VEHICLE CAVED IN AS WELL AS THE WINDSHIELD CAUSING HEAD INJURIES TO ONE OCCUPANT OF 5 IN THE VEHICLE. ALL 5 OCCUPANTS SUSTAINED INJURIES AND 2 REQUIRED HOSPITALIZED. *TR
NHTSA ODI #10230938
253,162 miles · Sep 25, 2006
Tires
I WAS NORTH BOUND ON VIRGINIA 220 APPROXIMATELY 3 MILES WEST OF MARTINSVILLE, VA RETURNING FROM A FUNERAL IN NORTH CAROLINA. I EXPERIENCED A LOW FREQUENCY VIBRATION FOR A 3 OR 4 SECOND PERIOD THAT INCREASED IN AMPLITUDE UNTIL THERE WAS A VIOLENT EXPLOSION IN THE FRONT OF MY VEHICLE. I RECOVERED CONTROL OF THE CAR AND STEERED I…
Read full complaint
I WAS NORTH BOUND ON VIRGINIA 220 APPROXIMATELY 3 MILES WEST OF MARTINSVILLE, VA RETURNING FROM A FUNERAL IN NORTH CAROLINA. I EXPERIENCED A LOW FREQUENCY VIBRATION FOR A 3 OR 4 SECOND PERIOD THAT INCREASED IN AMPLITUDE UNTIL THERE WAS A VIOLENT EXPLOSION IN THE FRONT OF MY VEHICLE. I RECOVERED CONTROL OF THE CAR AND STEERED INTO THE BREAKDOWN LANE. I NOTICED IN THE REAR VIEW MIRROR THAT THERE WAS A SIGNIFICANT AMOUNT OF TIRE DEBRIS IN THE LANE I WAS TRAVELING IN. I EXITED THE VEHICLE AND NOTED THAT THE DRIVERS FRONT TIRE HAD SUFFERED A CATASTROPHIC TREAD AND CORD SEPARATION FAILURE. THE TIRE CONTINUED TO HOLD AIR PRESSURE. VIRGINIA STATE TROOPER E.J. O''CONNELL WITNESSED THE INCIDENT AND AFTERMATH AND PULLED IN BEHIND ME TO MAKE SURE I WAS UNINJURED. TROOPER O''CONNELL DEPLOYED FLARES AND PROVIDED TRAFFIC CONTROL WHILE I CHANGED THE TIRE. I PURCHASED THE TIRES IN NORTH CAROLINA IN LATE 2001 OR EARLY 2002 FROM A LOCAL BP GARAGE, GARYS BP ON HWY 64 IN LEXINGTON, NC. I DIDN'T RETAIN THE RECEIPT. I DIDN'T INSTALL THEM UNTIL 2005. THEY WERE IN DRY STORAGE IN THE LOFT ABOVE MY GARAGE. THE TIRE HAD APPROXIMATELY 21,000 MILES ON IT WHEN IT FAILED. THE TIRES ON MY RODEO HAD 34 PSI COLD PRESSURE AND WERE NOT OVER INFLATED. *JB
NHTSA ODI #10169220
Mileage unknown · Aug 29, 2000
Tires
TIRE TREAD SEPARATED. TIRES WHERE PROPERLY INFLATED AND WHERE DRIVEN AT NORMAL HIGHWAY SPEEDS. I TOOK VEHICLE TO DEALER AND BECUASE THE TIRES WHERE ONLY TWO YEARS OLD WITH A LITTLE LESS THAN 30,000 MILES ON THEM THEY REPLACED IT. THEY ALSO FOUUND ANOTHER BAD TIRE WHICH WAS REPLACED UNDER WARRANTY. MY CONCERN IS THAT THESE TI…
Read full complaint
TIRE TREAD SEPARATED. TIRES WHERE PROPERLY INFLATED AND WHERE DRIVEN AT NORMAL HIGHWAY SPEEDS. I TOOK VEHICLE TO DEALER AND BECUASE THE TIRES WHERE ONLY TWO YEARS OLD WITH A LITTLE LESS THAN 30,000 MILES ON THEM THEY REPLACED IT. THEY ALSO FOUUND ANOTHER BAD TIRE WHICH WAS REPLACED UNDER WARRANTY. MY CONCERN IS THAT THESE TIRES DID THE SAME THING THAT THE FIRESTONE RECALLED TIRES WHERE DOING. ALTHOUGH THEY WHERE NOT THE RIGHT SIZE NOR WHERE THEY MADE AT THE SAME PLANT AS THE RECALLED TIRES, I BELIEVE THAT THESE TIRES ARE ALSO DEFECT AND SHOULD BE INVESTIGATED AS WELL SO AS TO AVOID OTHER POSSIBLE ACCIDENTS OR DEATHS. IT IS A HORRIBLE COOINCIDENCE THAT THESE TIRES ARE MADE BY FIRESTONE AND HAD TREAD SEPARATIONS AS WELL AS THE RECALLED TIRES. MY GOAL HERE IS TO SIMPLY REPORT THE INCIDENT IN THE HOPE THAT THE SAFETY OF ALL CITIZENS ARE CONSIDERED BY INVESTIGATING AND POSSIBLY RECALLING THESE TIRES AS WELL.( DOT NUMBER: TIRE SIZE: 2257R15 )
NHTSA ODI #729418
Mileage unknown · Jul 20, 1999
TiresWheels
ORIGINAL LUG NUTS ON THE FRONT AND REAR TIRES ARE HARD TO GET OFF THE VEHICLE. LUG BOLT THREADS ARE TOO SOFT AND MAKES CHANGING A TIRE IMPOSSIBLE. OWNER BELIEVES THE LUG NUTS SHOULD BE RECALLED. *AK *ML
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MID-DECEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
AN INTEGRATED CIRCUIT WITHIN THE VOLTAGE REGULATOR CAN CONTAIN MANUFACTURING ERRORS.
Consequence & remedy
Consequence: THIS CAN CAUSE EXCESSIVE ELECTRICAL CHARGING OF THE VEHICLE'S ALTERNATOR, RESULTING IN ENGINE CONTROL MALFUNCTION, AND/OR EVENTUAL ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE VOLTAGE REGULATOR WITH A NEW REGULATOR.
THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE.
CONSTANT EXPANSION AND CONTRACTION OF THE CYLINDER HEAD CAUSES THE CAMSHAFT SEAL END PLUG CAN BECOME DISLODGED FROM THE CYLINDER HEAD. THIS ALLOWS OIL TO LEAK FROM THE CAMSHAFT.
Consequence & remedy
Consequence: THIS CAN CAUSE ENGINE DAMAGE AND POSSIBLE ENGINE FIRE FROM OIL LEAKING ONTO THE HOT EXHAUST SYSTEM.
Remedy: DEALERS WILL INSTALL CAMSHAFT END SEAL PLUG RETAINER PLATES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Seat Belts:front:buckle Assembly
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
Seat Belts:front:buckle Assembly
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
Seat Belts
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
Seat Belts
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
SQ96009 · Brush/grille Guard Campaign
Opened Jan 10, 1996 · No close date supplied
Status: open (inferred from source dates) · Unknown Or Other
ADDITION INFORMATION IS NEEDED TO FULLY UNDERSTAND THE NATURE AND CIRCUMSTANCES OF THE SUBJECT BULLETIN.LOSS OF AN ITEM THIS SIZE WOULD HAVE SAFETY COSEQUENCES.THIS SQ IS OPENED TO LEARN MORE ABOUT THIS ISSUE.
1994 Isuzu Rodeo Problems, Complaints & Recalls | Skip That Year
Illustration