DEFECTIVE FUEL SENDING UNIT ON A 1999 ISUZU RODEO. HAPPENED JUST AFTER WARRANTY EXPIRED AT 60,000 MILE. THE SUV HAS 80,000 MILE AND CONTINUING TO HAVE THE SAME PROBLEM. THIS IS A VERY COMMON PROBLEM AND ISUZU WILL NOT FIX IT. IT IS A MANUFACTURING DEFECT AND SHOULD BE ADDRESSED BY THE MANUFACTURER. THE REPAIR COST IS APPROX…
Read full complaint
DEFECTIVE FUEL SENDING UNIT ON A 1999 ISUZU RODEO. HAPPENED JUST AFTER WARRANTY EXPIRED AT 60,000 MILE. THE SUV HAS 80,000 MILE AND CONTINUING TO HAVE THE SAME PROBLEM. THIS IS A VERY COMMON PROBLEM AND ISUZU WILL NOT FIX IT. IT IS A MANUFACTURING DEFECT AND SHOULD BE ADDRESSED BY THE MANUFACTURER. THE REPAIR COST IS APPROXIMATELY $500.00.*AK
NHTSA ODI #10114433
Mileage unknown · Dec 1, 2004
Fuel System, Other
FUEL GAUGE DOES NOT WORK, GOES UP AND DOWN. DAUGHTER DRIVES THE CAR, PUTTING HER AT RISK OF RUNNING OUT OF FUEL ON HIGHWAY WHILE ALONE.*AK
NHTSA ODI #10100875
Mileage unknown · Jun 10, 2004
Fuel System, Other
AFTER CONFURRING WITH MANY OWNERS OF A 1999 ISUZU RODEO IT IS MY CONSENSUS THAT THERE IS A MANUFACTURER MALFUNCTION WITH THE FUEL SENDING UNIT. FUEL SENDING UNIT IS NOT WORKING PROPERLY AND CAUSES THE GAS GUAGE TO READ EMPTY. CONTACTING ISUZU HAS DONE CONSUMERS NO GOOD SINCE ISUZU DENIES ANY PROBLEM. HOWEVER IT IS MY UNDERSTANDI…
Read full complaint
AFTER CONFURRING WITH MANY OWNERS OF A 1999 ISUZU RODEO IT IS MY CONSENSUS THAT THERE IS A MANUFACTURER MALFUNCTION WITH THE FUEL SENDING UNIT. FUEL SENDING UNIT IS NOT WORKING PROPERLY AND CAUSES THE GAS GUAGE TO READ EMPTY. CONTACTING ISUZU HAS DONE CONSUMERS NO GOOD SINCE ISUZU DENIES ANY PROBLEM. HOWEVER IT IS MY UNDERSTANDING FROM A PARTICULAR ISUZU MECHANIC THAT HE REPAIRS 3-4 SENDING UNITS PER DAY. I DO NOT FEEL IT IS A CONSUMERS RESPONSIBILITY TO PAY AN ENORMOUS SERVICE COST TO FIX A PROBLEM THAT WE BELIEVE THE MANUFACTURERS KNOW ABOUT AND HAVE CHOSEN NOT TO RECALL. *AK
NHTSA ODI #10075174
Mileage unknown · Apr 27, 2004
Engine And Engine CoolingFuel System, OtherService Brakes, Air
I HAVE CONTACTED THE COMPANY 10 TIMES TO FIX THE RECALL PROBLEMS WITH MY AUTO BUT NO ONE HAS EVEN BOTHERED TO FOLLOW UP OR GIVE THE INFO I NEED. MY AUTO IS FALLING APART WITH DEFECTS AND ISUZU SEEMS TO NOT CARE. *AK
NHTSA ODI #10067934
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
1999 Isuzu Rodeo Sport Problems, Complaints & Recalls | Skip That Year
Illustration