Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 6 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
6 reports
10,721 miles · Sep 6, 2013
EnginePower Train
THE INTERNATIONAL DT 466 SCHOOL BUS ENGINE SUDDENLY EXPERIENCED EXTREME PERFORMANCE DEGRADATION WITHOUT ANY WARNING WHILE DRIVING. THE ENGINE STARTED A POPPING NOISE AND SEVERELY LACKED POWER. WE PURCHASED 75 SCHOOL BUSES IN 2008, AND 26 PERCENT OF THEM HAD ROLLER TAPPET GUIDES FAIL BY FEBRUARY 2013. IN EVERY CASE, THIS FAILU…
Read full complaint
THE INTERNATIONAL DT 466 SCHOOL BUS ENGINE SUDDENLY EXPERIENCED EXTREME PERFORMANCE DEGRADATION WITHOUT ANY WARNING WHILE DRIVING. THE ENGINE STARTED A POPPING NOISE AND SEVERELY LACKED POWER. WE PURCHASED 75 SCHOOL BUSES IN 2008, AND 26 PERCENT OF THEM HAD ROLLER TAPPET GUIDES FAIL BY FEBRUARY 2013. IN EVERY CASE, THIS FAILURE MODE RESULTED IN MAJOR DAMAGE TO ENGINE VALVE TRAIN COMPONENTS. TWO ENGINES OUT OF 26 TOTAL FAILURES TO DATE WERE NOT REPAIRABLE AND REQUIRED REPLACEMENT. THE CURRENT FAILURE HAS NOW GROWN TO 34 PERCENT. IT IS A SAFETY HAZARD TO SCHOOL CHILDREN AND OTHER VEHICLES WHEN A SCHOOL BUS ENGINE SUDDENLY EXPERIENCES SEVERE ENGINE DEGRADATION ON THE ROAD.
NHTSA ODI #10542324
30,741 miles · Apr 2, 2012
Electrical SystemExterior Lighting
THE DRIVER OF THIS SCHOOL BUS APPROACHED A STUDENTS DROP-OFF LOCATION AND ACTIVATED THE AMBER 8-WAYS. AFTER COMING TO A COMPLETE STOP, THE DRIVER OPENED THE DOOR TO LET OFF THE STUDENTS. DUE TO A FAULTY DOOR SWITCH (INTERNATIONAL PART #2207601C1) THE RED FLASHING 8-WAY LIGHTS AS WELL AS THE STOP ARM FAILED TO ACTIVATE. THIS P…
Read full complaint
THE DRIVER OF THIS SCHOOL BUS APPROACHED A STUDENTS DROP-OFF LOCATION AND ACTIVATED THE AMBER 8-WAYS. AFTER COMING TO A COMPLETE STOP, THE DRIVER OPENED THE DOOR TO LET OFF THE STUDENTS. DUE TO A FAULTY DOOR SWITCH (INTERNATIONAL PART #2207601C1) THE RED FLASHING 8-WAY LIGHTS AS WELL AS THE STOP ARM FAILED TO ACTIVATE. THIS PROMPTED THE DRIVER OF ANOTHER VEHICLE TO GO PAST THE SCHOOL BUS WHILE IT WAS STOPPED AND THE STUDENTS WERE UNLOADING. LUCKILY, NO ONE WAS INJURED IN THIS INCIDENT. UNFORTUNATELY, IT'S NOT THE FIRST TIME THIS SWITCH HAS FAILED. DELIVERY DATE OF THIS VEHICLE WAS AUG. 2007. THE ORIGINAL SWITCH WAS REPLACED ON FEB. 2008 AT 31,000 MILES. IT WAS ALSO REPLACED ON SEPT. 2010 AT 60,000 MILES, AND NOW IN APRIL, 2012 AT 92,000 MILES. WE HAVE 12 OTHER BUSES WITH THIS SAME SWITCH AND ALL OF THEM HAVE HAD SIMILAR PROBLEMS. *TR
NHTSA ODI #10453752
Mileage unknown · Oct 6, 2011
Visibility
OWNER OPERATOR OF SCHOOL BUS STATES THAT FOUR (UPPER-LOWER-RIGHT-LEFT) DUAL PANE DOOR WINDOWS HAVE FOGGED DUE TO WATER ENTRY BETWEEN THE PANES. OWNER HAS REMOVED THE PANES IN AN ATTEMPT TO CORRECT AND FOUND THAT (AT LEAST ONE OF) THE PANES HAD COMPLETELY SEPARATED FROM THE PANE "SANDWICH." OWNER WAS UNABLE TO REMOVE COATING FR…
Read full complaint
OWNER OPERATOR OF SCHOOL BUS STATES THAT FOUR (UPPER-LOWER-RIGHT-LEFT) DUAL PANE DOOR WINDOWS HAVE FOGGED DUE TO WATER ENTRY BETWEEN THE PANES. OWNER HAS REMOVED THE PANES IN AN ATTEMPT TO CORRECT AND FOUND THAT (AT LEAST ONE OF) THE PANES HAD COMPLETELY SEPARATED FROM THE PANE "SANDWICH." OWNER WAS UNABLE TO REMOVE COATING FROM THE GLASS WITH SOLVENTS, ETC. THIS OWNER IS PART OF A GROUP OF EIGHT PURCHASERS WHO PURCHASED A PORTION OF "ON-SITE" INVENTORY OF BUSSES WHICH WERE ALL EQUIPPED WITH THE SAME GLASS FEATURE (I.E. PURCHASERS DID NOT SPECIFY THIS OPTION). OWNER OF A RELATED VEHICLE PREVIOUSLY FILED VOQ 10416533. *TR
NHTSA ODI #10428931
1,745 miles · Sep 19, 2011
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
HAVE HAD NOTHING BUT PROBLEMS WITH THIS VEHICLE SINCE I PURCHASED IT 10/07. ELECTRICAL, WOULD NOT START IN COLD WEATHER, CONTINUAL DRAW ON BATTERIES REPLACED WITH NEW AND ALSO ADDED A THIRD. NUMEROUS EGR VALVES, EGR COOLERS, LOW PRESSURE FUEL PUMPS, FUEL SUPPLY CONNECTORS DPF'S, WILL NOT DO MANUAL REGEN WHEN INDICATORS ON DASHBO…
Read full complaint
HAVE HAD NOTHING BUT PROBLEMS WITH THIS VEHICLE SINCE I PURCHASED IT 10/07. ELECTRICAL, WOULD NOT START IN COLD WEATHER, CONTINUAL DRAW ON BATTERIES REPLACED WITH NEW AND ALSO ADDED A THIRD. NUMEROUS EGR VALVES, EGR COOLERS, LOW PRESSURE FUEL PUMPS, FUEL SUPPLY CONNECTORS DPF'S, WILL NOT DO MANUAL REGEN WHEN INDICATORS ON DASHBOARD CALL FOR IT, THIS HAS NEVER WORKED PROPERLY, USES OIL AND ANTIFREEZE CONTINUALLY, STEERING COLUMN HAD TO BE REPLACED AT APPROX. 40,000 MILES, ALOT OF DIESEL FUEL HAS BEEN IN OIL, APRIL 2010,OIL AND AGAIN SEPT 2011. HAVE ALSO HAD TO REPLACE SERVICE DOOR MOTOR,CROSS GATE MOTOR(SEVERAL)THERMO PANE GLASS DOORS LEAKED, FORMED CONDENSATION AND DRIED LEAVING A CLOUDY RESIDUE RESTRICTING VISIBILITY, HAD TO BE REPLACED. MANY OTHER REPAIRS HAVE BEEN DONE TO. THIS VEHICLE DEALER REPAIR SHOPS ALSO DO NOT GIVE RECEIPTS WHEN WARRANTY WORK IS DONE. WHEN ASKED THEY TELL ME IT NEEDS TO GO THROUGH INTERNATIONAL FIRST AND THEN COPY WILL BE GIVEN, BUT RARELY HAPPENS. I SHOULD NOT HAVE TO KEEP ASKING. VEHICLE HAS BEEN IN DEALER REPAIR SHOPS AND MECHANICS HAVE DONE SERVICE CALLS MORE THAN 40 TIMES! THIS WAS MOST RECENTLY FROM THE END OF JUNE 2011 TO AUGUST 24,2011 AT TWO DIFFERENT FACILITIES WITH OUT ANY SATISFACTION, ONLY TO DRIVE IT AGAIN ON SEPT. 1,2011 TO HAVE MORE DIESEL IN THE OIL AND HARD TO START. ENGINE ALSO HAS A STUDDER, DEALER MODIFIED TRANI TO MAKE UP FOR THIS HESITATION WHICH HAS ONLY MADE IT WORSE. NOW DEALER HAS FINALLY AUTHORIZED INJECTORS TO BE REPLACED, MY CONCERN IS WHAT HAS ALREADY HAPPENED TO THE REST OF THE ENGINE? THE DEALER SHOULD PUT A NEW ENGINE IN WHILE THIS IS STILL UNDER WARRANTY OR LEMON LAW SHOULD ALSO BE ALLOWED FOR COMMERCIAL VEHICLES. *KB
NHTSA ODI #10426286
60,000 miles · Aug 1, 2011
Visibility
TL* THE CONTACT OWNS A 2008 INTERNATIONAL CE SCHOOL BUS. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION AND THEY DETECTED A CONDENSATION RESIDUE BUILDUP IN THE GLASS ON THE FOUR ENTRY DOOR PANELS. THE WHITE RESIDUE COMPLETELY OBSTRUCTED THE VISIBILITY. THE MANUFACTURER WAS NOTIFIED OF THE PROB…
Read full complaint
TL* THE CONTACT OWNS A 2008 INTERNATIONAL CE SCHOOL BUS. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION AND THEY DETECTED A CONDENSATION RESIDUE BUILDUP IN THE GLASS ON THE FOUR ENTRY DOOR PANELS. THE WHITE RESIDUE COMPLETELY OBSTRUCTED THE VISIBILITY. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. UPDATED 09/28/11*LJ UPDATED
NHTSA ODI #10416453
15,000 miles · Mar 21, 2011
Fuel System, Diesel
HI, I WOULD LIKE TO REPORT DEFECTIVE FUEL LINES ON IHC BUSSES. THE YEARS RANGE FROM 2008 365 ENGINE TO 2011 MAXFORCE 7. THE PROBLEM IS THEY HAVE ALUMIUM FUEL LINES AND HAVE STAINLESS KEEPERS FOR THE QUICK DISCONECT. THEY ARE RUBBING THROUGH AND CAUSING FUEL LEAKS. IT SPAYS UP ON MOTOR AND EXHAUST. I TOLD OUR LOCAL DEALER IN 200…
Read full complaint
HI, I WOULD LIKE TO REPORT DEFECTIVE FUEL LINES ON IHC BUSSES. THE YEARS RANGE FROM 2008 365 ENGINE TO 2011 MAXFORCE 7. THE PROBLEM IS THEY HAVE ALUMIUM FUEL LINES AND HAVE STAINLESS KEEPERS FOR THE QUICK DISCONECT. THEY ARE RUBBING THROUGH AND CAUSING FUEL LEAKS. IT SPAYS UP ON MOTOR AND EXHAUST. I TOLD OUR LOCAL DEALER IN 2008 AND SEVERAL TIMES SINCE. IT IS GOING TO CAUSE FIRE AND OR DEATH. I AM SURE THIS COULD BE SOLVED BY USING STAINLEES LINES. THE CHILDEREN THAT RIDE MY BUSSES COME FIRST. PLEASE HELP BEFORE THEY KILL SOMEONE. THANK YOU *TR
NAVISTAR HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2010 AND 2011 IC CE, HC, AND BE COMMERCIAL BUSES AND INTERNATIONAL 1300, 3200, 3300, 4100, 4200, 4300, 4400, AND MXT TRUCKS MANUFACTURED FROM NOVEMBER 19, 2003 THROUGH FEBRUARY 9, 2010. THE PARKING BRAKE MAY RELEASE IF THE BRAKE SYSTEM ELECTRONIC CONTROL UNIT (ECU) SOFTWARE MISINTERPRETS INPUT SIGNALS GENERATED FROM CYCLING THE IGNITION SWITCH MORE THAN ONCE AT A SPECIFIC FREQUENCY.
Consequence & remedy
Consequence: RELEASE OF THE PARKING BRAKE MAY CAUSE SUDDEN, UNEXPECTED SHIFT IN VEHICLE POSITION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL DAMAGE, OR DEATH.
Remedy: NAVISTAR WILL NOTIFY OWNERS AND WILL REPAIR THE VEHICLES BY REPROGRAMMING THE VEHICLE'S BRAKE SYSTEM ECU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 14, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-260-461-1890.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE12011 · High Pressure Oil Line Rupture
Opened Apr 16, 2012 · Closed Oct 2, 2012
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine:diesel
On April 16, 2012 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE12-011) to assess the risks associated with rupture of the high pressure oil line to the fuel injectors causing an engine stall in model year (MY) 2008 International CE school buses equipped with International I-6 diesel engines.On August 31, 2012 ODI received Navistar's response to its August 2, 2012, information request letter and identified 3 consumer complaints with one involving an oil line rupture that resulted in an engine compartment fire.ODI also identified 470 warranty claims related to the defect.This calculates to a warranty rate of 2.8 percent for the subject population.Navistar has released two Technical Service Information (TSI) bulletins and two iKNow (information) articles pertaining to the high pressure hose in the I-6 engine.Following discussions with ODI concerning the warranty rate, consumer complaints and interviews, and the risk to students resulting from a stranded bus, Navistar decided to submit recall notices (12V-473 and 12V-476) on the subject vehicles to address the high pressure hose failures.Navistar's recall actions address the issues raised by this investigation and as a result this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10450319 and 10455151.
Additional source detail variants (4)
Engine And Engine Cooling:engine:diesel
On April 16, 2012 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE12-011) to assess the risks associated with rupture of the high pressure oil line to the fuel injectors causing an engine stall in model year (MY) 2008 International CE school buses equipped with International I-6 diesel engines.On August 31, 2012 ODI received Navistar's response to its August 2, 2012, information request letter and identified 3 consumer complaints with one involving an oil line rupture that resulted in an engine compartment fire.ODI also identified 470 warranty claims related to the defect.This calculates to a warranty rate of 2.8 percent for the subject population.Navistar has released two Technical Service Information (TSI) bulletins and two iKNow (information) articles pertaining to the high pressure hose in the I-6 engine.Following discussions with ODI concerning the warranty rate, consumer complaints and interviews, and the risk to students resulting from a stranded bus, Navistar decided to submit recall notices (12V-473 and 12V-476) on the subject vehicles to address the high pressure hose failures.Navistar's recall actions address the issues raised by this investigation and as a result this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10450319 and 10455151.
Engine And Engine Cooling:engine:diesel
On April 16, 2012 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE12-011) to assess the risks associated with rupture of the high pressure oil line to the fuel injectors causing an engine stall in model year (MY) 2008 International CE school buses equipped with International I-6 diesel engines.On August 31, 2012 ODI received Navistar's response to its August 2, 2012, information request letter and identified 3 consumer complaints with one involving an oil line rupture that resulted in an engine compartment fire.ODI also identified 470 warranty claims related to the defect.This calculates to a warranty rate of 2.8 percent for the subject population.Navistar has released two Technical Service Information (TSI) bulletins and two iKNow (information) articles pertaining to the high pressure hose in the I-6 engine.Following discussions with ODI concerning the warranty rate, consumer complaints and interviews, and the risk to students resulting from a stranded bus, Navistar decided to submit recall notices (12V-473 and 12V-476) on the subject vehicles to address the high pressure hose failures.Navistar's recall actions address the issues raised by this investigation and as a result this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10450319 and 10455151.
Engine And Engine Cooling
On April 16, 2012 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE12-011) to assess the risks associated with rupture of the high pressure oil line to the fuel injectors causing an engine stall in model year (MY) 2008 International CE school buses equipped with International I-6 diesel engines.On August 31, 2012 ODI received Navistar's response to its August 2, 2012, information request letter and identified 3 consumer complaints with one involving an oil line rupture that resulted in an engine compartment fire.ODI also identified 470 warranty claims related to the defect.This calculates to a warranty rate of 2.8 percent for the subject population.Navistar has released two Technical Service Information (TSI) bulletins and two iKNow (information) articles pertaining to the high pressure hose in the I-6 engine.Following discussions with ODI concerning the warranty rate, consumer complaints and interviews, and the risk to students resulting from a stranded bus, Navistar decided to submit recall notices (12V-473 and 12V-476) on the subject vehicles to address the high pressure hose failures.Navistar's recall actions address the issues raised by this investigation and as a result this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10450319 and 10455151.
Engine And Engine Cooling
On April 16, 2012 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE12-011) to assess the risks associated with rupture of the high pressure oil line to the fuel injectors causing an engine stall in model year (MY) 2008 International CE school buses equipped with International I-6 diesel engines.On August 31, 2012 ODI received Navistar's response to its August 2, 2012, information request letter and identified 3 consumer complaints with one involving an oil line rupture that resulted in an engine compartment fire.ODI also identified 470 warranty claims related to the defect.This calculates to a warranty rate of 2.8 percent for the subject population.Navistar has released two Technical Service Information (TSI) bulletins and two iKNow (information) articles pertaining to the high pressure hose in the I-6 engine.Following discussions with ODI concerning the warranty rate, consumer complaints and interviews, and the risk to students resulting from a stranded bus, Navistar decided to submit recall notices (12V-473 and 12V-476) on the subject vehicles to address the high pressure hose failures.Navistar's recall actions address the issues raised by this investigation and as a result this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10450319 and 10455151.
2008 International Ce Problems, Complaints & Recalls | Skip That Year
Illustration