Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Air. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reports
5,825 miles · Jan 23, 2007
Service Brakes, Air
OUR AGENCY PURCHASED FOUR 2005, 7400 INTERNATIONAL TRUCKS TO BE USED AS FIRE APPARATUS. SINCE THE FIRST TRUCK WENT INTO SERVICE IN APRIL OF 2005 WE HAVE HAD A SERIES OF AIR COMPRESSOR FAILURES. THE HEAD GASKETS LEAK COOLANT INTO THE VEHICLE'S AIR SYSTEM. THIS REQUIRES REPLACEMENT OF THE AIR COMPRESSOR ALONG WITH THE AIR DRYER C…
Read full complaint
OUR AGENCY PURCHASED FOUR 2005, 7400 INTERNATIONAL TRUCKS TO BE USED AS FIRE APPARATUS. SINCE THE FIRST TRUCK WENT INTO SERVICE IN APRIL OF 2005 WE HAVE HAD A SERIES OF AIR COMPRESSOR FAILURES. THE HEAD GASKETS LEAK COOLANT INTO THE VEHICLE'S AIR SYSTEM. THIS REQUIRES REPLACEMENT OF THE AIR COMPRESSOR ALONG WITH THE AIR DRYER CARTRIDGE. THE FIRST VEHICLE IS GOING ON IT'S FIFTH UNIT. ANOTHER LEAKED COOLANT INTO THE MOTOR OIL AND SUBSEQUENTLY HAD TO HAVE THE ENGINE REPLACED. THE OTHER TWO VEHICLES HAVE HAD THE AIR COMPRESSOR HEAD GASKETS REPLACED TO TRY AND PREVENT A SIMILAR OCCURRENCE. THE AIR COMPRESSORS ARE MANUFACTURED BY BENDIX. *NM
ON CERTAIN TRUCKS, THE REAR-REAR AXLE BRAKE SLACK ADJUSTERS MAY CONTACT THE REAR AXLE HOUSING PREVENTING THE BRAKES FROM BEING FULLY APPLIED POSSIBLY CAUSING EXTENDED STOPPING DISTANCES.
Consequence & remedy
Consequence: EXTENDED STOPPING DISTANCES CAN CONTRIBUTE TO A VEHICLE CRASH THAT MAY RESULT IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
Remedy: DEALERS WILL REPLACE ALL REAR-REAR AXLE BRAKE SPIDERS WITH A SPIDER THAT HAS A DIFFERENT BRAKE GROUP CLOCKING ANGLE FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2007. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.
ON CERTAIN VEHICLES EQUIPPED WITH AIR OPERATED FIFTH WHEEL SLIDES AND AN MSVA 7-PACK ACCESSORY CONTROLLER, THE 7-PACK CAN ALLOW WATER TO CONTAMINATE ITS CIRCUIT BOARD. THIS COULD RESULT IN INADVERTENT OPERATION OF THE FIFTH WHEEL SLIDE CONTROL.
Consequence & remedy
Consequence: IF THE SLIDE CONTROL ACTUATES WHILE THE VEHICLE IS IN MOTION, MOMENTUM FROM THE TRAILER CAN CAUSE THE FIFTH WHEEL TO SLIDE WITHOUT INPUT FROM THE DRIVER, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL RELOCATE THE MSVA 7-PACK TO A LESS WATER INTENSIVE ENVIRONMENT. A NEW MSVA 7-PACK BASE, THAT HAS BEEN IMPROVED TO PREVENT WATER INTRUSION, AND ALL AIR ACCESSORY SOLENOIDS WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.
ON CERTAIN TRUCKS, THE BOLTS THAT MOUNT THE FRONT OF THE CAB TO THE MOUNTING BRACKETS WERE NOT PROPERLY TORQUED AT THE MANUFACTURING PLANT.
Consequence & remedy
Consequence: THESE BOLTS CAN LOOSEN DURING NORMAL VEHICLE USE AND FALL OUT. THIS MAY LEAD TO THE CAB SEPARATING FROM THE VEHICLE'S CHASSIS DURING A VEHICLE CRASH THAT MAY RESULT IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
Remedy: AS AN INTERIM ACTION, DEALERS WILL PROPERLY TIGHTEN THE EXISTING CAB MOUNTING BOLTS AND REPLACE ANY MISSING BOLTS. AS SOON AS PARTS ARE AVAILABLE, DEALERS WILL REPLACE ALL SIXTEEN BOLTS AND TIGHTEN THEM PROPERLY. AN INTERIM LETTER WAS SENT TO OWNERS ON FEBRUARY 11, 2005. ANOTHER LETTER WAS SENT TO OWNERS ON APRIL 8, 2005, AS SOON AS PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 International 7400 Problems, Complaints & Recalls | Skip That Year
Illustration