2007 INTERNATIONAL 4300, UNIT 1 AND UNIT 2 WERE EASTBOUND ON THE OHIO TURNPIKE. UNIT 2 STATED ICE FROM UNIT 1 TRAILER FLEW OFF HIS VEHICLE STRIKING UNIT 2 WINDSHIELD. UNITS MOVED FURTHER UP THE ROAD FROM AREA OF IMPACT. NO ICE WAS FOUND ON THE ROADWAY. OFFICER STATED, HE CHECKED UNIT 1 FOR ANY SNOW/ICE ON THE TRAILER. HE S…
Read full complaint
2007 INTERNATIONAL 4300, UNIT 1 AND UNIT 2 WERE EASTBOUND ON THE OHIO TURNPIKE. UNIT 2 STATED ICE FROM UNIT 1 TRAILER FLEW OFF HIS VEHICLE STRIKING UNIT 2 WINDSHIELD. UNITS MOVED FURTHER UP THE ROAD FROM AREA OF IMPACT. NO ICE WAS FOUND ON THE ROADWAY. OFFICER STATED, HE CHECKED UNIT 1 FOR ANY SNOW/ICE ON THE TRAILER. HE SAW NONE FROM THE INSPECTION FROM GROUND LEVEL. *BF (OHIO TRAFFIC CRASH REPORT # 10-0098-91) UPDATED 03/29/11 *BF
NAVISTAR HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2010 AND 2011 IC CE, HC, AND BE COMMERCIAL BUSES AND INTERNATIONAL 1300, 3200, 3300, 4100, 4200, 4300, 4400, AND MXT TRUCKS MANUFACTURED FROM NOVEMBER 19, 2003 THROUGH FEBRUARY 9, 2010. THE PARKING BRAKE MAY RELEASE IF THE BRAKE SYSTEM ELECTRONIC CONTROL UNIT (ECU) SOFTWARE MISINTERPRETS INPUT SIGNALS GENERATED FROM CYCLING THE IGNITION SWITCH MORE THAN ONCE AT A SPECIFIC FREQUENCY.
Consequence & remedy
Consequence: RELEASE OF THE PARKING BRAKE MAY CAUSE SUDDEN, UNEXPECTED SHIFT IN VEHICLE POSITION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL DAMAGE, OR DEATH.
Remedy: NAVISTAR WILL NOTIFY OWNERS AND WILL REPAIR THE VEHICLES BY REPROGRAMMING THE VEHICLE'S BRAKE SYSTEM ECU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 14, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-260-461-1890.
E-N-G MOBILE SYSTEM IS RECALLING CERTAIN MODEL YEAR 2008 CHEVROLET W5500, MODEL YEAR 2007-2009 DODGE 3500, MODEL YEAR 2009 MIGHTY MOVER, MODEL YEAR 2006-2009 FORD E-250, E-350 AND E-450, MODEL YEAR 2008-2009 GMC W4500, MODEL YEAR 2007 INTERNATIONAL 4300, MODEL YEAR 2009 TOYOTA LAND CRUISER VEHICLES EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.
Consequence & remedy
Consequence: THIS DEFECT COULD RESULT IN A FIRE.
Remedy: E-N-G MOBILE SYSTEM WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2009. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR E-N-G MOBILE SYSTEM AT 1-925-798-4060.
INTERNATIONAL IS RECALLING 34,993 MY 2006-2008 SCHOOL AND TRANSIT BUSES AND HEAVY DUTY TRUCKS/TRACTORS MANUFACTURED BETWEEN JUNE 1, 2006 AND JUNE 28, 2007, EQUIPPED WITH INTERNATIONAL DT466 OR DT570 ENGINES. THE BASE PLATE OF THE ENGINE OIL COOLER MAY CRACK ALLOWING PRESSURIZED OIL TO LEAK INTO THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: THIS CONDITION MAY CAUSE EITHER ENGINE SHUT DOWN WITHOUT WARNING, OR IN EXTREME CASES, POSSIBLE ENGINE FIRE WHICH CAN LEAD TO PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Remedy: INTERNATIONAL WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 21, 2008. OWNERS MAY CONTACT INTERNATIONAL AT 800-448-7825.
ON CERTAIN TRUCKS, ONE OR BOTH REAR AXLE HOUSINGS MAY CONTAIN THINNER MATERIAL THAN WHAT IS NECESSARY FOR NORMAL VEHICLE OPERATION. OVER TIME, THIS THINNER MATERIAL MAY RESULT IN A FATIGUE FAILURE OF THE REAR AXLE HOUSING, POSSIBLY IN THE LOCATION OF THE BRAKE FLANGE.
Consequence & remedy
Consequence: A CRACK IN THE BRAKE FLANGE LOCATION OF THE REAR AXLE HOUSING MAY RESULT IN A WHEEL END LOCKUP OR WHEEL SEPARATION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S REAR AXLES AND, IF NECESSARY, REPLACE THE AXLE HOUSINGS. THE RECALL BEGAN ON MAY 18, 2007. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7815.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08055 · Front Leaf Spring Breakage
Opened Sep 17, 2008 · Closed Jan 13, 2009
Status: closed (inferred from source dates) · Suspension:front:springs:leaf Spring Assembly
ODI OPENED THIS INVESTIGATION IN SEPTEMBER 2008, BASED ON 18 WARRANTY CLAIMS OF FRACTURED FRONT LEAF SPRINGS. AT 2008 YEAR-END, INTERNATIONAL TRUCK AND ENGINE (ITE) HAS ADVISED ODI THAT AN ADDITIONAL 11 WARRANTY CLAIMS HAVE BEEN REPORTED TO DATE (TOTAL 29).ODI 'S INVESTIGATION HAS DETERMINED THAT A MANUFACTURING FLAW EXISTS IN AN INDETERMINATE NUMBER OF THE 1600 FRONT LEAF SPRINGS MANUFACTURED BETWEEN JULY AND AUGUST, 2007 BY ITS SUPPLIER, HENDRICKSON, USA, LLC.INVESTIGATION HAS DETERMINED THAT FRACTURED SPRINGS HAVE BEEN DETECTED SOLELY BY VISUAL OR AUDIBLE INDICATIONS SUCH AS VEHICLE SAG OR TILT AND/OR FRONT END VEHICLE NOISE.EVIDENCE INDICATES THAT THERE IS NO SIGNIFICANT EFFECT ON VEHICLE CONTROL IF AND WHEN THE LOWER LEAF OF THE TWO LEAF FRONT SPRING ASSEMBLY FRACTURES IN THE SUSPECT VEHICLES SINCE THE INTACT UPPER LEAF SPRING CONTINUES TO PROVIDE ADEQUATE LOAD BEARING SUPPORT AND FRONT AXLE ALIGNMENT FOR THE VEHICLE. THERE ARE NO REPORTS OF LOSS OF CONTROL AND NO CRASHES.THEREFORE, THIS INVESTIGATION IS CLOSED.A SAFETY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES IS NOT CURRENTLY WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THE VEHICLES IF WARRANTED BY THE CIRCUMSTANCES. ODI WILL CONTINUE TO MONITOR FIELD REPORTS AND TAKE APPROPRIATE ACTION IF INDICATED.
2007 International 4300 Problems, Complaints & Recalls | Skip That Year
Illustration