Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reports
Mileage unknown · Feb 9, 2006
Engine And Engine CoolingPower Train
WE HAVE A SCHOOL BUS THAT HAS HAD THE TRANSMISSION REPLACED FOUR TIMES SO FAR AND HAS HAD 8 NEW INJECTORS PUT IN IT AND IT STILL DOESN'T RUN PROPERLY. THE SAFETY ISSUE IS IT WILL NOT MOVE WHEN COMING FROM A STOP AND WHEN IT FINALLY MOVES, IT IS SLOW. DOES NOT BUILD UP SPEED QUICKLY. IT IS BACK IN THE SHOP AND THEY CANNOT SEEM…
Read full complaint
WE HAVE A SCHOOL BUS THAT HAS HAD THE TRANSMISSION REPLACED FOUR TIMES SO FAR AND HAS HAD 8 NEW INJECTORS PUT IN IT AND IT STILL DOESN'T RUN PROPERLY. THE SAFETY ISSUE IS IT WILL NOT MOVE WHEN COMING FROM A STOP AND WHEN IT FINALLY MOVES, IT IS SLOW. DOES NOT BUILD UP SPEED QUICKLY. IT IS BACK IN THE SHOP AND THEY CANNOT SEEM TO FIGURE IT OUT. THE FIRST TRANSMISSION REPLACEMENT WAS PUT IN THE FIRST SIX MONTHS OF OWNING THE VEHICLE, ONE IN OCT. 2003, ONE IN OCT. 2004 AND ONE IN JUNE 2005. THE VEHICLE HAS 102,000 MILES ON IT AND REALLY SHOULD NOT HAVE HAD TO REPLACE 8 INJECTORS WITHIN THAT AMOUNT OF MILES. THE BUS HAS BEEN DOWN MORE THAN IT HAS BEEN ON THE ROAD THIS SCHOOL YEAR.*JB
ON CERTAIN SCHOOL AND TRANSIT BUSES BUILT WITH BOSCH ZERO OFFSET PIN SLIDE (ZOPS) HYDRAULIC DISC BRAKES, THE ZOPS HYDRAULIC DISC BRAKES MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION, WHICH CAN RESULT IN EXCESSIVE OR ABNORMAL HEAT GENERATION AT ONE OR MORE OF THE BRAKES.
Consequence & remedy
Consequence: THE COMBINATION OF THE FOLLOWING FACTORS MAY COLLECTIVELY RESULT IN AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY: POTENTIAL FIRE AT A WHEEL END, HIGH INCIDENT RATES OF STUCK CALIPERS, AND EVACUATION AND CONTAINMENT CONCERNS RELATING TO MULTIPLE PASSENGERS.
Remedy: INTERNATIONAL WILL NOTIFY ITS CUSTOMERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN OCTOBER 29, 2004.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA02034 · Overheating Front And Rear Brakes
Opened Dec 3, 2002 · Closed Feb 10, 2004
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION FOCUSED ON INTERNATIONAL MEDIUM DUTY TRUCKSAND SCHOOL BUS CHASSIS WEIGHING UP TO 33,000 POUNDS, EQUIPPED WITH HYDRAULIC BRAKES AND BUILT WITH THE BOSCH ZERO OFFSET PIN SLIDE (ZOPS)BRAKE SYSTEM CALIPERS.INTERNATIONAL USED THE ZOPS CALIPERS FROM APRIL 1997 THROUGH JUNE 2002.ODI WAS CONCERNED ABOUT REPORTS OF THE BRAKE CALIPERS STICKING IN THE APPLIED POSITION, RESULTING IN EXCESSIVE HEAT.AS THE INVESTIGATION PROGRESSED, ODI BECAME AWARE OF WHEEL END FIRES, SOME OF WHICH OCCURRED ON SCHOOL BUSES.DURING THE INVESTIGATION ODI OBTAINED WARRANTY DATA WHICH WAS SORTED AND ANALYZED BY VRTC TEST ENGINEERS AND ODI TO GAIN AN UNDERSTANDING OF THE MAGNITUDE OF THE PROBLEM.AFTER A THOROUGH WARRANTY DATA ANALYSIS, RELATED TESTING AND DOCUMENT REVIEWS, ODI MET WITH INTERNATIONAL, SHARED THE DATA ANALYSIS AND SHORTLY AFTERWARDS, INTERNATIONAL AGREED TO A SAFETY RECALL.FURTHER DETAILS ARE INCLUDED ON PAGES 2 - 4.
1998 International 3600 Problems, Complaints & Recalls | Skip That Year
Illustration