Navistar, Inc. is recalling certain model year 2007-2015 IC BE and CE school buses, 2013-2015 IC AE school buses, 2007-2011 IC FE school buses, and 2007-2014 IC RE school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence & remedy
Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Remedy: Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on February 19, 2016. Owners may contact Navistar customer service at 1-800-448-7825. Note: These buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.
Navistar, Inc. (Navistar) is recalling certain model year 2013-2015 IC AE, 2007-2015 IC BE, CE, 2007-2011 IC FE, and 2007-2014 IC RE school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.
Consequence & remedy
Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: Navistar will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on January 29, 2015. Owners may contact Navistar customer service at 1-331-332-1590 or Ricon customer service at 1-800-322-2884. Navistar's number for this recall is 14518.
NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2008 IC BE, RE, AND CE SCHOOL BUSES MANUFACTURED FROM DECEMBER 4, 2001 THROUGH DECEMBER 14, 2009 EQUIPPED WITH INTERNATIONAL VT365 ENGINES HAVING ENGINE CALIBRATION PAN2PVR0, PAN2PVR1, OR PAN2PWR. THE ENGINE NORMALLY RESPONDS TO A FAILED OPEN ACCELERATOR POSITION SENSOR CIRCUIT FAULT BY RETURNING THE ENGINE TO LOW IDLE SPEED OF 800 RPM AND DISABLING THE DRIVER'S ABILITY TO INCREASE THE ENGINE SPEED. HOWEVER IF THE OPEN CIRCUIT CORRECTS ITSELF WITHIN 30 SECONDS OF INITIATION, ENGINE SPEED COULD SUDDENLY INCREASE TO A HIGH IDLE SPEED OF 1200 RPM.
Consequence & remedy
Consequence: THIS INCREASE TO HIGH IDLE SPEED MAY OCCUR WITHOUT WARNING CAUSING A SUDDEN AND UNEXPECTED SHIFT IN VEHICLE POSITION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 1, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825..
NAVISTAR IS RECALLING 24,975 MY 2003 THROUGH 2008 IC BE, CE, HC, AND RE SCHOOL AND COMMERCIAL BUSES AND 2002 THROUGH 2008 INTERNATIONAL 3200 AND 3300 MODEL BUSES MANUFACTURED BETWEEN SEPTEMBER 21, 2001 THROUGH DECEMBER 14, 2007, EQUIPPED WITH INTERNATIONAL VT365 ENGINES. THESE VEHICLES MAY EXHIBIT ENGINE HARD START, NO START, OR STALL CONDITIONS DUE TO POSSIBLY DAMAGED TERMINALS IN THE FUSE HOLDER CONNECTOR OF THE INJECTOR DRIVE MODULE (IDM) CLEAN BATTERY POWER CIRCUITS. THE TERMINALS MAY HAVE BEEN DAMAGED DURING ELECTRICAL CONTINUITY TESTING IN THE MANUFACTURING PROCESS.
Consequence & remedy
Consequence: THESE CONDITIONS COULD RESULT IN A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY.
Remedy: NAVISTAR WILL NOTIFY OWNERS AND REPLACE THE IDM FUSE HOLDER FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 3, 2008. OWNERS CAN CONTACT NAVISTAR TOLL-FREE AT 1-800-448-7825.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08034 · School Bus Stalling
Opened May 9, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Electrical System:wiring:fuses And Circuit Breakers
THIS PE WAS OPENED AFTER ODI BECAME AWARE OF 7 EVENTS ON SCHOOL BUSES WHERE THE FUSE FOR THE ECMOVERHEATED AND BURNED THE FUSE HOLDER AND/OR FUSE HOLDER TERMINALS.ONCE OVERHEATING OF THE FUSE HOLDER OCCURS, THE FUSE BLADES WOULD NO LONGERBE SECURED IN THE PLASTIC HOLDER, THUS INTERRUPTING THE ELECTRICAL FLOW.THE COMPLAINTS CENTERED AROUNDEITHER A NO-START, HARD START, ERRATIC ENGINE PERFORMANCE OR ENGINE STALLING. ODI WAS ALSO AWARE OF REPORTED BATTERY BOX FIRES. THEPE WAS OPENED TO EXAMINE THE SAFETY SIGNIFICANCE AND GAIN A TECHNICAL UNDERSTANDING OF THIS PROBLEM.AFTER DISCUSSIONS WITH ODI AND FURTHER REVIEW OF FIELD INCIDENTS, IC DECIDED THE PROPER WAY TO HANDLE THIS ISSUE WAS TO CONDUCT A SAFETY RECALL DURING WHICH THEY WILLREPLACE THE FUSE HOLDERS AND THE POWER ELECTRICAL CONNECTOR ON THE AFFECTED VEHICLES.THIS RECALL ACTION RESOLVES THE ISSUES RAISED BY THIS INVESTIGATION. THEREFORE, THIS INVESTIGATION IS CLOSED.
2008 Ic Bus Re Problems, Complaints & Recalls | Skip That Year
Illustration