IllustrationWhen locking all doors and then unlocking doors the passenger door will not open from the outside. You can open it from the inside however in an accident or fire, no one could open this door. Very dangerous and I have seen numerous complaints about the door locking/latch issues
2016 Hyundai Tucson
Owner reports · Recalls · Investigations
More warning signs than most Tucson years
Owner complaints for the 2016 Hyundai Tucson are substantially higher than the model-year median of 180.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tucson years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
3990–25K
12925–50K
16050–75K
8375–100K
56100–150K
5150K+
832 reports with mileage · 785 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 516 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 423 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 227 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports24 fire reports6 injury reports
What owners actually said
1,617 reportsThe contact owns a 2016 Hyundai Tucson. The contact stated that on three separate occasions, the window regulator for the front driver’s, front passenger’s, and rear driver’s side windows failed to operate as designed. The contact also stated that once the window regulators failed, the window would slide down independently while…
Read full complaint
The contact owns a 2016 Hyundai Tucson. The contact stated that on three separate occasions, the window regulator for the front driver’s, front passenger’s, and rear driver’s side windows failed to operate as designed. The contact also stated that once the window regulators failed, the window would slide down independently while driving. The vehicle was taken to the dealer after each failure and the window regulators were replaced out of pocket. The manufacturer was notified of the failure, but no assistance was provided. The vehicle was also out of warranty. The failure mileage was approximately 28,000. The contact has had all 4 window motors replaced as well as purchased an extended warranty for the vehicle. The contact has notified by Hyundai that other Tucson owners were experiencing the same issues.
Window regulators failing on all windows. Drivers side is stuck open and will not close. All others are stuck closed and will not go down.
The contact owns a 2016 Hyundai Tucson. The contact stated while driving 70 MPH, the vehicle decelerated without warning. The contact stated that after several seconds the vehicle continued to operate normally. The vehicle was taken to the dealer to be diagnosed; however, the mechanic was unable to determine the cause of the fai…
Read full complaint
The contact owns a 2016 Hyundai Tucson. The contact stated while driving 70 MPH, the vehicle decelerated without warning. The contact stated that after several seconds the vehicle continued to operate normally. The vehicle was taken to the dealer to be diagnosed; however, the mechanic was unable to determine the cause of the failure. The failure persisted. The manufacturer was not contacted. The failure mileage was 2,400.
The contact owns a 2016 Hyundai Tucson. The contact stated while driving at 30 MPH, the vehicle began to stall and he saw smoke coming out from underneath the hood of the vehicle. Several unknown warning lights were illuminated. The contact veered to the side of the road and quickly exited the vehicle. The contact waited severa…
Read full complaint
The contact owns a 2016 Hyundai Tucson. The contact stated while driving at 30 MPH, the vehicle began to stall and he saw smoke coming out from underneath the hood of the vehicle. Several unknown warning lights were illuminated. The contact veered to the side of the road and quickly exited the vehicle. The contact waited several minutes. The contact stated that upon opening the hood of the vehicle, he saw flames. The contact was able to extinguish the fire by shutting the hood closed. The contact stated that in the process of exiting the vehicle, he bumped his knee and twisted his ankle and received care from his caregiver. The vehicle was towed to the dealer where it was diagnosed that the engine needed to be replaced. The engine was replaced under an unknown recall. However, the contact stated that after the repair, the vehicle was experiencing rough starts and the engine was misfiring while driving. The vehicle was taken to a second dealer, Ron Tonkin Hyundai (675 NE Burnside Rd, Gresham, OR 97030), where it was diagnosed that the cylinder was misfiring. The dealer replaced the fuel injector, the spark plugs, and the cylinder head, and completed an oil change. However, the engine was knocking upon starting the vehicle. The dealer informed the contact that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and advised the contact that he would need to pay an Engine Control Unit (ECU) repair fee. The failure mileage was approximately 90,000.
Driver-side rear door fails to open from the inside or the outside. Currently, the passenger seated on that side of the vehicle has to enter and exit the vehicle using the door on the opposite side, which can easily be a safety issue. Thankfully, we have not been in an emergency incident or car accident where someone has had to …
Read full complaint
Driver-side rear door fails to open from the inside or the outside. Currently, the passenger seated on that side of the vehicle has to enter and exit the vehicle using the door on the opposite side, which can easily be a safety issue. Thankfully, we have not been in an emergency incident or car accident where someone has had to use that door to get out of the car in a hurry. The failure to unlock the door and open seems to stem from an actuator mechanism that is faulty. (The same issue/complaint has been mentioned by other owners, including failure of more than one door latch, e.g. https://www.hyundai-forums.com/threads/help-16-tucson-limited-intermittent-door-unlock-fob-issue.690557/#post-6162832; https://www.carproblemzoo.com/hyundai/tucson/door-latch-problems.php, ) I contacted the local Hyundai dealer about this issue and was only able to get an appointment two months out (which will be tomorrow)! I will have more details regarding the repair associated with this issue after my appointment. But it seems like this should be a safety related recall given the potential danger of being trapped in a vehicle in the event of an emergency or an accident.
The window regulator spool has melted on all 4 windows. This vehicle has less than 65000 miles and this should not be an issue. This is a safety issue. We have read hundreds of comments online of the same issue.
On Oct. 14, 2022 I had to take my car in to repair/replace front passenger side window regulator. The window no longer would go up and down. $807.51. Yesterday, Oct. 20 my driver's side front window failed. Another $807 repair. I am a senior citizen (woman) on a fixed income also experiencing recent Ian hurricane damage an…
Read full complaint
On Oct. 14, 2022 I had to take my car in to repair/replace front passenger side window regulator. The window no longer would go up and down. $807.51. Yesterday, Oct. 20 my driver's side front window failed. Another $807 repair. I am a senior citizen (woman) on a fixed income also experiencing recent Ian hurricane damage and repairs. Am I to expect the rest of the windows to fail? Do I have some recourse with Hyundai?
Passenger Front door will not open from exterior upon unlocking. Can only open door from inside vehicle by reaching over and releasing inside lever.
Car suddenly lost significant acceleration power in normal conditions. According to Hyundai dealer inspection, the rod bearing failed and pressure in the engine was lost. Safety risk was causing an accident because of loss of power. No accident occurred due to being so close to the right shoulder. This would have been far more d…
Read full complaint
Car suddenly lost significant acceleration power in normal conditions. According to Hyundai dealer inspection, the rod bearing failed and pressure in the engine was lost. Safety risk was causing an accident because of loss of power. No accident occurred due to being so close to the right shoulder. This would have been far more dangerous if this was on a 6-7 lane highway causing major accidents due to being an obstacle to normal traffic flow. No warning lights or lamps were displayed before incident.
Official recalls
520V543000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Sep 4, 2020
Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles. The Anti-lock Brake Hydraulic Electronic Control Unit (HECU) could corrode internally and cause an electrical short, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire can increase the risk of injury or crash.
Remedy: Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall began November 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 195.
16V842000 · Electrical System:wiring; Trailer Hitches
Nov 21, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Additional source detail variants (2)
Trailer Hitches
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Electrical System:wiring
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
16V628000 · Electrical System:software; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Aug 30, 2016
Hyundai Motor Company (Hyundai) is recalling certain model year 2016 Tucson vehicles manufactured May 20, 2015 through May 31, 2016 and equipped with a 7-speed EcoShift Dual Clutch Transmission. Certain driving conditions and high temperatures may cause the vehicle to not move if the accelerator pedal is pressed and released repeatedly.
Consequence & remedy
Consequence: Inability to move the vehicle while in traffic may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will update the Transmission Control Module software, free of charge. The recall is expected to begin on October 28, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 149.
Additional source detail variants (2)
Electrical System:software
Hyundai Motor Company (Hyundai) is recalling certain model year 2016 Tucson vehicles manufactured May 20, 2015 through May 31, 2016 and equipped with a 7-speed EcoShift Dual Clutch Transmission. Certain driving conditions and high temperatures may cause the vehicle to not move if the accelerator pedal is pressed and released repeatedly.
Consequence: Inability to move the vehicle while in traffic may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will update the Transmission Control Module software, free of charge. The recall is expected to begin on October 28, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 149.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Hyundai Motor Company (Hyundai) is recalling certain model year 2016 Tucson vehicles manufactured May 20, 2015 through May 31, 2016 and equipped with a 7-speed EcoShift Dual Clutch Transmission. Certain driving conditions and high temperatures may cause the vehicle to not move if the accelerator pedal is pressed and released repeatedly.
Consequence: Inability to move the vehicle while in traffic may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will update the Transmission Control Module software, free of charge. The recall is expected to begin on October 28, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 149.
16V348000 · Latches/locks/linkages:hood:latch
May 24, 2016
Hyundai Motor Company (Hyundai) is recalling certain model year 2016 Tucson vehicles manufactured May 19, 2015 to March 14, 2016. In the affected vehicles, if the primary hood latch has been released, and the vehicle is driven, the secondary hood latch may not hold adequately secure the hood to prevent it from opening while the vehicle is in motion.
Consequence & remedy
Consequence: If the primary hood latch is inadvertently released and the secondary latch cannot secure the hood, the hood may unexpectedly open while driving, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary hood latch, free of charge. The recall began on June 30, 2016. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 145.
16V147000 · Exterior Lighting:tail Lights
Mar 10, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016 Hyundai Tucson vehicles manufactured May 26, 2015 to January 15, 2016 and equipped with an accessory trailer hitch harness either included with the accessory trailer hitch or sold as a service part. In the affected vehicles, when the vehicle's engine is running and the brake lights are illuminated, if the turn signal is activated, the trailer turn signal lights will either turn off or remain continuously illuminated (not flash). As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard Number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Failure to illuminate the trailer's turn signal lights would prevent the communication of the driver's intent, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will update the tow hitch harness, free of charge. The recall began on May 2, 2016. Owners may contact Hyundai customer service at 1-855-371-9640. Hyundai's number for this recall is 142.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.