NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
423 reportsClear category filterMileage unknown · Sep 9, 2026
Electrical SystemEngine
The vehicle unexpectedly entered 'Limp Mode' due to engine tracking code P1326. The vehicle severely restricts engine power and RPMs while driving on public roads, preventing normal acceleration. This creates a severe safety hazard as the vehicle cannot safely merge into oncoming traffic, accelerate away from intersections, or m…
Read full complaint
The vehicle unexpectedly entered 'Limp Mode' due to engine tracking code P1326. The vehicle severely restricts engine power and RPMs while driving on public roads, preventing normal acceleration. This creates a severe safety hazard as the vehicle cannot safely merge into oncoming traffic, accelerate away from intersections, or maintain basic road speeds, putting me at a high risk of being rear-ended.The fault is under Hyundai Theta II Txxm. I have been given the runaround by both hyunday corporate and the local dealer.
NHTSA ODI #11763199
Mileage unknown · Jul 28, 2026
EnginePower Train
While stopped at a traffic light, the engine began producing a loud metallic clattering and clanking sound, consistent with connecting rod bearing failure (rod knock). There was no prior warning light or indication of this specific failure. When the light changed, the vehicle would not accelerate normally, leaving me stalled in …
Read full complaint
While stopped at a traffic light, the engine began producing a loud metallic clattering and clanking sound, consistent with connecting rod bearing failure (rod knock). There was no prior warning light or indication of this specific failure. When the light changed, the vehicle would not accelerate normally, leaving me stalled in a lane of moving traffic. I was forced to make an emergency turn to get the vehicle out of the way of oncoming and crossing traffic. The engine would not hold an idle afterward and has not run since. The vehicle was towed to a Hyundai dealership, where a service department employee stated by phone that this 1.6L turbocharged engine family has a known, documented history of severe factory defects affecting the connecting rod bearings.
NHTSA ODI #11753197
Mileage unknown · Jul 12, 2026
Engine
The engine is failing at 128,000 miles. The car is burning so much oil that it is impossible to drive more than 500 miles without the oil running dry. The problem has been inspected by the Hyundai dealership nearest me. The vehicle notified me of the oil issue by illuminating the oil light. The issue started after the turbo fail…
Read full complaint
The engine is failing at 128,000 miles. The car is burning so much oil that it is impossible to drive more than 500 miles without the oil running dry. The problem has been inspected by the Hyundai dealership nearest me. The vehicle notified me of the oil issue by illuminating the oil light. The issue started after the turbo failed at 127,000 miles. The turbo was replaced at a cost $3,500 and immediately afterwards the vehicle which previously did not burn oil now does. It doesn't just burn oil it consumes it like a black hole.
NHTSA ODI #11749884
Mileage unknown · Jul 1, 2026
EnginePower Train
While driving, the vehicle experienced a sudden and severe loss of motive power accompanied by a loud, catastrophic internal knocking sound from the engine compartment. The vehicle was towed to an authorized Hyundai dealership (Piazza Hyundai of Limerick), where a certified diagnostic technician confirmed a severe internal conne…
Read full complaint
While driving, the vehicle experienced a sudden and severe loss of motive power accompanied by a loud, catastrophic internal knocking sound from the engine compartment. The vehicle was towed to an authorized Hyundai dealership (Piazza Hyundai of Limerick), where a certified diagnostic technician confirmed a severe internal connecting rod bearing failure (rod knock). This sudden engine failure creates a significant highway safety hazard due to the immediate loss of acceleration and power steering/brake assistance if the engine completely seizes while operational. Hyundai has issued widespread safety recalls and a 15-year/150,000-mile extended warranty (TXXM) for this exact failure mode in other engine displacements (such as the 2.0L Nu GDI), yet they have excluded the 1.6L Turbo engine from identical coverage despite it suffering from the exact same manufacturing defect and presenting the same public safety risk.
NHTSA ODI #11747780
119,479 miles · Jun 26, 2026
Engine
The contact owns a 2016 Hyundai Tucson. While the contact’s daughter was driving approximately 55 MPH, the vehicle started to lose motive power. The vehicle failed to restart immediately. The vehicle was started after a while; however, the check engine warning light was illuminated. The vehicle was taken to a Goodyear Service Ce…
Read full complaint
The contact owns a 2016 Hyundai Tucson. While the contact’s daughter was driving approximately 55 MPH, the vehicle started to lose motive power. The vehicle failed to restart immediately. The vehicle was started after a while; however, the check engine warning light was illuminated. The vehicle was taken to a Goodyear Service Center to be diagnosed. The contact was informed that the engine had seized and needed to be repaired. The dealer was contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,479.
NHTSA ODI #11746702
Mileage unknown · Jun 12, 2026
EnginePower TrainVehicle Speed Control
The vehicle severely shudders, jerks, and hesitates from a stop and while making a turn, during both acceleration and deceleration, making it entirely unsafe to drive. The vehicle has been completely un-driveable for the past 6 days. The check engine light illuminated, and on 4/9/26, the dealer documented a failed transmission j…
Read full complaint
The vehicle severely shudders, jerks, and hesitates from a stop and while making a turn, during both acceleration and deceleration, making it entirely unsafe to drive. The vehicle has been completely un-driveable for the past 6 days. The check engine light illuminated, and on 4/9/26, the dealer documented a failed transmission judder test and kept the car, issuing a loaner. A temporary software patch failed after two weeks. Upon return, the dealer reported they were unable to recreate the problem, recommended returning when the vehicle demonstrates the problem more frequently, and refused to mechanically repair the dual-clutch transmission under my active original-owner 100,000-mile powertrain warranty, basically instructing me to continue to drive a seriously un-safe vehicle. Most recently, a yellow dashboard warning light illuminated, and the vehicle entered a dangerous 'limp mode,' severely restricting power and struggling to move before the light cleared after cooling down. The vehicle is completely un-driveable and parked.
NHTSA ODI #11743723
Mileage unknown · Jun 4, 2026
Engine
Oil consumption engine ticking hesitate to change gears poor acceleration.
NHTSA ODI #11742112
125,000 miles · Jun 3, 2026
Engine
The contact owns a 2016 Hyundai Tucson. The contact stated while driving 50 MPH, the vehicle failed to accelerate as intended and stalled. There was no warning light illuminated. The contact was able to pull over to the side of the road, where the contact restarted the vehicle. The contact drove to his workplace and parted the v…
Read full complaint
The contact owns a 2016 Hyundai Tucson. The contact stated while driving 50 MPH, the vehicle failed to accelerate as intended and stalled. There was no warning light illuminated. The contact was able to pull over to the side of the road, where the contact restarted the vehicle. The contact drove to his workplace and parted the vehicle. However, the vehicle later failed to start. The vehicle was towed to the dealer it was purchased from, and the contact was informed that the engine had failed. The vehicle was not repaired. The vehicle was then towed to Affordable Towing and Repair, where it was diagnosed that the engine had failed and needed to be replaced. The manufacturer was not contacted. The vehicle was towed to 125,000.
NHTSA ODI #11741794
Mileage unknown · May 13, 2026
EngineUnknown Or OtherVehicle Speed Control
Oil drains very fast even with regular oil changes and maintenance. The vehicle began shaking and then completely stopped with very little warning. Check engine light flashed for under 60 seconds then vehicle would not move forward on the highway creating a major safety hazard. Engine smelled hot and like burning rubber.
NHTSA ODI #11737712
Mileage unknown · May 6, 2026
Engine
The contact owns a 2016 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated and there was an abnormal sound coming from the engine compartment. The vehicle was taken to a dealer where it was diagnosed that the vehicle needed an oil consumption cleaning. Th…
Read full complaint
The contact owns a 2016 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated and there was an abnormal sound coming from the engine compartment. The vehicle was taken to a dealer where it was diagnosed that the vehicle needed an oil consumption cleaning. The vehicle was repaired however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA ODI #11736165
Official recalls
5Sep 4, 2020
Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles. The Anti-lock Brake Hydraulic Electronic Control Unit (HECU) could corrode internally and cause an electrical short, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire can increase the risk of injury or crash.
Remedy: Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall began November 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 195.
Nov 21, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Additional source detail variants (2)
Trailer Hitches
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Electrical System:wiring
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Aug 30, 2016
Hyundai Motor Company (Hyundai) is recalling certain model year 2016 Tucson vehicles manufactured May 20, 2015 through May 31, 2016 and equipped with a 7-speed EcoShift Dual Clutch Transmission. Certain driving conditions and high temperatures may cause the vehicle to not move if the accelerator pedal is pressed and released repeatedly.
Consequence & remedy
Consequence: Inability to move the vehicle while in traffic may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will update the Transmission Control Module software, free of charge. The recall is expected to begin on October 28, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 149.
Additional source detail variants (2)
Electrical System:software
Hyundai Motor Company (Hyundai) is recalling certain model year 2016 Tucson vehicles manufactured May 20, 2015 through May 31, 2016 and equipped with a 7-speed EcoShift Dual Clutch Transmission. Certain driving conditions and high temperatures may cause the vehicle to not move if the accelerator pedal is pressed and released repeatedly.
Consequence: Inability to move the vehicle while in traffic may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will update the Transmission Control Module software, free of charge. The recall is expected to begin on October 28, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 149.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Hyundai Motor Company (Hyundai) is recalling certain model year 2016 Tucson vehicles manufactured May 20, 2015 through May 31, 2016 and equipped with a 7-speed EcoShift Dual Clutch Transmission. Certain driving conditions and high temperatures may cause the vehicle to not move if the accelerator pedal is pressed and released repeatedly.
Consequence: Inability to move the vehicle while in traffic may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will update the Transmission Control Module software, free of charge. The recall is expected to begin on October 28, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 149.
May 24, 2016
Hyundai Motor Company (Hyundai) is recalling certain model year 2016 Tucson vehicles manufactured May 19, 2015 to March 14, 2016. In the affected vehicles, if the primary hood latch has been released, and the vehicle is driven, the secondary hood latch may not hold adequately secure the hood to prevent it from opening while the vehicle is in motion.
Consequence & remedy
Consequence: If the primary hood latch is inadvertently released and the secondary latch cannot secure the hood, the hood may unexpectedly open while driving, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary hood latch, free of charge. The recall began on June 30, 2016. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 145.
Mar 10, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016 Hyundai Tucson vehicles manufactured May 26, 2015 to January 15, 2016 and equipped with an accessory trailer hitch harness either included with the accessory trailer hitch or sold as a service part. In the affected vehicles, when the vehicle's engine is running and the brake lights are illuminated, if the turn signal is activated, the trailer turn signal lights will either turn off or remain continuously illuminated (not flash). As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard Number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Failure to illuminate the trailer's turn signal lights would prevent the communication of the driver's intent, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will update the tow hitch harness, free of charge. The recall began on May 2, 2016. Owners may contact Hyundai customer service at 1-855-371-9640. Hyundai's number for this recall is 142.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration