IllustrationREAR SUBFRAME IS ROTTED. MY 17 YEAR OLD WAS DRIVING ON THE HIGHWAY, SHE LOST CONTROL, IT COULD HAVE BEEN TRAGIC.THE CAR HAS BEEN TOWED AND SITTING IN A PARKING LOT FOR 2 MONTHS AS I CAN NOT FIND THIS PART! MY MECHANIC SAID IT WAS A RECALL WITH THESE CARS.
2005 Hyundai Tucson
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Hyundai Tucson do not stand out strongly from the model-year median of 180.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tucson years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
380–25K
2025–50K
2550–75K
1575–100K
24100–150K
17150K+
139 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports3 fire reports11 injury reports
Structure complaints
20 reportsTL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED THAT THE VEHICLE'S SUBFRAME AND SUSPENSION WERE SEVERELY RUSTED AND CORRODED. THE OIL PAN, FUEL TANK, FUEL TANK CLAMPS, REAR CHASSIS CRADLE, AND FRONT END SUSPENSION (INCLUDING THE STRUTS, SWAY BARS, SWAY BAR CLAMP, SWAY BUSHINGS) WERE REPLACED BY AN INDEPENDENT MECH…
Read full complaint
TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED THAT THE VEHICLE'S SUBFRAME AND SUSPENSION WERE SEVERELY RUSTED AND CORRODED. THE OIL PAN, FUEL TANK, FUEL TANK CLAMPS, REAR CHASSIS CRADLE, AND FRONT END SUSPENSION (INCLUDING THE STRUTS, SWAY BARS, SWAY BAR CLAMP, SWAY BUSHINGS) WERE REPLACED BY AN INDEPENDENT MECHANIC. GARBER HYUNDAI (5450 BAY RD, SAGINAW, MI) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE CONTACT INDICATED THAT THE VEHICLE STILL EXPERIENCED FRONT END VIBRATION WHILE DRIVING. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 155,000.
I HAVE A HYUNDAI THAT HAS A SEVERE SUBFRAME RUST. THE DEALER STATES IT WILL ONLY REPLACE THE PART AND NOTHING MORE. THE SUBFRAME IS SO RUSTED THAT THE PART CANNOT BE ATTACHED. THEY NEED TO REPLACE MORE THAN THE PART ON RECAP TO FIX IT. THEY HAVE HAD MY VEHICLE FOR 3.5 WEEKS OF NOTHING BUT THE RUNAROUND. I NEED YOUR ASSISTANCE TO…
Read full complaint
I HAVE A HYUNDAI THAT HAS A SEVERE SUBFRAME RUST. THE DEALER STATES IT WILL ONLY REPLACE THE PART AND NOTHING MORE. THE SUBFRAME IS SO RUSTED THAT THE PART CANNOT BE ATTACHED. THEY NEED TO REPLACE MORE THAN THE PART ON RECAP TO FIX IT. THEY HAVE HAD MY VEHICLE FOR 3.5 WEEKS OF NOTHING BUT THE RUNAROUND. I NEED YOUR ASSISTANCE TO GET THIS SERIOUS SAFTEY ISSUE FIXED. THERE WILL BE A CRASH IF THEY DON'T FIX IT
"TAKATA RECALL" ON APRIL 8TH APPROXIMATELY 6 O'CLOCK IN THE MORNING I WAS AWAKEN OUT OF MY SLEEP TO MY CAR ON FIRE IN MY YARD. I CALLED THE FIREFIGHTER DEPARTMENT THEY CAME OUT AND SAID IT WAS FROM BAD ELECTRICAL WIRES. MY CAR WAS IN MY FRONT YARD...I LAST DROVE IT THAT NIGHT TO PIZZA HUT
TL* THE CONTACT OWNED A 2005 HYUNDAI TUCSON. THE CONTACT STATED THAT THE SUB FRAME WAS COMPLETELY CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY DIAGNOSED THAT THE SUB FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS AT 180,000.
MY 2005 HYUNDAI TUCSON WAS RECALLED FOR RUST/CORROSION PROBLEM ON THE UNDERCARRIAGE SUBFRAME. THE SERVICE WORK WAS DONE IN NOVEMBER, 2015 BY MY HYUNDAI DEALER IN PLYMOUTH, MA. IT WAS INSPECTED AGAIN APPROXIMATELY 1 MONTH LATER AND DETERMINED THAT IT NEEDED ADDITIONAL PREVENTATIVE RUST RECALL SERVICE WORK TO BE DONE. HYUNDAI M…
Read full complaint
MY 2005 HYUNDAI TUCSON WAS RECALLED FOR RUST/CORROSION PROBLEM ON THE UNDERCARRIAGE SUBFRAME. THE SERVICE WORK WAS DONE IN NOVEMBER, 2015 BY MY HYUNDAI DEALER IN PLYMOUTH, MA. IT WAS INSPECTED AGAIN APPROXIMATELY 1 MONTH LATER AND DETERMINED THAT IT NEEDED ADDITIONAL PREVENTATIVE RUST RECALL SERVICE WORK TO BE DONE. HYUNDAI MOTORS OF AMERICA ASKED FOR ADDITIONAL PHOTOS AND ANOTHER INSPECTION AND CONCLUDED THAT THEY REFUSED TO REPAIR MORE RUST PROBLEMS THAT HAD BECOME SYSTEMIC AND WILL EVENTUALLY AFFECT THE SAFETY OF MY CAR AS THE RUST CONTINUES TO SPREAD OVER TIME. THIS DETERMINATION CAME IN FEBRUARY, 2016. MY CAR ONLY HAS 82,000 MILES AND I WAS HOPING TO KEEP THE CAR FOR SOME TIME LONGER BUT NOW I MAY NOT HAVE THAT OPTION AND MAY NOT QUALIFY FOR SAFETY INSPECTIONS IN THE FUTURE. I HAVE MANY EMAILS THAT WERE EXCHANGED WITH MY HYUNDAI DEALER RELATING TO THIS PROBLEM AND HYUNDAI SERVICE CENTER AND HYUNDAI CORPORATION MADE ME WAIT ALMOST 3 MONTHS WITH CONTINUOUS TRIPS TO THE DEALER WHILE THIS ISSUE WAS BEING PROCESSED. VERY UPSET WITH HYUNDAI MOTORS OF AMERICA AND THEIR UNWILLINGNESS TO CO-OPERATE AND PREVENT A SERIOUS PROBLEM THAT WILL ULTIMATELY RESULT IN A SAFETY PROBLEM. I WILL NO LONGER BE A HYUNDAI CUSTOMER AFTER THIS ORDEAL.
LETTER TO NSTB AND MA ATTORNEY GENERAL, RE HYUNDAI UNDERBODY CORROSION ON 8/6/2015 I RECEIVED A HYUNDAI "SERVICE CAMPAIGN NOTIFICATION" ON MY 2005 TUCSON FOR "UNDER BODY CORROSION." I DID HAVE THE RECALL SERVICE COMPLETED. ('ARRESTS' IT, THEY CLAIM, BUT NOT REMOVES IT.) BY THAT DATE I HAD ALREADY EXPERIENCED TWO FAILURE…
Read full complaint
LETTER TO NSTB AND MA ATTORNEY GENERAL, RE HYUNDAI UNDERBODY CORROSION ON 8/6/2015 I RECEIVED A HYUNDAI "SERVICE CAMPAIGN NOTIFICATION" ON MY 2005 TUCSON FOR "UNDER BODY CORROSION." I DID HAVE THE RECALL SERVICE COMPLETED. ('ARRESTS' IT, THEY CLAIM, BUT NOT REMOVES IT.) BY THAT DATE I HAD ALREADY EXPERIENCED TWO FAILURES CAUSED BY THE CORROSION, BOTH OF WHICH I BELIEVE HAD HIGH POTENTIAL FOR SERIOUS, EVEN FATAL ACCIDENTS. THE REPAIRS COST ALMOST $2,000, BUT THEY REFUSED TO REIMBURSE. I AM MORE CONCERNED WITH THE SAFETY ISSUES. LUCKILY, THE FUEL TANK FALLING ONTO THE DRIVE SHAFT DID NOT RUPTURE AND EXPLODE. THE RIGHT FRONT CONTROL ARM FAILURE CAUSED LOSS OF STEERING CONTROL AND AN ABRUPT STOP INTO THE RIGHT CURB. HAD IT BEEN THE LEFT FRONT,, I WOULD HAVE BEEN STEERED INTO ONCOMING TRAFFIC. HAD IT BEEN AT TURNPIKE SPEED I SUSPECT A LIKELY ROLLOVER. THE LEFT FRONT ARM WAS ALSO NEAR FAILURE. I SENT TWO EMAILS TO HYUNDAI, AND MADE A NUMBER OF CALLS, IN PART REQUESTING REPAIR REIMBURSEMENT, BUT MORE IMPORTANTLY TO TELL THEM MY CONCERN THE CAR WAS UNSAFE TO DRIVE. I ASKED THEM TO BUY IT BACK AT A FAIR PRICE. NO RESPONSE. TWICE, THEY PROMISED TO CONTACT ME IN 2 TO 5 DAYS, THEY DIDN'T, EVER.. WHEN I LATER CALLED THEM AND TOLD THEM I HAD SOLD THE CAR (AT A LOSS IN VALUE) THEY JUST BRUSHED ME OFF. (TO PARAPHRASE THEM: 'IT'S NO LONGER AN ISSUE SINCE YOU NOW DON'T OWN IT'). I CAN PROVIDE DOCUMENTS (REPAIR INVOICES, WITH FINDINGS, AND EMAILS IF YOU WISH). I AM REQUESTING YOU TAKE ACTION TO INVESTIGATE, AND AS NEEDED, TAKE ACTION TO ISSUE STRONGER SANCTIONS AGAINST HYUNDAI, THEY SHOULD BE FORCED TO RECALL ALL THE AFFECTED CARS.
STEERING WHEEL MATERIAL IS DISINTEGRATING. THE MATERIAL IS A RUBBERY COATING AND FIRST BEGAN CRACKING AND PROCEEDED TO COME OFF IN LARGER CHUNKS EXPOSING THE INNER STEEL FRAME. DEALER AND HYUNDAI REFUSED TO OFFER RESOLUTION. *JS
MY VEHICLE WAS PARKED IN MY DRIVEWAY WHEN I OPENED THE REAR HATCH. THE HINGES SUDDENLY DISINTEGRATED, BUSTED RIGHT OFF. THE REAR WINDOW FELL OUT STRIKING ME. THE ONLY WAY IT WAS BEING HELD UP AND KEPT FROM FALLING TO THE GROUND, WAS BY ITS SHOCKS THAT KEEP WINDOW UP WHEN OPENED. I SEE THAT ARE NUMEROUS REPORTS ON THIS MATTER FRO…
Read full complaint
MY VEHICLE WAS PARKED IN MY DRIVEWAY WHEN I OPENED THE REAR HATCH. THE HINGES SUDDENLY DISINTEGRATED, BUSTED RIGHT OFF. THE REAR WINDOW FELL OUT STRIKING ME. THE ONLY WAY IT WAS BEING HELD UP AND KEPT FROM FALLING TO THE GROUND, WAS BY ITS SHOCKS THAT KEEP WINDOW UP WHEN OPENED. I SEE THAT ARE NUMEROUS REPORTS ON THIS MATTER FROM VARIOUS TIMES. IS THERE SOME KIND OF RECALL ON THIS PROBLEM? *TR
AS I WAS DRIVING DOWN THE HIGHWAY, I NOTICED THAT ONE OF THE WINDOWS IN MY 2005 HYUNDAI TUCSON SOUNDED LIKE IT HAD BEEN ROLLED DOWN. ALMOST IMMEDIATELY, MY DAUGHTER YELLED, "OUR WINDOW IS COMING OFF!" I HAD JUST ENOUGH TIME TO LOOK IN MY REARVIEW MIRROR TO SEE THE RIGHT REAR QUARTER PANEL WINDOW BEING HELD ON BY JUST A SMALL STR…
Read full complaint
AS I WAS DRIVING DOWN THE HIGHWAY, I NOTICED THAT ONE OF THE WINDOWS IN MY 2005 HYUNDAI TUCSON SOUNDED LIKE IT HAD BEEN ROLLED DOWN. ALMOST IMMEDIATELY, MY DAUGHTER YELLED, "OUR WINDOW IS COMING OFF!" I HAD JUST ENOUGH TIME TO LOOK IN MY REARVIEW MIRROR TO SEE THE RIGHT REAR QUARTER PANEL WINDOW BEING HELD ON BY JUST A SMALL STRIP OF SOME SORT OF ADHESIVE. IN LESS THAN A SECOND, THE WINDOW FLEW OFF, BEGAN PINWHEELING THROUGH THE AIR AND NARROWLY MISSED THE VEHICLE JUST BEHIND ME. EVEN THE REPAIRMAN AT THE HYUNDAI DEALERSHIP THAT REPLACED THE WINDOW FOR ME WAS SPEECHLESS WHEN I TOLD HIM WHAT HAPPENED. I CONTACTED HYUNDAI, AND ALL THEY WOULD TELL ME IS THAT MY CAR IS OUT OF WARRANTY. WHILE IT WOULD HAVE BEEN NICE FOR THEM TO OFFER TO PAY FOR THE REPAIR, I WAS MUCH MORE CONCERNED WITH THEIR LACK OF CONCERN FOR ANYTHING OTHER THAN THE FACT THAT THE VEHICLE WAS OUT OF WARRANTY. THEY DID NOT ASK FOR ANY DETAILS OR OFFER ANY CONCERN FOR THE POSSIBLE DAMAGE AND/OR LOSS OF LIFE THAT COULD EASILY HAVE OCCURRED HAD THAT WINDOW HIT THE CAR BEHIND ME. *TR
Official recalls
809V280000 · Exterior Lighting
Jul 21, 2009
HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A DEFECTIVE STOP LAMP SWITCH MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION WOULD NOT BE ABLE TO BE SHIFT OUT OF THE "PARK" POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: ANY OF THESE MALFUNCTIONS COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 2, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO CUSTOMER SERVICE AT 1-787-999-4310.
09V122000 · Exterior Lighting:brake Lights:switch
Apr 15, 2009
HYUNDAI IS RECALLING 532,633 MY 2006-2007 ACCENT, ENTOURAGE, SONATA, MY 2007 AZERA, ELANTRA AND SANTA FE, MY 2005-2007 TUCSON AND MY 2007-2008 VERACRUZ VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
07V197000 · Air Bags:frontal:driver Side:inflator Module
May 8, 2007
ON CERTAIN VEHICLES, STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED THAT A SMALL STATURE ADULT DRIVER NOT WEARING A SEAT BELT AND INVOLVED IN A FRONTAL OR NEAR FRONTAL CRASH, THE DEPLOYMENT OF THE DRIVER AIR BAG MAY NOT OCCUR.
Consequence & remedy
Consequence: THIS CAN CAUSE INCREASED RISK OF INJURY TO THE DRIVER UNDER CERTAIN CRASH CONDITIONS.
Remedy: DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE WITH ONE THAT IS DESIGNED TO PROVIDE AN INCREASED MARGIN OF COMPLIANCE FOR LOW RISK DEPLOYMENT FOR SMALL STATURE ADULTS WHO ARE NOT PROPERLY WEARING THE SEAT BELTS. THE RECALL BEGAN ON SEPTEMBER 6, 2007, AND WILL BE PERFORMED IN TWO MAILINGS. OWNERS MAY CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
06V445000 · Air Bags:frontal:driver Side:inflator Module
Nov 22, 2006
ON CERTAIN SPORT UTILITY VEHICLES, DURING STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED IF A SMALL STATURED ADULT DRIVER, NOT WEARING A SEAT BELT, IS INVOLVED IN A FRONTAL OR NEAR FRONTAL CRASH, DEPLOYMENT OF THE DRIVER AIR BAG MAY RESULT IN AN INSUFFICIENT MARGIN OF COMPLIANCE AS MEASURED BY THE TEST DUMMY USED IN THE NHTSA TEST.
Consequence & remedy
Consequence: THIS CAN CAUSE INCREASED RISK OF INJURY TO THE DRIVER UNDER CERTAIN CRASH CONDITIONS.
Remedy: DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE. THE RECALL BEGAN ON JANUARY 29, 2007, AND WILL BE CONDUCTED THROUGH SIX MAILINGS. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
05V342000 · Parking Brake
Jul 27, 2005
ON CERTAIN PASSENGER VEHICLES, THE PARKING LEVER RATCHET PAWL WAS NOT PROPERLY MANUFACTURED AND MAY DAMAGE THE TEETH OF THE PARKING LEVER RATCHET. DAMAGED PARKING BRAKE LEVER RATCHET TEETH MAY PREVENT THE PARKING BRAKE FROM ENGAGING OR MAY ALLOW THE PARKING BRAKE TO RELEASE AFTER IT HAS BEEN ENGAGED.
Consequence & remedy
Consequence: THE INABILITY TO ENGAGE OR THE INADVERTENT RELEASE OF THE PARKING BRAKE LEVER, MAY ALLOW YOUR VEHICLE TO ROLL WHILE IT IS PARKED AND MAY RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE PARKING BRAKE LEVER ASSEMBLY. THE RECALL BEGAN ON SEPTEMBER 12, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
05V315000 · Parking Brake
Jul 7, 2005
ON CERTAIN SPORT UTILITY VEHICLES, THE PARKING BRAKE LEVER RATCHET PAWL WAS NOT PROPERLY MANUFACTURED AND MY DAMAGE THE TEETH OF THE PARKING BRAKE LEVER RATCHET. DAMAGED PARKING BRAKE LEVER RATCHET TEETH MAY PREVENT THE PARKING BRAKE FROM ENGAGING OR MAY ALLOW THE PARKING BRAKE TO RELEASE AFTER IT HAS BEEN ENGAGED.
Consequence & remedy
Consequence: THE INABILITY TO ENGAGE, OR THE INADVERTENT RELEASE OF, THE PARKING BRAKE LEVER MAY ALLOW YOUR VEHICLE TO ROLL WHILE IT IS PARKED AND MAY RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE PARKING BRAKE LEVER ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
05V177000 · Electronic Stability Control:automatic (asc)
Apr 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ELECTRONIC STABILITY PROGRAM (ESP), THE YAW RATE SENSOR MAY BECOME TOO SENSITIVE AND MAY RECALIBRATE INACCURATELY. WHILE DRIVING THE ESP PROGRAM MAY CAUSE THE ENGINE TO REDUCE POWER AND MAY CAUSE A BRAKE AT ONE OF THE WHEELS TO BE INAPPROPRIATELY.
Consequence & remedy
Consequence: BRAKE APPLICATION CAUSED BY INADVERTENT ESP ACTIVATION MAY RESULT IN LOSS OF CONTROL AND A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ESP HYDRAULIC ELECTRONIC CONTROL UNIT. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2005. OWNERS MAY CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
05V119000 · Electronic Stability Control:automatic (asc)
Mar 25, 2005
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ELECTRONIC STABILITY PROGRAM (ESP), THE YAW RATE SENSOR MAY BECOME TOO SENSITIVE AND MAY RECALIBRATE INACCURATELY. WHILE DRIVING THE ESP PROGRAM MAY CAUSE THE ENGINE TO REDUCE POWER AND MAY CAUSE A BRAKE AT ONE OF THE WHEELS TO BE INAPPROPRIATELY.
Consequence & remedy
Consequence: BRAKE APPLICATION CAUSED BY INADVERTENT ESP ACTIVATION MAY RESULT IN LOSS OF CONTROL AND A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ESP HYDRAULIC ELECTRONIC CONTROL UNIT FREE OF CHARGE. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE09003 · Stop Lamp Switch Failure
Opened Jan 14, 2009 · Closed Apr 24, 2009
Status: closed (inferred from source dates) · Electronic Stability Control; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Power Train:automatic Transmission:lever And Linkage:column Shift; Power Train:automatic Transmission:lever And Linkage:floor Shift; Power Train:manual Transmission:column Shift Assembly; Power Train:manual Transmission:floor Shift Assembly; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:pedals And Linkages; Vehicle Speed Control:cruise Control
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (10)
Electronic Stability Control
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights:switch
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:automatic Transmission:lever And Linkage:column Shift
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:automatic Transmission:lever And Linkage:floor Shift
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:manual Transmission:column Shift Assembly
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:manual Transmission:floor Shift Assembly
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Service Brakes, Hydraulic:pedals And Linkages
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Vehicle Speed Control:cruise Control
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.