2020 Hyundai Palisade

Vehicle is experiencing a breakdown in chassis with the failure of at least one rear selfleveling shock absorber on the right rear suspension of the vehicle and possibly the same condition exists on the left rear suspension. Concern exists for the shock absorber mount to completely become detached from the frame assembly resulting in loss of stability and vehicle control. Hyundai dearlership has been contacted for assistance in remedy of the situation but they have failer to respond to request for replacement/repair of the failed shock absorber mount which has been been noted in a Hyundai Service bulletin.

Engine started burning oil at around 70,000 miles. It now runs almost completely out of oil at around 5,000 miles since last oil change, not even close to reaching the manufacturer recommended interval of 7500 miles between oil changes. On top of the engine consuming oil at an alarming rate, there are no warning indicator lights that turn on to let you know your oil level is critically low. At around 74,000 miles?, Hyundai did a combustion cleaning. I've had two oil changes and it was back to vibrating, knocking, shifting hard, etc, right before a 3rd one at 5,300 miles since the last one and it stalled. The vehicle has now stalled twice, all engine lights flashed, then car stalled. Thankfully, this was not on an interstate or major road. This is a major problem!

This report describes a catastrophic engine failure, framing the event in the context of the widespread Hyundai GDI engine oil consumption issue and its impact on oil-dependent systems like the CVVT/OCV. ​Description of Incident @ 148,000 miles my vehicle oil was changed. ​On May 15, 2025, @ 151,000 miles my 2020 Hyundai Palisade was serviced at Patterson Hyundai Tyler (3120 S SW Loop 323, Tyler, TX 75701) for the replacement of the oil intake valve (OCV/CVVT solenoid). With reports of oil consumption. This type of service is often necessitated by sludge or contamination from excessive oil consumption clogging the valve screens and restricting oil flow to the VVT system. ​Shortly after this service, on 05/22/25, the engine experienced a catastrophic failure. There was an immediate and loud metallic grinding noise (consistent with severe internal bearing/connecting rod damage), followed by complete loss of engine power and instantaneous stalling. ​The failure is assessed to be a result of the underlying GDI defect related to excessive oil consumption, which can lead to internal engine starvation. This starvation may have been triggered or exacerbated by a failure within the oil circulation path (potentially involving the recently serviced OCV or adjacent components). The vehicle is part of the population of Hyundai GDI engines known for issues where low oil levels—due to consumption—or contamination lead to bearing and connecting rod failure. The vehicle has all maintence records and can provide them. ​The vehicle is currently located at Greenville Hyundai at 5395 I-30 Frontage Rd, Greenville, TX 75402 and is available for inspection upon request. Service Manager is Isaac.

Issues began in November of 2024 Began with a a oil consumption test and failed. Submitted for a new engine due to high oil consumption 3 quarts in 1,000 miles. Waited 6 months for a new engine to be available. July 2025 noted oil leaking brought in for repair and stated it was a boot joint that was leaking. Multiple return trips to repair since oil was still leaking. Check Engine light came on in , September and a faulty sensor in engine was noted (for mixing air and gas?), replaced sensor. Oil still continues to leak and after insisting they take the entire engine out to figure out where it was coming from a leaking faulty oil plug was noted on the rear side of the engine.

I am the 3rd time owner of this palisade. Car was bought after a transmission replacement at 27,000 miles. (Second transmission). At around 70,000 miles, we started to have oil consumption problems/ignition coil problems. After a slew of tests and other recommend procedures that cost us money out of pocket, hyundai recommended to get a new engine. We get the new engine. They call to tell us the new engine is done, and proceed to share the transmission is bad and it needs a new one (3rd transmission). They are asking us to pay for the transmission as well. We want a buy back as we think this is a lemon car. 3 transmissions and a new engine under 85000 miles is not good and definitely grounds for investigation. These repeated failures make it unsafe/unreliable for us to drive our 6 month old baby in, let alone my wife and my myself. . We request and investigation/buyback.

Our motor has been consuming a lot of oil, we were told that Hyundai knows about the issue and that there is nothing they can do. We got sold a poor excuse of a warranty in which they never told us that the warranty would not cover oil consumption, but we have the “best” warranty they had. Our car has died GOING DOWN THE ROAD WITH MY 4 kids and WIFE! Cars had to swerve to avoid a collision, 5 times this has happened but yet they will not do anything! We will be seeking legal help!

Engine started burning oil at 65000 miles. It has now run almost completely out of oil twice at about 4200 miles since last oil change, not even close to reaching the manufacturer recommended interval of 7500 miles between oil changes. On top of the engine consuming oil at an alarming rate, there are no warning indicator lights that turn on to let you know your oil level is critically low.