NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
65 reportsClear category filterMileage unknown · Aug 19, 2026
Engine
The engine auto idle system failed at a stoplight. The auto-idle engaged, but when I took my foot off the brake, the engine did not restart. It completely shut down, putting my car in park in a busy intersection. The engine light and an error message flashed briefly but disappeared. I was able to restart the car and drive, howev…
Read full complaint
The engine auto idle system failed at a stoplight. The auto-idle engaged, but when I took my foot off the brake, the engine did not restart. It completely shut down, putting my car in park in a busy intersection. The engine light and an error message flashed briefly but disappeared. I was able to restart the car and drive, however, only after waving several other cars to pass by me. I've noticed recently the restart function lagging, and if I put my foot on the gas too soon, the car lurching and jerking forward (indicating the engine isn't restarting quickly or properly). I recently had a full routine service on the vehicle, indicating battery life is good. No other issues appeared such as overheating.
NHTSA ODI #11757997
Mileage unknown · Aug 3, 2026
Engine
Vehicle: 2020 Honda Odyssey VIN: [XXX] Mileage at time of failure: 155413 Component: Engine — Connecting Rod BearingsDescription: My 2020 Honda Odyssey experienced a failure of the connecting rod bearings on 7/30/26, resulting in loud knocking noise. The failure was diagnosed by Luis Asturias at Jim Coleman Honda in Clarksville,…
Read full complaint
Vehicle: 2020 Honda Odyssey VIN: [XXX] Mileage at time of failure: 155413 Component: Engine — Connecting Rod BearingsDescription: My 2020 Honda Odyssey experienced a failure of the connecting rod bearings on 7/30/26, resulting in loud knocking noise. The failure was diagnosed by Luis Asturias at Jim Coleman Honda in Clarksville, MD. This vehicle falls within the scope of NHTSA's open Preliminary Evaluation PE25008, which covers 2018-2020 Honda Odyssey vehicles with the 3.5L J35 V6 engine for this exact failure mode. My dealer declined to cover the repair cost under warranty because no recall has yet been issued. I am filing this complaint to document my experience as part of the ongoing federal investigation. Repair cost estimate: $4573.00. The vehicle is not driveable without this repair.Thank you for your prompt attention,[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11754505
Mileage unknown · Jul 16, 2026
Electrical SystemEnginePower Train
The vehicle is a 2020 Honda Odyssey. A recurring and dangerous safety failure occurs involving the Auto Idle-Stop system. With the system enabled and the vehicle at a complete stop, the engine shuts off as designed. However, upon depressing the brake pedal to resume driving, the engine severely struggles to restart and completel…
Read full complaint
The vehicle is a 2020 Honda Odyssey. A recurring and dangerous safety failure occurs involving the Auto Idle-Stop system. With the system enabled and the vehicle at a complete stop, the engine shuts off as designed. However, upon depressing the brake pedal to resume driving, the engine severely struggles to restart and completely fails. Simultaneously, the vehicle immediately and automatically shifts itself into PARK, and the entire dashboard display illuminates with all available warning icons and messages. This malfunction creates an immediate, high-risk safety hazard. When the incident occurs, I am trapped, locked in PARK, in live traffic lanes, sometimes at busy intersections or during left-hand turns. It is impossible to shift back into drive or quickly restart the engine. I am forced to remain stationary in traffic for multiple minutes until the system allows me to cycle the ignition completely OFF and then back ON to attempt a full restart and shift back into Drive. This leaves my vehicle, my passengers, and other drivers vulnerable to rear-end collisions.
NHTSA ODI #11750904
Mileage unknown · Jul 9, 2026
EngineUnknown Or Other
Multiple times the engine has totally shut down due to the auto idle stop system power loss. I have had the battery replaced a couple times and had the Honda dealership do the software update and I'm still having issues. This is a major safety issue as the car unexpectedly shuts down and takes a minute or so to get started aga…
Read full complaint
Multiple times the engine has totally shut down due to the auto idle stop system power loss. I have had the battery replaced a couple times and had the Honda dealership do the software update and I'm still having issues. This is a major safety issue as the car unexpectedly shuts down and takes a minute or so to get started again causing traffice backups.
NHTSA ODI #11749230
Mileage unknown · Jul 6, 2026
Engine
While stopped at a traffic light my vehicle went into auto engine idle stop mode. When the light turned green, I removed my foot from the break, but the engine failed to restart. I had to shift the car to park and fully restart the engine.
NHTSA ODI #11748600
Mileage unknown · Jun 26, 2026
EnginePower Train
The automatic engine shut off at stop doesn't always restart engine when moving again. This has happened several times where the engine doesn't restart after the engine shut off is engaged. This is the same issue as reported in NHTSA Action Number: EA25004
NHTSA ODI #11746631
59,000 miles · Jun 23, 2026
Engine
The contact owns a 2020 Honda Odyssey. The contact stated that while reversing at an undisclosed speed, the vehicle stalled. No warning lights were illuminated. The vehicle was towed to a dealer where it was diagnosed and it was determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was …
Read full complaint
The contact owns a 2020 Honda Odyssey. The contact stated that while reversing at an undisclosed speed, the vehicle stalled. No warning lights were illuminated. The vehicle was towed to a dealer where it was diagnosed and it was determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 59,000.
NHTSA ODI #11745963
Mileage unknown · Jun 23, 2026
Electrical SystemEngineUnknown Or Other
The auto Start/Stop feature doesn't work as needed. It will randomly lurch, turn the car off make me put it in park and then have me restart it. Sometimes the car does not start right away and I am stuck on the road until it decided when and if it will restart. Myself and my family of 5 are not stuck in the road scared of gett…
Read full complaint
The auto Start/Stop feature doesn't work as needed. It will randomly lurch, turn the car off make me put it in park and then have me restart it. Sometimes the car does not start right away and I am stuck on the road until it decided when and if it will restart. Myself and my family of 5 are not stuck in the road scared of getting smashed into by other drivers unaware that we are stopped or anticipating for us not to be stopped in the middle of the road. I really dont want my family to go to the hospital or die because of this nonsense. Sometimes it doesn't fully shut off but will give error warnings like collision mitigation assistance even though there is nothing for it to mitigate. There are no cars around me and it shouldn't have done this. This has been happening for some time and only happens haphazardly meaning I can't always have the dealer identify or diagnose the issue. Then when I brought it to the dealer, they told me it was because of a power liftgate module error. Which was not true and didn't solve the issue.
NHTSA ODI #11745915
Mileage unknown · Jun 15, 2026
Electrical SystemEngine
Our vehicle has stalled at stop lights several times over the past 6 years. The auto stop/start feature seems to fail. The vehicle will shut off but when you repeat the brake it will not restart and the vehicle will die completely. You have to put it in park, wait a few seconds and try and restart. Additionally it has completely…
Read full complaint
Our vehicle has stalled at stop lights several times over the past 6 years. The auto stop/start feature seems to fail. The vehicle will shut off but when you repeat the brake it will not restart and the vehicle will die completely. You have to put it in park, wait a few seconds and try and restart. Additionally it has completely died at gas station after turning it off to refuel. When you go to start the vehicle it will be completely dead, zero power. We had to have it jump started. The battery has been replaced twice and was testing normal at the dealership. Not a battery issue. Honda acts like this is unheard of but our own research indicates it is a common well known problem with new Odyssey models.
NHTSA ODI #11744342
85,000 miles · Apr 30, 2026
EngineEngine And Engine Cooling
The contact owns a 2020 Honda Odyssey. The contact stated that the vehicle made an abnormal ticking sound while depressing the accelerator pedal, and the engine made a loud sound. There was no warning light illuminated. Upon investigation, the contact related the failure to NHTSA Action Number: PE25008 (Engine). The vehicle was …
Read full complaint
The contact owns a 2020 Honda Odyssey. The contact stated that the vehicle made an abnormal ticking sound while depressing the accelerator pedal, and the engine made a loud sound. There was no warning light illuminated. Upon investigation, the contact related the failure to NHTSA Action Number: PE25008 (Engine). The vehicle was taken to the local dealer, where it was diagnosed and there were metal shavings found in the engine oil. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and confirmed that there was no recall or warranty coverage for the repair. The failure mileage was approximately 85,000.
NHTSA ODI #11734818
Official recalls
14Jul 1, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey vehicles. Water may enter into the rearview camera, which can cause the rearview camera image to fail to display when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed August 24, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's number for this recall is HOX. This recall expands previous NHTSA recall number 20V438. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 9, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Apr 9, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2022 Odyssey vehicles. A software programming error can cause the side and side curtain air bags to deploy unexpectedly.
Consequence & remedy
Consequence: Air bags that deploy unexpectedly can increase the risk of injury.
Remedy: Dealers will reprogram the supplemental restraint system (SRS) electronic control unit (ECU) software or replace the ECU, as necessary, free of charge. Owner notification letters were mailed May 27, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's number for this recall is UNW. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning April 16, 2026. The information in your report suggests that Honda (American Honda Motor Co.) may have been aware of this issue more than five business days before filing a report with NHTSA. Please be reminded that under Federal law, this agency is to be notified of all safety defect and/or noncompliance decisions within five business days. 49 CFR 573.6 Significant civil penalties can be assessed for this violation.
Feb 1, 2024
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Jun 15, 2023
Honda (American Honda Motor Co.) is recalling certain 2018-2023 Odyssey, 2019-2022 Pilot, and 2019-2023 Passport vehicles. Due to a faulty Media Oriented Systems Transport (MOST) communication coaxial cable connector, the rearview camera image may not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.
Remedy: Dealers will replace the MOST cable harness and install a straightening cover over the vehicle cable connector, free of charge. Owner notification letters were mailed July 24, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are EEL, ZEM, and SFC.
Mar 16, 2023
Honda (American Honda Motor Co) is recalling certain 2020-2021 Pilot and Ridgeline, and 2020-2022 Passport and Odyssey vehicles. The heating pads behind both side-view mirrors may not be bonded properly, allowing the mirror glass to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: Detached mirror glass can reduce driver visibility, increasing the risk of a crash.
Remedy: Dealers will replace both left and right side-view mirrors, free of charge. Owner letters were mailed January 17, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is FE5.
Mar 9, 2023
Honda (American Honda Motor Co.) is recalling certain 2017-2020 CR-V, 2018-2019 Accord and Accord Hybrid, 2018-2020 Odyssey, 2019 Insight, and 2019-2020 Acura RDX vehicles. A manufacturing issue with the front seat belts may cause the seat belt buckle channel to interfere with the release button, preventing the seat belt buckle from latching.
Consequence & remedy
Consequence: An unlatched seat belt cannot properly restrain the seat occupant during a crash, increasing their risk of injury.
Remedy: Dealers will replace the driver and front passenger seat belt buckle release buttons or the buckle assemblies as necessary, free of charge. Owner notification letters were mailed April 18, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are NDA, QDB, BDC, MDD, LD9. TDF, FDG, ODH, YDI, ZDE.
Jan 14, 2021
Braun Corporation (Braun) is recalling certain 2018-2021 Braun-modified Honda Odyssey vehicles. The fuel tank assembly installed by Braun may be susceptible to the fuel tank overfilling into the charcoal canister. If the charcoal canister fills with a sufficient amount of fuel, fuel may leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may increase the risk of fire.
Remedy: Braun will notify owners, and dealers will inspect vehicles. If evidence of a fuel leak is present, a new fuel tank assembly and a new Honda charcoal canister will be installed, free of charge. The recall began February 22, 2021. Owners may contact Braun customer service at 1-800-488-0359.
Jul 28, 2020
Honda (America Honda Motor Co.) is recalling certain 2018-2020 Odyssey vehicles. Water may enter the outer door handle cables for the sliding doors. If this occurs, the outer door handle cables may freeze in cold temperatures, preventing the front and rear sliding door latches from securely latching.
Consequence & remedy
Consequence: A power sliding door that fails to latch may open while moving, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will replace the power sliding door outer handle cables, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is A88.
Jul 28, 2020
American Honda Motor Co. (Honda) is recalling certain 2019-2020 Odyssey vehicles. Water may get into the rearview camera mounting holes and enter the camera lens and cause a distorted image, or no image at all. Additionally, if the rearview camera view mode is set to top-down view, or switched from that view to another mode in a bright environment, the image may not display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: A distorted or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the rearview camera, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is W83.
Jul 28, 2020
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."
Consequence & remedy
Consequence: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will reprogram the instrument panel control module software, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T89.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."
Consequence: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will reprogram the instrument panel control module software, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T89.
Electrical System:software
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."
Consequence: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will reprogram the instrument panel control module software, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T89.
Jul 28, 2020
Honda (American Honda Motor Co.) is recalling certain 2019-2021 Pilot, 2019-2020 Odyssey and 2019-2020 Passport vehicles. Incorrect central network software programming may cause several errors to occur that can delay or prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: A delayed or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners that updated software is available. Owners have the option to either follow the mailed instructions to download and update the software for free, or visit a dealer to have the software update performed, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is Y7Y.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Honda (American Honda Motor Co.) is recalling certain 2019-2021 Pilot, 2019-2020 Odyssey and 2019-2020 Passport vehicles. Incorrect central network software programming may cause several errors to occur that can delay or prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence: A delayed or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners that updated software is available. Owners have the option to either follow the mailed instructions to download and update the software for free, or visit a dealer to have the software update performed, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is Y7Y.
Electrical System:software
Honda (American Honda Motor Co.) is recalling certain 2019-2021 Pilot, 2019-2020 Odyssey and 2019-2020 Passport vehicles. Incorrect central network software programming may cause several errors to occur that can delay or prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence: A delayed or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners that updated software is available. Owners have the option to either follow the mailed instructions to download and update the software for free, or visit a dealer to have the software update performed, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is Y7Y.
Feb 6, 2020
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey vehicles. The wire harness for the third row seat accessory power outlet may get pinched between the unibody and rear trim panel, possibly damaging the wires and causing an electrical short.
Consequence & remedy
Consequence: An intermittent electrical short could overheat the wire harness, increasing the risk of a fire.
Remedy: Honda will notify owners, and dealers will inspect the third row seat accessory power outlet wire harness for damage, replacing it as necessary. If no damage is found, the dealer will apply protective tape and re-route the harness. All repairs will be performed free of charge. The recall began March 16, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T6U.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25018 · Inadvertent Deployment Of Side Air Bags
Opened Oct 28, 2025 · Closed Jun 25, 2026
Status: closed (inferred from source dates) · Air Bags; Air Bags:sensor:side Impact; Air Bags:side/window
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Air Bags
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Air Bags:sensor:side Impact
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Air Bags:side/window
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
Illustration