IllustrationSTEERING "STICKY STEERING CHECK STEERING THE STEERING WHEEL STICKS IN CERTAIN SPOTS ESPECIALLY WHEN TURNING WHEEL
2018 Honda CR-V
Owner reports · Recalls · Investigations
More warning signs than most CR-V years
Owner complaints for the 2018 Honda CR-V are substantially higher than the model-year median of 400.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all CR-V years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
5830–25K
13325–50K
7250–75K
5575–100K
36100–150K
5150K+
884 reports with mileage · 1,253 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 527 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Forward Collision Avoidance. Review the 392 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 369 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports2 fire reports39 injury reports
Steering complaints
323 reportsSteering has sticky response from the neutral position. Car has 60000 mi. Seems be after car warms up, and over 35 mph. When driving, when car is starting to drift left, light steering to right hangs up briefly before jumping right slightly. No warning lights and lane departure is off. No tire problems. Recent alignment. …
Read full complaint
Steering has sticky response from the neutral position. Car has 60000 mi. Seems be after car warms up, and over 35 mph. When driving, when car is starting to drift left, light steering to right hangs up briefly before jumping right slightly. No warning lights and lane departure is off. No tire problems. Recent alignment. No recall on this car, but problem seems very similar to other cr-v recalls with electric steering. My wife is afraid to drive car very far, as problem has become much more pronounced since it started last month. There is a definite feeling of lack of steering control. Car will taken to dealer as soon as possible.
EPS RACK. steering sticks turning left and right
Steering has a sticky spout requiring extra effort when making slight adjustments.
Steering becomes “sticky” when turning. Wheel does not reset to straight position in timely manner. Extra effort required to steer vehicle. There is no warning light or engine light that comes on. Car almost impossible to steer making the vehicle unsafe.
The contact owns a 2018 Honda CR-V. The contact stated while driving 55 MPH, the steering wheel failed to respond as needed. There was no warning light illuminated. The contact and her husband diagnosed the vehicle with sticky steering. The local dealer was contacted; however, the vehicle was not repaired because it was not unde…
Read full complaint
The contact owns a 2018 Honda CR-V. The contact stated while driving 55 MPH, the steering wheel failed to respond as needed. There was no warning light illuminated. The contact and her husband diagnosed the vehicle with sticky steering. The local dealer was contacted; however, the vehicle was not repaired because it was not under recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,000.
When making a steering correction, there is a tendency for the steering to get stuck in a fixed position for a brief period. It takes an abnormal level of force to overcome this stickiness before it becomes un-stuck and allows a steering change. As a result, there is some jerkiness in the steering, which presents a significant…
Read full complaint
When making a steering correction, there is a tendency for the steering to get stuck in a fixed position for a brief period. It takes an abnormal level of force to overcome this stickiness before it becomes un-stuck and allows a steering change. As a result, there is some jerkiness in the steering, which presents a significant safety issue. It is more noticeable at higher speeds and can be a bit alarming, and a potential collision hazard, particularly if surrounded by other vehicles on a major highway, which I have experienced with this vehicle. I have not yet taken it to a dealer or service provider but have read several forums on-line and tried some of the recommended remedies, such as adjusting the steering column and turning the wheel slowly through full motion, which did not resolve the issue.
In this model of Honda steering wheel looses controls like loosing the steering for fraction of seconds it like steering and wheel movement has lag you feel like it's tiny motion in steering wheel. If you holds steering wheel while driving it tends to not stay in place and you need to keep making tiny motion to keep in place. De…
Read full complaint
In this model of Honda steering wheel looses controls like loosing the steering for fraction of seconds it like steering and wheel movement has lag you feel like it's tiny motion in steering wheel. If you holds steering wheel while driving it tends to not stay in place and you need to keep making tiny motion to keep in place. Dealer did not recognize this as issue and asked to comeback if it's get worst. As driver my fear is for me and my family as if it fails or do malfunction we can loose control of the vehicle and loss of life can occur. Someone needs to carefully inspect it to find what component making is responsible and provide remediation.
My 2018 CR-V EX is experiencing a "sticky steering" issue that has gotten noticeably worse over time (I purchased the vehicle new). When driving around long, steady curves, in particular, and typically at speeds in the 40 to 60+ mph range, the steering wheel sticks at that orientation to the point that you can feel it doesn't w…
Read full complaint
My 2018 CR-V EX is experiencing a "sticky steering" issue that has gotten noticeably worse over time (I purchased the vehicle new). When driving around long, steady curves, in particular, and typically at speeds in the 40 to 60+ mph range, the steering wheel sticks at that orientation to the point that you can feel it doesn't want to move. When coming out of the curve, or if the turn radius changes requiring you to straighten out a bit, it doesn't want to move back toward center; it requires a bit of effort to get it to "unstick" and straighten out. Once you apply that required force, though, it doesn't unstick smoothly but in sort of a jerking fashion back toward straight, which can cause a bit of an overcorrection. I see that there is a steering recall of 2018 CR-V's requiring a replacement of the gear box, although my VIN is not included, and I also see that there is a major recall recently for newer Hondas, including the CR-V, that seems to perfectly describe this issue. Apparently, it's a significant safety concern if they're recalling one to two million vehicles for it, and from all of the similar reviews and complaints I've read from other 2018 CR-V owners, it appears it's long been an issue with this gear box, although only recently acknowledged on the more recent vehicles. This should clearly be evaluated and reconsidered going back to 2018 when the CR-V redesign happened, as I and MANY other 2018 CR-V owners are and have been experiencing this same issue that's warranted a safety recall on the newer models.
The contact owns a 2018 Honda CR-V. The contact stated while driving at an undisclosed speed, the contact noticed that the steering wheel seized and the contact stated the steering wheel felt very tight with no warning light illuminated. The contact stated that the steering became difficult to turn and also heard a clanking nois…
Read full complaint
The contact owns a 2018 Honda CR-V. The contact stated while driving at an undisclosed speed, the contact noticed that the steering wheel seized and the contact stated the steering wheel felt very tight with no warning light illuminated. The contact stated that the steering became difficult to turn and also heard a clanking noise when the contact attempted to turn the steering wheel. The vehicle was taken to the dealer where it was diagnosed that the steering gearbox failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 33,100.
Official recalls
526V332000 · Air Bags:sensor:occupant Classification:front Passenger
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
23V858000 · Fuel System, Gasoline:delivery:fuel Pump
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
23V158000 · Seat Belts:front:buckle Assembly
Mar 9, 2023
Honda (American Honda Motor Co.) is recalling certain 2017-2020 CR-V, 2018-2019 Accord and Accord Hybrid, 2018-2020 Odyssey, 2019 Insight, and 2019-2020 Acura RDX vehicles. A manufacturing issue with the front seat belts may cause the seat belt buckle channel to interfere with the release button, preventing the seat belt buckle from latching.
Consequence & remedy
Consequence: An unlatched seat belt cannot properly restrain the seat occupant during a crash, increasing their risk of injury.
Remedy: Dealers will replace the driver and front passenger seat belt buckle release buttons or the buckle assemblies as necessary, free of charge. Owner notification letters were mailed April 18, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are NDA, QDB, BDC, MDD, LD9. TDF, FDG, ODH, YDI, ZDE.
21V215000 · Fuel System, Gasoline:delivery:fuel Pump
Mar 25, 2021
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Acura MDX, MDX Sport Hybrid, RDX, TLX, Honda Accord, Civic Hatchback, Insight, 2019 Acura ILX, Honda Accord Hybrid, Civic Coupe, Civic Coupe Si, Civic Sedan, Civic Sedan Si, Civic Type R, Fit, HR-V, Odyssey, Passport, Pilot and Ridgeline, and 2018-2019 CR-V vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the fuel pump assembly, free of charge. Owner letters were mailed May 18, 2021. Owners may contact Honda customer service at 1-888-234-2138. Note: This recall is an expansion of recall 20V-314.
18V663000 · Steering:electric Power Assist System
Sep 27, 2018
Honda (American Honda Motor Co.) is recalling certain 2017-2018 Honda Civic and CR-V vehicles. The magnet that controls the torque sensor output signal for the electronic power steering system may not be properly secured, allowing the magnet to become dislodged. During a full lock turn, the dislodged magnet may cause steering assist to be applied in the opposite direction.
Consequence & remedy
Consequence: The unintended steering input reduces vehicle maneuverability and increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the steering gearbox assembly, free of charge. The recall began November 9, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are C2N, P2O.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA24002 · Inadvertent Automatic Emergency Braking
Opened Apr 15, 2024 · No close date supplied
Status: open (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking; Forward Collision Avoidance: Sensing System: Camera; Forward Collision Avoidance: Sensing System: Radar; Forward Collision Avoidance:software
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (5)
Forward Collision Avoidance: Automatic Emergency Braking
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance: Sensing System: Camera
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance: Sensing System: Radar
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance:software
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE22011 · Rear Differential Seizure
Opened Nov 28, 2022 · Closed Jul 22, 2024
Status: closed (inferred from source dates) · Power Train; Power Train:axle Assembly; Power Train:axle Assembly:axle Shaft; Power Train:axle Assembly:axle Shaft:seal; Power Train:driveline:differential Unit; Power Train:driveline:driveshaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Additional source detail variants (6)
Power Train:axle Assembly:axle Shaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:axle Assembly:axle Shaft:seal
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:axle Assembly
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:driveline:differential Unit
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:driveline:driveshaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
PE22003 · Inadvertent Automatic Emergency Braking
Opened Feb 21, 2022 · Closed Apr 18, 2024
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking; Forward Collision Avoidance: Sensing System: Camera; Forward Collision Avoidance: Sensing System: Radar; Forward Collision Avoidance:software
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (5)
Forward Collision Avoidance: Automatic Emergency Braking
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance: Sensing System: Camera
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance: Sensing System: Radar
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance:software
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.