NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
63 reportsClear category filter16 miles · Jun 3, 2020
EnginePower Train
I PURCHASED THE VEHICLE WITH 16 MILES ON IT; I BOUGHT IT BRAND NEW. IT LEAKED OIL AND TRANSMISSION FLUID ALL OVER MY GARAGE AND WHILE DRIVING THE CAR. I HAD A SIGNIFICANT OIL AND TRANSMISSION LEAK. HAD TO TOW THE CAR TO BE REPAIRED. THE SAME ISSUE HAPPENED AGAIN WHERE IT DUMPED ALL THE OIL OUT OF THE ENGINE, AND THEY HAD TO FIX…
Read full complaint
I PURCHASED THE VEHICLE WITH 16 MILES ON IT; I BOUGHT IT BRAND NEW. IT LEAKED OIL AND TRANSMISSION FLUID ALL OVER MY GARAGE AND WHILE DRIVING THE CAR. I HAD A SIGNIFICANT OIL AND TRANSMISSION LEAK. HAD TO TOW THE CAR TO BE REPAIRED. THE SAME ISSUE HAPPENED AGAIN WHERE IT DUMPED ALL THE OIL OUT OF THE ENGINE, AND THEY HAD TO FIX IT FOR A SECOND TIME. THEY INFORMED ME THERE WASN'T ANY OIL LEFT IN MY ENGINE AND THIS WAS RIGHT AFTER AN OIL CHANGE.THEY SAID THIS NEVER HAPPENS, BUT IT DID TWICE. MY 36,000-MILE WARRANTY IS ALMOST UP, AND I HAVE A FEELING THIS IS AN ONGOING ISSUE. LAST TIME IT LEAKED, IT TOOK THEM THREE MONTHS TO FIX IT. I PAID A LOT OF MONEY WHEN I BOUGHT MY FIRST NEW CAR EVER. IT'S A SHAME I BOUGHT A LEMON, AND I'M PAYING MONTHLY FOR IT. THIS ISSUE NEEDS TO BE ADDRESSED BECAUSE MY CAR START LIGHT ALWAYS BLINKS ON AND OFF ALSO, AND THEY CAN'T FIGURE IT OUT. ALSO, MY TOUCHSCREEN HAS FROZEN AND LET THE RADIO ON FULL BLAST WHILE I WAS DRIVING AND WOULDN'T SHUT OFF ON MORE THAN ONE OCCASION. *TR
NHTSA ODI #11327099
Mileage unknown · Mar 2, 2020
Power Train
FROM THE DATE I PURCHASED (SO HONDA ALREADY KNEW OF PROBLEM) MY VEHICLE OIL IS BEING OVER FILLED (AND DILUTED) WITH GASOLINE. IT DILUTES AND OVERFILLS TO THE POINT OF PCV VALVE BURN OFF. NOW 33000 MILES ON AUTO, HONDA WANTS TO CHANGE INJECTORS TO "SEE" IF THIS SOLVES PROBLEM. ONE: IT'S HAPPENED SINCE NEW. INJECTORS OR DOUBTFULLY…
Read full complaint
FROM THE DATE I PURCHASED (SO HONDA ALREADY KNEW OF PROBLEM) MY VEHICLE OIL IS BEING OVER FILLED (AND DILUTED) WITH GASOLINE. IT DILUTES AND OVERFILLS TO THE POINT OF PCV VALVE BURN OFF. NOW 33000 MILES ON AUTO, HONDA WANTS TO CHANGE INJECTORS TO "SEE" IF THIS SOLVES PROBLEM. ONE: IT'S HAPPENED SINCE NEW. INJECTORS OR DOUBTFULLY THE PROBLEM. TWO: 33000 MILES OF GAS/OIL DILUTION HAS UNDOUBTEDLY CAUSED WEAR TO CRANK AND CYLINDERS. HOW IS INJECTORS BEING REPLACED GOING TO "SOLVE" THE WEAR THAT THEY HAVE ALLOWED, SINCE MY CONTINUED CONCERNS AT EVERY SINGLE OIL CHANGE FOR 33000 MILES WERE IGNORED? I HAVE READ THIS IS NOT AN UNCOMMON PROBLEM, BUT VERY COMMON WITH THIS ENGINE. ONE: WHY HAVEN'T THEY ADDRESSED MY CONCERNS FOR 33000 MILES? TWO: WITH A KNOWN PROBLEM, AND THE CUSTOMER COMPLAINING FROM THE START OF DILUTION, WHY HAVEN'T THEY ADDRESSED THE WEAR TO MY ENGINE? AN EXTENDED WARRANTY DOES NOT STOP THE DAMAGE CAUSED BY HONDA IGNORING MY COMPLAINTS FOR 33000 MILES TO START A REPAIR. NOTE, I HAVE ADDRESSED OVERFILLING WITH GASOLINE AT EVERY OIL CHANGE (GARAGE VISIT) TO THE POINT OF ARGUMENT JUST TO GET IT DOCUMENTED THAT I RAISED THE ISSUE! IT DILUTES TO PCV VALVE BURNOFF BEFORE 1000 MILES (AS TESTED AND VERIFIED BY HONDA DEALERSHIP!) AND GOES FOR AT LEAST 5000 MILES BETWEEN OIL CHANGES. EVERY DAY MORE GAS AND OIL ARE BURNT THROUGH EXHAUST AS MORE GAS IS ADDED. I WILL COMPLY WITH THE INJECTOR "FIX" BY THE GARAGE, BUT WANT MY WEAR TO THE ENGINE ADDRESSED. THIS IS GROSS OVERFILLING AND DILUTION, KNOWN BY HONDA, AND SOLD TO ME ANYWAYS, WITH NO REPAIR AS OF YET TO WEAR. WHAT HAPPENS WHEN WARRANTY RUNS OUT AND THEY HAVE ALLOWED SUCH GROSS DILUTION AND WEAR? THEY ARE CLAIMING A "COLD CLIMATE" PROBLEM, BUT MY DOES IT IN THE HEAT OF THE SOUTH CAROLINA SUMMER! HONDA IS COVERING UP.
NHTSA ODI #11315528
6,329 miles · Feb 18, 2020
Power Train
ENGINE OIL DILUTION CONTINUES AFTER HONDA FIX WITH REPROGRAMMING ENGINE COMPUTER AND AC CONTROL MODULE REPLACEMENT. HONDA HAS EXTENDED THE POWERTRAIN WARRANTY TO 6 YEARS UNLIMITED MILEAGE FROM THE ORIGINAL SALE DATE. CURRENT MILEAGE 14,000. ENGINE OIL AND FILTER HAS BEEN CHANGED 8 TIMES DUE TO THIS PROBLEM.
NHTSA ODI #11309775
20,165 miles · Aug 29, 2019
EnginePower Train
2018 HONDA CRV EX: MILEAGE 20,165. UPON ACCELERATING WHILE PULLING THE CAR ON MAIN ROADWAY, THE CAR DROPPED FROM 50MPH TO 25MPH AND THEN WOULDN'T REACH PAST 35MPH, THE ENGINE LIGHT APPEARED AND STARTED TO BLINK. PUSHING THE GAS PEDAL ONLY AGGRAVATED THE SITUATION. ABOUT A MILE LATER THE CAR STOPPED/STALLED TRYING TO GO UP A HIL…
Read full complaint
2018 HONDA CRV EX: MILEAGE 20,165. UPON ACCELERATING WHILE PULLING THE CAR ON MAIN ROADWAY, THE CAR DROPPED FROM 50MPH TO 25MPH AND THEN WOULDN'T REACH PAST 35MPH, THE ENGINE LIGHT APPEARED AND STARTED TO BLINK. PUSHING THE GAS PEDAL ONLY AGGRAVATED THE SITUATION. ABOUT A MILE LATER THE CAR STOPPED/STALLED TRYING TO GO UP A HILL. I TURNED OFF CAR, WAITED 10 MIN AND RESTARTED. WAS ABLE TO GO ANOTHER 1 MILE TO HOME, I DID NOT ATTEMPT TO GO OVER 25 MPH, BECAUSE ENGINE LIGHT WAS STILL BLINKING. THE NEXT MORNING, I DROVE THE CAR TO THE DEALER, BUT MADE SURE I DID NOT GO OVER 30MPH, AS I DID NOT WANT IT TO STALL. DURING THE DRIVE THE ENGINE LIGHT WAS STILL BLINKING. WAITING TO HEAR BACK.FROM THE DEALER. I BELIEVE THIS IS A POWERTRAIN ISSUE THAT HAS BEEN DOCUMENTED BY HONDA AND ALL 2017/2018 CRVS HAVE BEEN RECALLED IN CHINA AND EUROPE, BUT NOT THE US.
NHTSA ODI #11252166
4,500 miles · Jul 6, 2019
EngineFuel/propulsion SystemPower Train
THIS VEHICLE AFTER HAVING 4500 MILES, BEGAN TO SMELL TERRIBLY OF GASOLINE INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE SPUTTERED , DID NOT WANT TO RUN, AND STALLED A FEW TIMES BEFORE I WOUND UP AT THE DEALERSHIP. I ALSO NOTICED THAT WHEN THE LITTLE WRENCH CAME ON, FOR A NOTIFICATION OF THE FIRST OIL CHANGE, THAT THE VEHICLE …
Read full complaint
THIS VEHICLE AFTER HAVING 4500 MILES, BEGAN TO SMELL TERRIBLY OF GASOLINE INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE SPUTTERED , DID NOT WANT TO RUN, AND STALLED A FEW TIMES BEFORE I WOUND UP AT THE DEALERSHIP. I ALSO NOTICED THAT WHEN THE LITTLE WRENCH CAME ON, FOR A NOTIFICATION OF THE FIRST OIL CHANGE, THAT THE VEHICLE MADE A LOUD GROWLING NOISE. THE VEHICLE IS SITTING IN THE DEALERSHIP RIGHT NOW WAITING A HOPEFUL REPAIR. HERE I AM WITH NO VEHICLE, AND A $400 PER MONTH PAYMENT. THIS IS ABSOLUTELY UNACCEPTABLE IN TODAY'S WORLD. THIS PROBLEM SHOULD HAVE BEEN FIXED, BEFORE THE VEHICLE WAS ALLOWED TO BE PUT UP FOR SALE . A VEHICLE IS DEEMED NOT SAFE, WHEN IT'S STALLS ON YOU IN THE MIDDLE OF TRAFFIC.
NHTSA ODI #11229718
21,000 miles · Jun 12, 2019
Power Train
WHILE DRIVING OUR 2017 HONDA CRV TODAY WITH OUR YOUNG GRANDCHILDREN IN THE VEHICLE ON A BUSY HIGHWAY THE GEAR SHIFT BUTTON ON THE SHIFTER AND A SPRING SUDDENLY POPPED OUT AND FELL ON THE FLOOR. I PULLED OFF THE ROAD AND OBVIOUSLY COULD NOT SHIFT THE VEHICLE INTO PARK OR REVERSE. LUCKILY I WAS ABLE TO LEAVE THE VEHICLE IN DRIVE A…
Read full complaint
WHILE DRIVING OUR 2017 HONDA CRV TODAY WITH OUR YOUNG GRANDCHILDREN IN THE VEHICLE ON A BUSY HIGHWAY THE GEAR SHIFT BUTTON ON THE SHIFTER AND A SPRING SUDDENLY POPPED OUT AND FELL ON THE FLOOR. I PULLED OFF THE ROAD AND OBVIOUSLY COULD NOT SHIFT THE VEHICLE INTO PARK OR REVERSE. LUCKILY I WAS ABLE TO LEAVE THE VEHICLE IN DRIVE AND MAKE IT BACK TO OUR HOUSE. I CONSIDER THIS A SERIOUS ISSUE. I HAVE READ OF SEVERAL INSTANCES OF THIS HAPPENING AND THE CRV REQUIRING TO BE TOWED TO A DEALERSHIP. HONDA NEEDS TO ISSUE A RECALL ON THIS ISSUE AS WELL AS THE SERIOUS GAS IN OIL ISSUE WITH THIS VEHICLE. WE LIVE IN AN AREA WITH SEVERE WINTER WEATHER AND THE POSSIBILITY OF BEING STRANDED BECAUSE OF THIS DEFECT IS DANGEROUS.
NHTSA ODI #11219643
9,500 miles · Apr 15, 2019
Power Train
SMELLED GASOLINE IN AND OUTSIDE THE CAR. CAR NEVER WARMS UP. HEAT DOES NOT WORK. ENGINE OIL SMELLS LIKE GASOLINE & SIGNIFICANTLY OVER FULL MARK ON DIPSTICK. TOOK VEHICLE TO HONDA DEALER LATE NOVEMBER 2018. PARTS TOOK SEVERAL WEEKS. COMPLETED 12/17/18 HONDA UPDATE 18-114. HEAT NEVER WORKED OVER WINTER, CAR NEVER WARMED UP UNLESS …
Read full complaint
SMELLED GASOLINE IN AND OUTSIDE THE CAR. CAR NEVER WARMS UP. HEAT DOES NOT WORK. ENGINE OIL SMELLS LIKE GASOLINE & SIGNIFICANTLY OVER FULL MARK ON DIPSTICK. TOOK VEHICLE TO HONDA DEALER LATE NOVEMBER 2018. PARTS TOOK SEVERAL WEEKS. COMPLETED 12/17/18 HONDA UPDATE 18-114. HEAT NEVER WORKED OVER WINTER, CAR NEVER WARMED UP UNLESS DRIVEN IN "L" FOR AN EXTENDED PERIOD OF TIME, SMELLED OF GAS & ENGINE OIL LEVEL EXCEEDED FULL MARK. TOOK INTO DEALER & DEALER MEASURE ENGINE OIL OVER 1 INCH ABOVE FULL ON DIPSTICK. HONDA SERVICE ADVISOR CONSULTED WITH HONDA WHO STATED THIS IS A "NORMAL" CHARACTERISTIC OF THIS MOTOR. NOTHING WAS DONE TO FIX ISSUE & DEEMED EXCESSIVE GASOLINE IN THE OIL AS BEING NORMAL. ENGINE CONTINUES NOT TO PROVIDE HEAT & OCCASSIONALLY SMELLS OF GASOLINE. DEALER STATES IF CAR IS PRIMARILY USED FOR SHORT DISTANCES THE VEHICLE DOES NOT HAVE TIME TO WARM UP & BURN OFF EXCESS GASOLINE IN THE INJECTORS. I HAVE LIVED IN THE SAME HOUSE FOR 15 YEARS & IN THAT TIME HAD 7 CARS. MY COMMUTES & OVERALL USE OF VEHICLES HAS NOT CHANGED BUT THIS IS THE ONLY CAR TO EXPERIENCE THIS ISSUE.
NHTSA ODI #11196526
2,339 miles · Mar 30, 2019
EngineFuel/propulsion SystemPower Train
ON 3 DIFFERENT OCCASIONS, WHILE DRIVING THE CAR ON THE INTERSTATE HIGHWAY, IT STARTED VIBRATING, AND WOULD NOT ACCELERATE, BURNING SMELL OCCURRED, SEVERAL WARNING LIGHTS CAME UP ON THE DASHBOARD. WE HAD TO NAVIGATE THE CAR FROM THE MIDDLE OF HIGHWAY TO THE SHOULDER OF THE HIGHWAY VERY ABRUPTLY. IT WAS A NEAR DEATH EXPERIENCE AS …
Read full complaint
ON 3 DIFFERENT OCCASIONS, WHILE DRIVING THE CAR ON THE INTERSTATE HIGHWAY, IT STARTED VIBRATING, AND WOULD NOT ACCELERATE, BURNING SMELL OCCURRED, SEVERAL WARNING LIGHTS CAME UP ON THE DASHBOARD. WE HAD TO NAVIGATE THE CAR FROM THE MIDDLE OF HIGHWAY TO THE SHOULDER OF THE HIGHWAY VERY ABRUPTLY. IT WAS A NEAR DEATH EXPERIENCE AS SEVERAL TRUCKS AND CARS WERE TRAVELING ON THE HIGHWAY AT VERY FAST SPEEDS. REPORTED THE FIRST OCCURRENCE TO THE MCGRATH CITY HONDA, CHICAGO, IL IN JANUARY 2019 ALONG WITH THE DASHBOARD WARNING LIGHT PICTURES AND THEY REPLACED SOME FUEL SENSORS AND INFORMED ME THAT THIS WAS A MANUFACTURING ISSUE (DEFECTIVE PART). SECOND INCIDENT OCCURRED IN FEBRUARY 2019, COULD NOT TAKE PHOTOS AS THE PROBLEMS WENT AWAY AFTER RESTARTING THE ENGINE. REPORTED THE THIRD INCIDENT IN MARCH 2019 ALONG WITH THE DASHBOARD WARNING LIGHT PICTURES TO THE SAME DEALERSHIP AND I WAS INFORMED THAT THERE IS A PROBLEM WITH FUEL INJECTOR AND THEY PLACED THE ORDER FOR THE PART. WE ARE REALLY, REALLY SCARED OF DRIVING THIS DEFECTIVE, MALFUNCTIONING AND HAZARDOUS VEHICLE. I SEARCHED THE INTERNET LAST NIGHT AND IT SEEMS SEVERAL OTHER HONDA CRV OWNERS ARE HAVING THESE ISSUES. PLEASE INVESTIGATE THIS SERIOUS ISSUE AND SAVE THE PEOPLE.
NHTSA ODI #11192559
8,000 miles · Mar 10, 2019
Power TrainService Brakes
WHILE PERFORMING A STRAIGHT, SLOW SPEED STOP AT RED LIGHT IN CITY TRAFFIC, IN DRY WEATHER WITH NO ROAD DEBRIS, THE BRAKES FEEL SPONGY, LIKE THEY ARE NOT OPERATING AT FULL POWER, AND IS UNABLE TO STOP THE VEHICLE. PRESSING HARDER ON THE BRAKE PETALS CAUSES A LOUD RUMBLING NOISE FROM THE BRAKING SYSTEM THAT SOUNDS LIKE ABS SYSTEM…
Read full complaint
WHILE PERFORMING A STRAIGHT, SLOW SPEED STOP AT RED LIGHT IN CITY TRAFFIC, IN DRY WEATHER WITH NO ROAD DEBRIS, THE BRAKES FEEL SPONGY, LIKE THEY ARE NOT OPERATING AT FULL POWER, AND IS UNABLE TO STOP THE VEHICLE. PRESSING HARDER ON THE BRAKE PETALS CAUSES A LOUD RUMBLING NOISE FROM THE BRAKING SYSTEM THAT SOUNDS LIKE ABS SYSTEM ENGAGING. THE VEHICLE DOES COME TO A FULL STOP, BUT A LOW RUMBLING NOISE CONTINUES WHILE STOPPED. WHEN DRIVER RELEASES BRAKES, BEFORE PRESSING THE GAS PEDAL, THE VEHICLE LURCHES FORWARD ABRUPTLY AND RUMBLING NOISE STOPS. SUBSEQUENT OPERATION OF VEHICLE RETURNS TO NORMAL. THIS SEQUENCE OF BEHAVIOR OCCURS SPORADICALLY. IT HAS OCCURRED THREE TIMES IN THE LAST FOUR MONTHS. I TOOK THE VEHICLE TO A HONDA DEALERSHIP. INSPECTION BY A CERTIFIED MECHANIC DID NOT UNCOVER ANY CAUSE FOR THIS BEHAVIOR AND NO ERROR CODES ARE RECORDED IN THE VEHICLE'S COMPUTER. MECHANIC INDICATED THAT WITHOUT A RELIABLE WAY TO REPRODUCE THE FAULT, IT IS DIFFICULT TO KNOW WHAT WENT WRONG OR HOW TO FIX IT.
NHTSA ODI #11185601
4,525 miles · Mar 5, 2019
EngineFuel/propulsion SystemPower Train
WHEN DRIVING MY VEHICLE ON THE HIGHWAY, IT SHUT DOWN AND THE SERVICE ENGINE LIGHT CAME ON, IT HAD LOST ALL POWER AND IT HAD 4525 MILES ON IT. I WAS ON MY WAY TO TAKE IT UP FOR A RECALL FOR A SOFTWARE UPDATE WITH A/C CONTROL UNIT REPLACEMENT ; DTC P0300, P0301,P0302,P0303,P0304,OR P0172. I HAD TO CALL HONDA ROAD SIDE ASSISTANC…
Read full complaint
WHEN DRIVING MY VEHICLE ON THE HIGHWAY, IT SHUT DOWN AND THE SERVICE ENGINE LIGHT CAME ON, IT HAD LOST ALL POWER AND IT HAD 4525 MILES ON IT. I WAS ON MY WAY TO TAKE IT UP FOR A RECALL FOR A SOFTWARE UPDATE WITH A/C CONTROL UNIT REPLACEMENT ; DTC P0300, P0301,P0302,P0303,P0304,OR P0172. I HAD TO CALL HONDA ROAD SIDE ASSISTANCE AND MY VEHICLE WAS HAULED ON A FLAT BED TRAILER TO GET THE RECALL FIXED. THIS RECALL ALSO INVOLVED AN OIL CHANGE, OF WHICH THEY WERE MAKING THE CUSTOMER RESPONSIBLE TO PAY FOR THE FILTER, THEY WOULD CHANGE THE FILTER WITH THE OIL CHANGE, BUT NOT PAY FOR THE FILTER WHEN CHANGING THE OIL. THERE IS ALSO AN OIL DISILLUSION PROBLEM WITH THIS VEHICLE AS THERE IS GAS GOING INTO THE OIL CAUSING A GAS SMELL IN THE OIL AND THINNING OUT THE OIL. ALSO THERE IS A HEATING PROBLEM WITH THIS VEHICLE AS THERE IS NO HEAT WHICH COMES OUT OF THE BLOWERS, WHICH WHERE I LIVE IS VERY IMPORTANT TO HAVE FOR 6-9 MONTHS OUT OF THE YEAR. I WOULD RATHER NOT HAVE AIR CONDITIONING AS I CAN ROLL DOWN MY WINDOW TO GET COOLED OFF, BUT THERE IS ONLY ONE WAY I CAN GET HEAT IN MY CAR AND THAT IS FROM RUNNING THE ENGINE AND USING THE CLIMATE CONTROL IN THE CAR. IN COLD WEATHER STATES WHEN DRIVING THIS CAR IS NOT SAFE BECAUSE WHEN IT SHUTS DOWN AND ISN'T DRIVABLE AND THE CAR ISN'T ABLE TO PRODUCE HEAT WHEN YOU ARE STRANDED A PERSON COULD FREEZE TO DEATH BECAUSE OF THE CARS INABILITY TO PRODUCE HEAT WHILE STRANDED IN THE COLD WEATHER. MY OIL ALREADY SMELLS OF GAS AND I HAVE DRIVEN IT LESS THAN 700 MILES SINCE THE OIL CHANGE, THAT WAS PERFORMED WITH THE RECALL. I AM TAKING TO HONDA DEALER AGAIN FOR AN EXAM I WAS TOLD, TO CHECK OUT SPARK PLUGS AND X-RAY THEM AND ALSO FOR ANOTHER OIL CHANGE, WITH 5219 MILES ON CAR NOW, SO WITH LESS THAN 700 MILES FROM LAST OIL CHANGE I WILL NOW BE GETTING ANOTHER. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #11184408
Official recalls
5May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Mar 9, 2023
Honda (American Honda Motor Co.) is recalling certain 2017-2020 CR-V, 2018-2019 Accord and Accord Hybrid, 2018-2020 Odyssey, 2019 Insight, and 2019-2020 Acura RDX vehicles. A manufacturing issue with the front seat belts may cause the seat belt buckle channel to interfere with the release button, preventing the seat belt buckle from latching.
Consequence & remedy
Consequence: An unlatched seat belt cannot properly restrain the seat occupant during a crash, increasing their risk of injury.
Remedy: Dealers will replace the driver and front passenger seat belt buckle release buttons or the buckle assemblies as necessary, free of charge. Owner notification letters were mailed April 18, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are NDA, QDB, BDC, MDD, LD9. TDF, FDG, ODH, YDI, ZDE.
Mar 25, 2021
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Acura MDX, MDX Sport Hybrid, RDX, TLX, Honda Accord, Civic Hatchback, Insight, 2019 Acura ILX, Honda Accord Hybrid, Civic Coupe, Civic Coupe Si, Civic Sedan, Civic Sedan Si, Civic Type R, Fit, HR-V, Odyssey, Passport, Pilot and Ridgeline, and 2018-2019 CR-V vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the fuel pump assembly, free of charge. Owner letters were mailed May 18, 2021. Owners may contact Honda customer service at 1-888-234-2138. Note: This recall is an expansion of recall 20V-314.
Sep 27, 2018
Honda (American Honda Motor Co.) is recalling certain 2017-2018 Honda Civic and CR-V vehicles. The magnet that controls the torque sensor output signal for the electronic power steering system may not be properly secured, allowing the magnet to become dislodged. During a full lock turn, the dislodged magnet may cause steering assist to be applied in the opposite direction.
Consequence & remedy
Consequence: The unintended steering input reduces vehicle maneuverability and increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the steering gearbox assembly, free of charge. The recall began November 9, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are C2N, P2O.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA24002 · Inadvertent Automatic Emergency Braking
Opened Apr 15, 2024 · No close date supplied
Status: open (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking; Forward Collision Avoidance: Sensing System: Camera; Forward Collision Avoidance: Sensing System: Radar; Forward Collision Avoidance:software
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (5)
Forward Collision Avoidance: Automatic Emergency Braking
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance: Sensing System: Camera
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance: Sensing System: Radar
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance:software
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE22011 · Rear Differential Seizure
Opened Nov 28, 2022 · Closed Jul 22, 2024
Status: closed (inferred from source dates) · Power Train; Power Train:axle Assembly; Power Train:axle Assembly:axle Shaft; Power Train:axle Assembly:axle Shaft:seal; Power Train:driveline:differential Unit; Power Train:driveline:driveshaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Additional source detail variants (6)
Power Train:axle Assembly:axle Shaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:axle Assembly:axle Shaft:seal
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:axle Assembly
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:driveline:differential Unit
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:driveline:driveshaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
PE22003 · Inadvertent Automatic Emergency Braking
Opened Feb 21, 2022 · Closed Apr 18, 2024
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking; Forward Collision Avoidance: Sensing System: Camera; Forward Collision Avoidance: Sensing System: Radar; Forward Collision Avoidance:software
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (5)
Forward Collision Avoidance: Automatic Emergency Braking
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance: Sensing System: Camera
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance: Sensing System: Radar
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance:software
On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles. The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations. However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,081 consumer complaints of inadvertent activation of CMBS in the subject vehicles. A total of 24 complaints alleged a crash and 42 alleged an injury. The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources. In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged. In total, there were X,XXX reports, 84 injury incidents and 40 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22003 has been upgraded to an Engineering Analysis (EA24002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further the scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration