Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
Mileage unknown · Oct 31, 2002
Suspension
BIKE PULLS EXTREMLY HARD TO LEFT. COULD ONLY BE PARTIALLY SOLVED BY MOVING ENGINE OVER IN FRAME. CAN NOT BE TOLD BY DEALER OR HD IF THIS IS WITHIN FACTORY SPECS. HAVE HAD IN SEVERAL TIMES WITH NO RESOLVE. SPOKE WITH SOMEONE AT FACTORY AND WAS TOLD THIS IS NOT ACCEPTABLE AS ENGINE IS MOUNTED EXACTLY THE SAME EVERY TIME IN A JIG …
Read full complaint
BIKE PULLS EXTREMLY HARD TO LEFT. COULD ONLY BE PARTIALLY SOLVED BY MOVING ENGINE OVER IN FRAME. CAN NOT BE TOLD BY DEALER OR HD IF THIS IS WITHIN FACTORY SPECS. HAVE HAD IN SEVERAL TIMES WITH NO RESOLVE. SPOKE WITH SOMEONE AT FACTORY AND WAS TOLD THIS IS NOT ACCEPTABLE AS ENGINE IS MOUNTED EXACTLY THE SAME EVERY TIME IN A JIG AND MOVING ENGINE IS COMPENSATING FOR SOMETHING ELSE. DEALER HAS NEVER OPENED A WARRANTY TICKET WITH HD WHICH MAKES ME FEEL LIKE THEY ARE HIDING SOMETHING. THIS HAS BEEN GOING ON SINCE APRIL. HD HAS NO ANSWERS EITHER. I WANT TO MAKE SURE BIKE IS SAFE. DT
NHTSA ODI #769147
Mileage unknown · Jul 9, 2002
Vehicle Speed Control
DESIGN OF THROTTLE BODY IS NOT DONE PROPERLY, WHEN MOTORCYCLE VIBRATES THROTTLE BODY WILL COME LOOSE AND RPMS WILL START TO REV UP. CONTACTED DEALER.*AK HARLEY DAVIDSON IS AWARE OF THE PROBLEM AND HAS A REMEDY, THE ORIGINAL SCREWS ON THE THROTTLE BODY THAT HOLDS IT TO THE INTAKE MANIFOLD BREAK, OR VIBRATE OUT, CAUSING THROTTLE …
Read full complaint
DESIGN OF THROTTLE BODY IS NOT DONE PROPERLY, WHEN MOTORCYCLE VIBRATES THROTTLE BODY WILL COME LOOSE AND RPMS WILL START TO REV UP. CONTACTED DEALER.*AK HARLEY DAVIDSON IS AWARE OF THE PROBLEM AND HAS A REMEDY, THE ORIGINAL SCREWS ON THE THROTTLE BODY THAT HOLDS IT TO THE INTAKE MANIFOLD BREAK, OR VIBRATE OUT, CAUSING THROTTLE BODY TO SEPARATE FROM INTAKE, THIS CAUSES LARGE VOLUMES OF AIR TO ENTER ENGINE, INCREASING THE RPM TO OVER 4000, CONSUMER HAD TO USE THE IGNITION SWITCH TO SHUT THE MOTORCYCLE DOWN, THE ABOVE IS NOT THE OWNERS INFORMATION. *SLC
ON CERTAIN MOTORCYCLES, THE CLIPS THAT RETAIN THE WIRING FOR THE FRONT FENDER TIP LIGHT CAN BECOME DETACHED FROM THE FENDER, CAUSING THE WIRES TO FRAY AND SHORT.
Consequence & remedy
Consequence: THIS COULD CAUSE THE LIGHTING SYSTEM FUSE TO BLOW, LEAVING THE VEHICLE WITHOUT AN OPERATIONAL FRONT FENDER TIP LIGHT, HEADLIGHT, TAILLIGHT, RUNNING LIGHTS, AND PASSING LAMPS (IF EQUIPPED).
Remedy: DEALERS WILL REPLACE THE FENDER TIP LIGHT WIRING HARNESS RETENTION CLIPS, AND INSPECT AND REPLACE, IF NECESSARY, ANY DAMAGED WIRING HARNESSES. OWNER NOTIFICATION BEGAN JANUARY 9, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-342-4680.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 HARLEY-DAVIDSON Flhr Problems, Complaints & Recalls | Skip That Year
Illustration