IllustrationCONSUMER WAS DRIVING A 2005 INTERNATIONAL 9400I, BUT THE 2006 GREAT DANE TRAILER HE WAS TOWING HAD THE TIRE BLOW OUT. RIGHT REAR TIRE ON UNIT 1 BLEW. TIRE RE-TREAD FROM UNIT 1 STRUCK UNIT 2 GRILL. *BF (OHIO TRAFFIC CRASH POLICE REPORT # 10-078-90. *JB UPDATED 08/06/10 *BF
2006 Great Dane Trailer
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trailer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Equipment. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Tires complaints
1 reportsOfficial recalls
307V461000 · Trailer Hitches
Sep 28, 2007
ON CERTAIN TRAILERS, STAINLESS STEEL MOUNTING BOLTS OF A LESSER GRADE WERE USED IN LIEU OF THE STANDARD GRADE 8 CARBON STEEL BOLTS TO ATTACH THE PINTLE HOOKS.
Consequence & remedy
Consequence: THIS COULD RESULT IN SEPARATION OF THE TOWED VEHICLE FROM THE SEMI-TRAILER WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL THE GRADE 8 CARBON STEEL BOLTS IN ORDER TO INSURE THAT THE MOUNTING OF THE PINTLE HOOK MEETS THE REQUIRED RECOMMENDATIONS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT GREAT DANE AT 1-800-633-4176.
07V406000 · Service Brakes, Air:antilock
Sep 6, 2007
ON CERTAIN FEDERAL EXPRESS (FED-EX) TRUCKS EQUIPPED WITH HALDEX ANTILOCK BRAKE SYSTEM (ABS) ELECTRONIC CONTROL UNIT (ECU) VALVES, THE VALVES NEED TO BE MODIFIED IN ORDER TO RELOCATE THE VALVES IN AN UPRIGHT POSITION. THE VALVES CONTAIN A BALL SEAT PISTON THAT MAY BECOME DISLODGED DURING AN ABS EVENT AND NOT PERFORM PROPERLY.
Consequence & remedy
Consequence: DRIVERS WOULD NOT BE WARNED OF A BRAKE SYSTEM FAILURE INCREASING THE RISK OF A CRASH.
Remedy: GREAT DANE IS WORKING WITH FED-EX TO REPLACE THE ABS VALVES FREE OF CHARGE. FED-EX HAS DEAD-LINED THESE VEHICLES UNTIL THE REPAIR HAS BEEN PERFORMED.
05V493000 · Suspension
Oct 25, 2005
ON CERTAIN VAN AND REFRIGERATED SEMI-TRAILERS EQUIPPED WITH TUTHILL SUSPENSIONS, MODEL 20/22AR AND RS3162, THE BEAM/AXLE PIVOT CONNECTION JOINT IS MIS-ALIGNED CAUSING EXCESSIVE PLAY WITH THE TRAILER ALLOWING THE TRAILER TO WANDER.
Consequence & remedy
Consequence: SHOULD THE TRAILER WANDER A VEHICLE CRASH COULD OCCUR WITHOUT NOTICE.
Remedy: GREAT DANE IS WORKING WITH TUTHILL TO NOTIFY THE OWNERS OF THE AFFECTED VEHICLES AND PROVIDE FREE REMEDY. OWNERS MAY CONTACT TUTHILL AT 800-753-0025 OR GREAT DANE AT 912-644-2100.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.