IllustrationNoticed the left side of the 5th wheel seemed lower, the smell of burning rubber was highly present. Upon further investigation noticed the front axle leaf spring had broken. Noticed the new tire was hot and rubbed up on and caused damage to the metal of the chassis and ruined the new tire.
2017 Grand Design Reflection
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Reflection years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
125–50K
050–75K
075–100K
0100–150K
0150K+
23 reports with mileage · 2 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Equipment. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
Suspension complaints
5 reportsI WAS DRIVING IN ARKANSAS IN OCTOBER 11TH 2019 WHEN I NOTICED THE RV DID NOT APPEAR TO BE TRACKING STRAIGHT BEHIND THE TRUCK. I PACKED UP AND LEFT THE CAMPGROUND ABOUT 2 HOURS EARLIER. THERE WERE NO ISSUES WITH THE AXLES AT THAT TIME. THERE WERE NO UNUSUAL ROAD HAZARDS OR SHOCKS TO THE FRAME DURING THAT PERIOD PRIOR TO WHEN I…
Read full complaint
I WAS DRIVING IN ARKANSAS IN OCTOBER 11TH 2019 WHEN I NOTICED THE RV DID NOT APPEAR TO BE TRACKING STRAIGHT BEHIND THE TRUCK. I PACKED UP AND LEFT THE CAMPGROUND ABOUT 2 HOURS EARLIER. THERE WERE NO ISSUES WITH THE AXLES AT THAT TIME. THERE WERE NO UNUSUAL ROAD HAZARDS OR SHOCKS TO THE FRAME DURING THAT PERIOD PRIOR TO WHEN I NOTICED THE ISSUE. I STOPPED AT A REST AREA IN HELENA ARKANSAS AND FOUND THE RIGHT REAR AXLE SPRING HANGER HAD BROKEN FROM THE FRAME. THE SPRING AND REAR AXLE WAS SHIFTED TO THE LEFT AND LODGED PRECARIOUSLY UP INSIDE THE FRAME. IT WAS LATE ON A FRIDAY EVENING. I WAS ABLE TO FIND A TRUCK/TRAILER SHOP OPEN IN BATESVILLE, MISSISSIPPI. I DROVE THERE FOR EMERGENCY REPAIRS. THEY JUDGED THE FAILURE WAS DUE TO POOR WELDS. I'VE DONE SOME WELDING AND IT WAS EASY TO RECOGNIZE POOR PENETRATION. THE TRUCK SHOP WELDED THE HANGERS AND PULLED THE REAR AXLE AS CLOSE TO PROPER ALIGNMENT AS POSSIBLE. HOWEVER THE AXLE HAD SHIFTED SLIGHTLY IN THE U-BOLTS. THE U-BOLTS NEEDED TO BE CUT OFF, THE AXLE PROPERLY ALIGNED AND NEW U-BOLTS INSTALLED. THEY DID NOT STOCK THE BOLTS BUT THE TRAILER WAS SAFE TO TOW HOME. UPON RETURNING FROM THAT TRIP, I PUT THE TRAILER IN MY WAREHOUSE AND INSPECTED THE FRAME AND AXLES. I NOTICED IMMEDIATELY THE FRAME AT THE RIGHT REAR CORNER DIRECTLY BEHIND THE FAILED REAR AXLE SPRING HANGER HAD SEPARATED. THE EXTERIOR SHEET METAL IS WARPED AND THERE IS A VISIBLE GAP. THE FACTORY HAS REFUSED TO COVER THE AXLE REALIGNMENT OR RIGHT REAR FRAME SEPARATION UNDER THEIR 3-YEAR STRUCTURAL WARRANTY. MY RV HAS BEEN AT THE DEALER JUNE 5, 2020 UNTIL TODAY OCT 1 REGARDING THESE ISSUES AND AN UPPER DECK FRAME ISSUE THAT THEY FAILED TO REPAIR CORRECTLY 2 YEARS AGO.
THE RIGHT REAR LEAF SPRING HANGER FOR THE REAR AXLE BROKE OFF FROM THE TRAILER FRAME, THIS HAPPENED WHEN VEHICLE WAS IN MOTION ON THE HIGHWAY. NOTICED REAR AXLE OUT OF PLACE WHEN WE WERE PARKED IN OUR DRIVEWAY UPON FURTHER INSPECTION THAT IS WHEN WE NOTICED THE RIGHT REAR HANGER BROKEN COMPLETELY OUT OF FRAME AND THE LEFT REAR …
Read full complaint
THE RIGHT REAR LEAF SPRING HANGER FOR THE REAR AXLE BROKE OFF FROM THE TRAILER FRAME, THIS HAPPENED WHEN VEHICLE WAS IN MOTION ON THE HIGHWAY. NOTICED REAR AXLE OUT OF PLACE WHEN WE WERE PARKED IN OUR DRIVEWAY UPON FURTHER INSPECTION THAT IS WHEN WE NOTICED THE RIGHT REAR HANGER BROKEN COMPLETELY OUT OF FRAME AND THE LEFT REAR HANGER CRACKED.
WHEEL BEARING GREASE TOO THIN AND LEAKS PAST SEALS CONTAMINATING BRAKE MAGNETS AND BRAKES. MANY CUSTOMERS IMPACTED BASED ON FACEBOOK GROUP POSTS.
GREASE LEAKING FROM AXLE SEALS WITH EXTENSIVE CONTAMINATION OF BRAKES ON 2 OUT OF 4 WHEELS. A 3RD WHEEL IS JUST STARTING TO SHOW SIGNS OF GREASE LEAKING PAST SEAL WITH ONLY THE START OF CONTAMINATION OF BRAKE PAD. LIPPERT AXLE AND BRAKE ASSEMBLIES. APPROXIMATELY 3,420 MILES SINCE MANUFACTURE OF TRAILER IN JUNE 2016. SAFETY C…
Read full complaint
GREASE LEAKING FROM AXLE SEALS WITH EXTENSIVE CONTAMINATION OF BRAKES ON 2 OUT OF 4 WHEELS. A 3RD WHEEL IS JUST STARTING TO SHOW SIGNS OF GREASE LEAKING PAST SEAL WITH ONLY THE START OF CONTAMINATION OF BRAKE PAD. LIPPERT AXLE AND BRAKE ASSEMBLIES. APPROXIMATELY 3,420 MILES SINCE MANUFACTURE OF TRAILER IN JUNE 2016. SAFETY CONCERN IS LOSS OF BRAKING ABILITY ON A TRAILER WITH A GVWR OF 11,995 LBS. CONTAMINATION NOTED ON OCTOBER 30, 2016 WHEN OWNER PERFORMED INSPECTION OF AXLE AND BRAKE ASSEMBLIES AFTER LEARNING OF NUMEROUS OTHER OWNERS WITH SIMILAR ISSUES ON THE ONLINE GRAND DESIGN OWNERS FORUM.
Official recalls
522V038000 · Equipment:appliance:refrigerator
Jan 28, 2022
Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
Consequence & remedy
Consequence: An electrical arc increases the risk of a fire.
Remedy: Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.
20V362000 · Electrical System:wiring
Jun 19, 2020
Grand Design RV, LLC (Grand Design) is recalling certain 2016-2018 Reflection trailers. A wiring connector in the vehicle underbody may not be properly secured, allowing water intrusion into the wiring connector, possibly resulting in an electrical short circuit.
Consequence & remedy
Consequence: If water enters the wiring connector, it can cause a short circuit, increasing the risk of a fire.
Remedy: Grand Design will notify owners, and dealers will inspect and secure the wiring connectors up to prevent water intrusion, free of charge. This recall began June 29, 2020. Owners may contact Grand Design's customer service at 1-574-825-9679. Grand Design's number for this recall is 910020.
17V789000 · Equipment:mechanical:integrated Jack/leveler/stabilizer
Dec 8, 2017
Grand Design RV, LLC (Grand Design) is recalling certain 2017-2018 Reflection and Imagine travel trailers equipped with a Smart-Jack model power tongue jack. The laminated plastic touch pad on the jack may crack or separate allowing water to enter, potentially causing the jack to operate unintentionally.
Consequence & remedy
Consequence: If the tongue jack retracts or extends unexpectedly, there could be an increased risk of a crash or injury.
Remedy: Grand Design will notify owners, and dealers will replace the power tongue jack, free of charge. The recall began on December 29, 2017. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 900012.
16V717000 · Equipment:other:labels
Oct 7, 2016
Grand Design RV, LLC (Grand Design) is recalling certain model year 2015-2017 Reflection recreational trailers, model 357BHS and 367BHS, manufactured November 12, 2014, to September 22, 2016. The affected vehicles have an incorrect Gross Axle Weight Rating (GAWR) on the Federal Certification Label, stating a GAWR of 7,000 lbs when the actual GAWR is 6,400 lbs. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence & remedy
Consequence: If the operator loads the vehicle to the GAWR on the label, it can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Grand Design will notify owners, and dealers will install a corrected Federal Certification Label, free of charge. Owners will also have the option to replace the Certification Label themselves, free of charge. The recall began on October 28, 2016. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910007.
16V355000 · Equipment:recreational Vehicle/trailer:lpg Systems:lines And Fittings
May 25, 2016
Grand Design RV, LLC (Grand Design) is recalling certain model year 2016-2017 Imagine and Reflection recreational trailers manufactured January 15, 2016 to May 4, 2016. The MB Sturgis LP regulator on these vehicles may allow propane gas to leak into the regulator sight glass causing it to degrade and potentially crack.
Consequence & remedy
Consequence: If the indicator sight glass cracks, propane gas may leak out, increasing the risk of a fire.
Remedy: Grand Design will notify owners, and dealers will replace the LP regulator kit, free of charge. The recall began on June 6, 2016. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910006.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.