IllustrationA DEALERSHIP DIAGNOSED THAT RIGHT/ FRONT UPPER BALL JOINT HAS FAILED AND MUST BE REPLACED. ALSO, DEALERSHIP INFORMED CONSUMER THAT THIS VEHICLE WAS NOT AFFECTED BY ANY RECALL. CONSUMER MUST COVER ALL EXPENSES FOR REPLACEMENT OF THE BALL JOINTS. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION.*AK
1996 GMC Sonoma
Owner reports · Recalls · Investigations
More warning signs than most Sonoma years
Owner complaints for the 1996 GMC Sonoma are substantially higher than the model-year median of 57.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sonoma years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 12 of 148 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports1 fire reports4 injury reports
Suspension complaints
6 reportsBALL JOINTS BROKE TWICE WHILE DRIVING.*AK
DRIVERS SIDE UPPER BALL JOINT FAILED WHILE DRIVING. TRUCK PULLED IMMEDIATELY TO THE LEFT, NO ONCOMING VEHICLES. UPON FURTHER INSPECTION, BY TWO SEPERATE FACILITIES, ALL BALL JOINTS (UPPER/LOWER/DRIVERS SIDE/PASSENGERS SIDE) WERE FOUND TO BE DEFECTIVE. THESE PARTS ARE LUBERCATED (GREASED) 3-4 TIMES A YEAR, TYPICALLY EVERY OTHE…
Read full complaint
DRIVERS SIDE UPPER BALL JOINT FAILED WHILE DRIVING. TRUCK PULLED IMMEDIATELY TO THE LEFT, NO ONCOMING VEHICLES. UPON FURTHER INSPECTION, BY TWO SEPERATE FACILITIES, ALL BALL JOINTS (UPPER/LOWER/DRIVERS SIDE/PASSENGERS SIDE) WERE FOUND TO BE DEFECTIVE. THESE PARTS ARE LUBERCATED (GREASED) 3-4 TIMES A YEAR, TYPICALLY EVERY OTHER OIL CHANGE.
WHILE DRIVING ENGINE CHECK LIGHT FLASHES. THEN VEHICLE CUTS OFF, AND VEHICLE DRIFTS TO THE SIDE OF THE ROAD. *AK
THERE ARE NUMEROUS, SUBSTANTIAL SAFETY HAZARDS TO THESE VEHICLES WHICH APPEAR TO BE COMMON KNOWLEDGE TO MECHANICS BUT DENIED BY DEALERSHIPS. THE BALL JOINTS ARE APPARENTLY COMMON FAILURES ACCORDING TO MASSACHUSETTS SAFETY INSPECTORS AND ARE DEEMED TO BE AN EXTREME SAFETY HAZARD. THEY STATE THAT DEALERSHIPS REGULARLY DENY ANY RES…
Read full complaint
THERE ARE NUMEROUS, SUBSTANTIAL SAFETY HAZARDS TO THESE VEHICLES WHICH APPEAR TO BE COMMON KNOWLEDGE TO MECHANICS BUT DENIED BY DEALERSHIPS. THE BALL JOINTS ARE APPARENTLY COMMON FAILURES ACCORDING TO MASSACHUSETTS SAFETY INSPECTORS AND ARE DEEMED TO BE AN EXTREME SAFETY HAZARD. THEY STATE THAT DEALERSHIPS REGULARLY DENY ANY RESPONSIBILITY FOR THIS FAILURE. MY VEHICLE IS EXTREMELY WELL CARED FOR, NOT ABUSED IN ANY WAY, AND HAS EXPERIENCED DEFECTS, WHICH IN MY OPINION DEMONSTRATE GROSS NEGLIGENCE ON THE PART OF GMC'S ENGINEERING/PRODUCTION. I AM ALSO A PROFESSIONAL ENGINEER, AND PREPARED TO TESTIFY THE SAME. *AK
THE REAR LEAF SPRINGS ARE SAGGING.
Official recalls
699V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
97V146001 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Sep 11, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence & remedy
Consequence: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
97V096001 · Seat Belts
Jun 12, 1997
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
97V008001 · Visibility:windshield
Jan 27, 1997
THE TOP COAT PAINT SEVERELY PEELS DUE TO OVERBAKING OF THE POWDER PRIMER PRIOR TO THE TOP COAT APPLICATION. SINCE THE WINDSHIELD PRIMER AND ADHESIVE ADHERE TO THE TOP COAT PAINT ONTHE WINDSHIELD OPENING FLANGE, THE WINDSHIELD DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WINDSHIELD MAY NOT STAY IN PLACE AS REQUIRED BY FMVSS NO. 212.
Remedy: ALL VEHICLES HAVE BEEN REPURCHASED. THIS CAMPAIGN IS 100%.
96V035000 · Power Train:manual Transmission
Feb 22, 1996
SOME OF THESE TRUCKS WERE BUILT WITH TRANSMISSIONS CONTAINING PARTS WHICH WERE NOT MACHINED TO GM'S SPECIFICATIONS.
Consequence & remedy
Consequence: THESE TRANSMISSIONS COULD SEIZE AND LOCK THE REAR DRIVE WHEELS WHILE THE TRUCK IS BEING DRIVEN CAUSING A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION MAIN SHAFT OUTPUT TORQUE USING A SPECIAL TOOL. IF THE OUTPUT TORQUE DOES NOT MEET SPECIFICATIONS, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.