Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
1125–50K
2750–75K
1275–100K
20100–150K
5150K+
106 reports with mileage · 11 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports2 fire reports2 injury reports
What owners actually said
117 reports
62,749 miles · Oct 8, 2012
Seats
DRIVER SEAT HEATER TURNS ON BY ITSELF CREATING AN EXTREMELY UNSAFE DRIVING CONDITION IN THE SUMMERTIME IN HIGH DENSITY TRAFFIC WITH SUN GLARE A PROBLEM AND AN INABILITY TO EFFECTIVELY TURN THE SEAT HEATER OFF. THIS PROBLEM HAS BEEN REVIEWED BOTH BY THE LOCAL CHEVROLET AND GMC DEALERS WITH THE ULTIMATE CORRECTIVE ACTION BEING TO…
Read full complaint
DRIVER SEAT HEATER TURNS ON BY ITSELF CREATING AN EXTREMELY UNSAFE DRIVING CONDITION IN THE SUMMERTIME IN HIGH DENSITY TRAFFIC WITH SUN GLARE A PROBLEM AND AN INABILITY TO EFFECTIVELY TURN THE SEAT HEATER OFF. THIS PROBLEM HAS BEEN REVIEWED BOTH BY THE LOCAL CHEVROLET AND GMC DEALERS WITH THE ULTIMATE CORRECTIVE ACTION BEING TO DISCONNECT THE SEAT HEATING ELEMENTS. WHILE THIS ADDRESSES SAFETY FOR ME IT FALLS SHORT OF PROVIDING ME WITH A FUNCTIONING SEAT HEATER AS PURCHASED. ALSO THE CORRECTIVE ACTION DOES NOT GIVE CONSIDERATION TO A POTENTIALLY GENERAL EXISTING PROBLEM---WHICH IS THE MORE IMPORTANT REASON THAT I MAKE THIS REPORT. *TR
NHTSA ODI #10479265
55,833 miles · Aug 7, 2012
Service Brakes
VEHICLE WAS DRIVEN ON A DRIVEWAY AND THE BRAKE PEDAL LOST COMPLETE RESISTANCE AND WENT FLAT TO THE FLOOR. TOTAL BRAKE FAILURE OCCURRED WITHOUT ANY WARNING INDICATORS. INSPECTION OF THE METAL BRAKE LINES POSITIONED NEAR THE LEFT FRONT WHEEL REVEALED THAT ALL FOUR LINES SHOWED SEVERE SIGNS OF CORROSION AND ONE OF THE LINES HAD PR…
Read full complaint
VEHICLE WAS DRIVEN ON A DRIVEWAY AND THE BRAKE PEDAL LOST COMPLETE RESISTANCE AND WENT FLAT TO THE FLOOR. TOTAL BRAKE FAILURE OCCURRED WITHOUT ANY WARNING INDICATORS. INSPECTION OF THE METAL BRAKE LINES POSITIONED NEAR THE LEFT FRONT WHEEL REVEALED THAT ALL FOUR LINES SHOWED SEVERE SIGNS OF CORROSION AND ONE OF THE LINES HAD PRODUCED A HOLE THEREFORE LEAKING BRAKE FLUID. *TR
NHTSA ODI #10469546
63,520 miles · Jul 30, 2012
Engine
EXHAUST IN PASSENGER COMPARTMENT. SERVICE MAN INFORMED ME OF BROKEN BOLTS AND THAT I MUST REPLACE BOTH MANIFOLDS BEFORE NEXT INSPECTION. *TR
NHTSA ODI #10468287
55,437 miles · Jun 7, 2012
Service Brakes
THE PROBLEM IS A TOTALLY RUSTED-OUT SET OF STEEL BRAKE LINES THROUGHOUT THE GMC TRUCK. THE BURST BRAKE LINE IS IN THE ENGINE COMPARTMENT. IT IS THE LINE THAT RUNS FROM THE ANTILOCK BRAKE DISTRIBUTION POINT (ATTACHED TO THE FRAME BENEATH THE DRIVER SEAT). IT RUNS ALONG THE FRAME, ABOVE THE FRAME RAIL AND PAST THE STEERING BOX,…
Read full complaint
THE PROBLEM IS A TOTALLY RUSTED-OUT SET OF STEEL BRAKE LINES THROUGHOUT THE GMC TRUCK. THE BURST BRAKE LINE IS IN THE ENGINE COMPARTMENT. IT IS THE LINE THAT RUNS FROM THE ANTILOCK BRAKE DISTRIBUTION POINT (ATTACHED TO THE FRAME BENEATH THE DRIVER SEAT). IT RUNS ALONG THE FRAME, ABOVE THE FRAME RAIL AND PAST THE STEERING BOX, AND THEN MAKES A RIGHT TURN BENEATH THE RADIATOR TO THE PASSENGER SIDE OF THE TRUCK, WHERE IT EXITS INTO THE WHEEL WELL AND CONNECTS TO THE FLEXIBLE BRAKE HOSE ON THE PASSENGER SIDE. THE STEEL LINE BURST IN THE AREA ADJACENT TO THE STEERING BOX, SO THAT IT SPRAYS BRAKE FLUID ALL OVER THE STEERING BOX WHENEVER THE BRAKE PEDAL IS DEPRESSED. THIS QUICKLY EMPTIED THE RESERVOIR ON THE MASTER CYLINDER LEAVING ALMOST NO BRAKES AT ALL. THERE IS VERY MINIMAL BRAKING AVAILABLE WITH THE PEDAL FULLY DEPRESSED THE FLOOR. I INITIALLY EXAMINED THE SYSTEM TO SEE IF THERE IS ANY CHANCE OF A DO-IT-YOURSELF REPAIR BUT QUICKLY ABANDONED THAT IDEA. ALL OF THE BRAKE LINES ARE BADLY CORRODED AND COVERED WITH SCALE, SO THERE IS NO CHANCE OF CUTTING OUT THE BAD SEGMENT, DOUBLE FLARING THE ENDS, AND SPLICING-IN A SHORT SEGMENT TO REPLACE THE RUSTED-OUT PORTION OF THE BRAKE LINE. ALL OF THE BRAKE LINES THROUGHOUT THE TRUCK ARE BADLY RUSTED AND LIKELY WILL FAIL AGAIN IF LEFT IN PLACE (ACCORDING TO THE GMC SERVICE MANAGER). THE BRAKE LINE THAT FAILED BURST IN A PART OF THE ENGINE COMPARTMENT THAT WOULD SEEM TO NOT EVEN BE EXPOSED TO ROAD SALT, SINCE IT IS INSIDE THE ENGINE COMPARTMENT AND RELATIVELY SHIELDED FROM SALT SPRAY AND ROAD GRIME BY THE BODY, WHEEL WELL AND FRAME RAIL. THE DEALER SERVICE MANAGER IN MURPHY, NC ESTIMATES THAT IT WILL TAKE ONE OF HIS MECHANICS ALMOST A FULL DAY TO REMOVE ALL OF THE BAD BRAKE LINES AND FABRICATE REPLACEMENTS (THESE LINES ARE NOT AVAILABLE IN PREFABRICATED FORM FROM GMC. *JS
NHTSA ODI #10460887
132,000 miles · Jan 9, 2012
Visibility
TL* THE CONTACT OWNS A 2005 GMC SIERRA. WHILE PARKED WITH THE IGNITION TURNED OFF, THE CONTACT NOTICED THAT THE BLOWER MOTOR WOULD NOT SHUT OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT STATED THERE WAS A MANUFACTURER'S RECALL FOR THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND …
Read full complaint
TL* THE CONTACT OWNS A 2005 GMC SIERRA. WHILE PARKED WITH THE IGNITION TURNED OFF, THE CONTACT NOTICED THAT THE BLOWER MOTOR WOULD NOT SHUT OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT STATED THERE WAS A MANUFACTURER'S RECALL FOR THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE MANUFACTURER'S RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 132,000.
NHTSA ODI #10442890
72,000 miles · Jan 5, 2012
Service Brakes, HydraulicSuspension
TL* THE CONTACT OWNS A 2005 GMC SIERRA 2500HD. THE CONTACT STATED THAT WHEN ATTEMPTING TO BRAKE AT LOW SPEEDS, THE FRONT END WOULD SHAKE AND THE BRAKING DISTANCE WOULD INCREASE. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD PULL TOWARD THE RIGHT WHEN THE FAILURE OCCURRED. AN AUTHORIZED DEALER STATED THAT THIS WAS A KNOWN FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2005 GMC SIERRA 2500HD. THE CONTACT STATED THAT WHEN ATTEMPTING TO BRAKE AT LOW SPEEDS, THE FRONT END WOULD SHAKE AND THE BRAKING DISTANCE WOULD INCREASE. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD PULL TOWARD THE RIGHT WHEN THE FAILURE OCCURRED. AN AUTHORIZED DEALER STATED THAT THIS WAS A KNOWN FAILURE, BUT THIS YEAR, MAKE AND MODEL WAS NOT RECALLED. THE FAILURE AND CURRENT MILEAGES WERE 72,000. UPDATED 02/09/12*LJ THE FRONT WHEEL BEARING ASSEMBLY AND SENSOR WERE REPLACED. UPDATED 02/13/12
NHTSA ODI #10442566
55,000 miles · Dec 28, 2011
Electrical System
GOT INTO VEHICLE ON 12/24/2011. WHEN I STARTED IT, I NOTICED AN ODOMETER ERROR. STILL NOT WORKING. *TR
NHTSA ODI #10441537
65,500 miles · Nov 27, 2011
Electrical System
SPEEDOMETER AND OIL PRESSURE GAUGE FAILURE.... SPEEDOMETER STUCK AT 120 OR O. OIL PRESSURE GAUGE STUCK TO FURTHEST POSSIBLE LEVEL. *TR
NHTSA ODI #10437386
73,000 miles · Nov 15, 2011
Structure
UNDER CARRIAGE OF TRUCK IS COMPLETELY RUSTED. FRAME, BRAKE LINES, LEAF SPRINGS, BASICALLY EVERYTHING. FUEL TANK LOOKS AS IF MIGHT BREAK OFF AND FALL TO GROUND AT ANY MOMENT AND LEAF SPRING SHACKLES LOOK AS IF MIGHT BREAK AND SPLIT TRUCK IN HALF. ALL DANGEROUS AND SHOULD BE RECALLED. *TR
NHTSA ODI #10435639
47,000 miles · Oct 14, 2011
Service Brakes, Hydraulic
I HAVE A 2005 GMC SIERRA. WHILE DRIVING ON DRY ROADS AND BRAKING AT LOW SPEEDS THE ABS ABNORMALLY ACTIVATES WITH OUT WARRANT. THIS ONLY HAPPENS AT LOW SPEEDS AND HAS ALMOST CAUSED ME TO HAVE SEVERAL ACCIDENTS. I CALLED THE GM DEALER TO SEE IF THERE IS A RECALL ON THIS AND THEY TOLD ME THERE WAS NOT AND I COULD BRING IT IN TO H…
Read full complaint
I HAVE A 2005 GMC SIERRA. WHILE DRIVING ON DRY ROADS AND BRAKING AT LOW SPEEDS THE ABS ABNORMALLY ACTIVATES WITH OUT WARRANT. THIS ONLY HAPPENS AT LOW SPEEDS AND HAS ALMOST CAUSED ME TO HAVE SEVERAL ACCIDENTS. I CALLED THE GM DEALER TO SEE IF THERE IS A RECALL ON THIS AND THEY TOLD ME THERE WAS NOT AND I COULD BRING IT IN TO HAVE IT LOOKED AT AND REPAIRED AT MY EXPENSE. I SEE THERE ARE OTHER COMPLAINTS HERE AT THE NHTSA FOR THE SAME THING. SEARCHING THE INTERNET I FOUND THERE ARE ALOT OF PEOPLE WITH THE SAME PROBLEM AND THAT GM HAS DONE A RECALL ON 1999-2002 VEHICLES. I ALSO FOUND THAT GM KNOWS THEY STILL HAVE A PROBLEM WITH THERE ABS BECAUSE THEY HAVE PUT OUT A TSB # 03-05-25-007D ON IT, AND THE NHTSA HAS IT LISTED ON THERE BULLETIN SECTION. IT IS NHTSA BULLETIN #10004310. *TR
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 GMC Sierra Problems, Complaints & Recalls | Skip That Year
Illustration