IllustrationWENT TO STOP AT STOP SIGN, BRAKES FELT SPONGY. STOPPED UP THE ROAD ABOUT 2 MILES AT MY MOMS HOUSE TO GET MY KIDS, LOOKED UNDER THE TRUCK AND SAW BRAKE FLUID DRIPPING DOWN ON THE LEFT SIDE OF THE FRAME BEHIND THE LEFT FRONT WHEEL.I HAVE TO REPLACE ALL OF MY BRAKE LINES NOW DUE TO RUST. *TR
2005 GMC Sierra
Owner reports · Recalls · Investigations
More warning signs than most Sierra years
Owner complaints for the 2005 GMC Sierra are substantially higher than the model-year median of 53.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sierra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
1125–50K
2750–75K
1275–100K
20100–150K
5150K+
106 reports with mileage · 11 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports2 fire reports2 injury reports
What owners actually said
117 reportsTL* THE CONTACT OWNS A 2005 GMC SIERRA. THE CONTACT STATED THAT THE DRIVER SIDE AIR BAG DEPLOYED WHEN THE VEHICLE WAS SHUT OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.
WHEN TRYING TO EXIT HIGHWAY OFFRAMP BRAKES COMPLETELY FAILED DUE TO BRAKE LINES RUSTING THROUGH. VEHICLE WAS BROUGHT TO A STOP WITH PARKING BRAKE. *TR
I WAS TRAVELING AT 35 MPH AND APPROACHED A STOP LIGHT. THE BRAKES FAILED AND I WENT THROUGH THE RED LIGHT. I NEARLY WAS HIT BY ONCOMING TRAFFIC. THE BRAKE LINE HAS A SEVER LEAK AT A RUSTED AREA IN THE LINE. *TR
AROUND THE MIDDLE OF DECEMBER 2014 THE "SERVICE BRAKE SYSTEM" MESSAGE APPEARED ON MY 2005 GMC 1500 SIERRA SLE. I CHECKED THE BRAKE FLUID RESERVOIR AND IT WAS NEARLY EMPTY. I COULD NOT FIND WHERE THE FLUID HAD LEAKED FROM SO I SERVICED THE RESERVOIR WITH 12 OUNCES BRAKE FLUID TO THE FULL MARK. FROM ABOUT DECEMBER 15, 2014 UNTI…
Read full complaint
AROUND THE MIDDLE OF DECEMBER 2014 THE "SERVICE BRAKE SYSTEM" MESSAGE APPEARED ON MY 2005 GMC 1500 SIERRA SLE. I CHECKED THE BRAKE FLUID RESERVOIR AND IT WAS NEARLY EMPTY. I COULD NOT FIND WHERE THE FLUID HAD LEAKED FROM SO I SERVICED THE RESERVOIR WITH 12 OUNCES BRAKE FLUID TO THE FULL MARK. FROM ABOUT DECEMBER 15, 2014 UNTIL 28 DECEMBER 2014, I LOST ABOUT 7 OUNCES OF BRAKE FLUID. NO TRACE OF BRAKE FLUID CAN BE FOUND ON THE DRIVEWAY. I CRAWLED UNDER THE TRUCK AND HAD MY WIFE PRESS THE BRAKES WHILE I LOOKED FOR A LEAK. I FOUND THE LEAK NEAR THE LEFT REAR WHEEL AREA ON A VERY CORRODED BRACKET. IT APPEARS TO BE A VERY SMALL HOLE BECAUSE THE FLUID COMES OUT AS A FINE MIST AND NOT A STREAM. THE RIGID BRAKE LINE CONNECTS TO A FLEXIBLE BRAKE LINE AT THE BRACKET AND THERE IS A LOT OF RUST AT THE CONNECTION AS WELL AS THE BRAKE LINE. I HAVE FOUND RUST FORMING ON OTHER BRAKE LINES AS WELL. *TR
ENGINE HAS LOSE OF ENGINE COOLANT OVER TIME WITH NO EVIDENCE OF LEAKS FOUND. WE BROUGHT THE TRUCK TO A GM DEALER WHICH TOLD US THIS WAS A KNOWN DEFECT ISSUE. THEY PROVIDED US WITH BULLETIN # 06-06-01-019B DOCUMENT ID 1986750 WHICH CLEARLY STATE THIS WAS DEFECT IN THE CASTING OF THE CASTECH HEADS. THE COST WITH PARTS AND LABOR IS…
Read full complaint
ENGINE HAS LOSE OF ENGINE COOLANT OVER TIME WITH NO EVIDENCE OF LEAKS FOUND. WE BROUGHT THE TRUCK TO A GM DEALER WHICH TOLD US THIS WAS A KNOWN DEFECT ISSUE. THEY PROVIDED US WITH BULLETIN # 06-06-01-019B DOCUMENT ID 1986750 WHICH CLEARLY STATE THIS WAS DEFECT IN THE CASTING OF THE CASTECH HEADS. THE COST WITH PARTS AND LABOR IS $3,100.00 DOLLARS. CLEARLY, GM SHOULD COVER THIS COST SINCE THIS OBVIOUSLY IS A KNOWN DEFECT. SEARCHING THE INTERNET YOU CAN SEE A LARGE NUMBER OF PEOPLE EXPERIENCING THIS ISSUE WITH LITTLE OR NO HELP FROM GM. *TR
THE VEHICLE WAS PURCHASED NEW AND HAS BEEN REGULARLY MAINTAINED. THE BRAKE LINES AND FRAME ARE HEAVILY CORRODED. WHILE PULLING OUT OF A PARKING SPOT ON 10/26/14 BRAKES WERE APPLIED ABRUPTLY WHICH CAUSED A RUPTURE OF THE CORRODED BRAKE LINES. ALL BRAKE LINES WILL NEED TO BE REPLACED IN ORDER TO SAFELY RETURN THE VEHICLE TO SER…
Read full complaint
THE VEHICLE WAS PURCHASED NEW AND HAS BEEN REGULARLY MAINTAINED. THE BRAKE LINES AND FRAME ARE HEAVILY CORRODED. WHILE PULLING OUT OF A PARKING SPOT ON 10/26/14 BRAKES WERE APPLIED ABRUPTLY WHICH CAUSED A RUPTURE OF THE CORRODED BRAKE LINES. ALL BRAKE LINES WILL NEED TO BE REPLACED IN ORDER TO SAFELY RETURN THE VEHICLE TO SERVICE. OTHER FAMILY MEMBERS HAVE 2004 CHEVY YUKON AND 1994 GMC 2500, BOTH VEHICLES HAD BRAKE LINES FAIL DUE TO CORROSION AND REQUIRED COMPLETE REPLACEMENT IN ORDER TO SAFELY RETURN THE VEHICLES TO SERVICE. THIS IS A SERIOUS SAFETY CONCERN AND THESE BRAKE LINE FAILURES ARE NOT NORMAL WEAR AND TEAR. I HAVE HAD SEVERAL VEHICLES MUCH OLDER THAN THIS VEHICLE WHICH STILL HAVE STOCK BRAKE LINES WITH NO CORROSION. *TR
MY SPEEDOMETER RECENTLY MALFUNCTIONED AT AROUND 77,000 MILES AND I BROUGHT IT TO THE ATTENTION OF THE DEALERSHIP'S SERVICE MANAGER, JEFF BEVINGTON, AT RALLY GMC AUTO GROUP IN PALMDALE, CA (WHERE I PURCHASED THE VEHICLE NEW IN 2005). I WAS GIVEN SERVICE BULLETIN #07187C - SPECIAL COVERAGE ADJUSTMENT INSTRUMENT PANEL CLUSTER GAUGE…
Read full complaint
MY SPEEDOMETER RECENTLY MALFUNCTIONED AT AROUND 77,000 MILES AND I BROUGHT IT TO THE ATTENTION OF THE DEALERSHIP'S SERVICE MANAGER, JEFF BEVINGTON, AT RALLY GMC AUTO GROUP IN PALMDALE, CA (WHERE I PURCHASED THE VEHICLE NEW IN 2005). I WAS GIVEN SERVICE BULLETIN #07187C - SPECIAL COVERAGE ADJUSTMENT INSTRUMENT PANEL CLUSTER GAUGE NEEDLE FUNCTION (MARCH 20, 2009), WHICH INDICATES THE FOLLOWING: THIS BULLETIN IS BEING REVISED TO INCLUDE CERTAIN 2005 MODEL YEAR VEHICLES IN THE U.S. ADDITIONALLY, FOR U.S. 2003-2005 MODEL YEAR VEHICLES, GM WILL PROVIDE THE INSTRUMENT PANEL CLUSTER (IPC) ONLY, AT NO CHARGE TO THE CUSTOMER FOR VERIFIED FAILURES BETWEEN 70,001 MILES (110,001 KM) AND 80,000 MILES (130,000 KM). ANY ADDITIONAL COSTS, INCLUDING LABOR TO REPLACE THE INSTRUMENT PANEL CLUSTER, WILL BE THE RESPONSIBILITY OF THE CUSTOMER. DEALERS WILL BE RESPONSIBLE FOR THE RETURN OF THE CUSTOMER'S IPC BACK TO THE ELECTRONIC SERVICE CENTER. PLEASE DISCARD ALL COPIES OF BULLETIN 01787B, ISSUED SEPTEMBER 2008. THE VIN BREAKOUTS OF VEHICLES INVOLVED IN THE BULLETIN INCLUDE 2005 GMC SIERRA BETWEEN 51100001 AND 51347001. HOWEVER, JEFF BEVINGTON TOLD ME THAT SINCE MY VEHICLE IS OLDER THAN 7 YEARS AND OVER 70,000 MILES, IT IS NOT COVERED??? HE SUGGESTED I CALL THE GM TOLL FREE NUMBER (800) 222-1020 AND ASK IF THEY CAN HELP. I CALLED AND SPOKE TO DONTES WHO TOLD ME THAT GM HAS NO RECORD OF THE SERVICE BULLETIN MENTIONED ABOVE??? *TR
POWER STEERING STOPS WORKING ON SLOW RIGHT HAND TURNS. I SOMETIMES NEED TO BACK UP IN ORDER TO COMPLETE THE TURN. I ALSO END UP CROSSING INTO ONCOMING LANES IF NO TRAFFIC IS COMEING TOWARDS ME. IF THERE IS TRAFFIC I NEED TO STOP IN THE MIDDLE OF THE TURN UNTIL THE TRAFFIC CLEARS. THE "CHECK AIRBAG" LIGHT CAME ON AT 85000 MILES …
Read full complaint
POWER STEERING STOPS WORKING ON SLOW RIGHT HAND TURNS. I SOMETIMES NEED TO BACK UP IN ORDER TO COMPLETE THE TURN. I ALSO END UP CROSSING INTO ONCOMING LANES IF NO TRAFFIC IS COMEING TOWARDS ME. IF THERE IS TRAFFIC I NEED TO STOP IN THE MIDDLE OF THE TURN UNTIL THE TRAFFIC CLEARS. THE "CHECK AIRBAG" LIGHT CAME ON AT 85000 MILES AFTER THE BATTERY DISCHARGED FROM THE VEHICLE SITTING TO LONG WITHOUT BEING DRIVEN. *TR
AT ANY RATE OF SPEED TRUCK WILL GO INTO REDUCED ENGINE POWER MUST PULL OVER OUT OF TRAFFIC AND KILL ENGINE WAIT A COUPLE OF MINUTES AND THEN RESTART SOMETIMES YOU CAN GO 1 MILE TILL HAPPENS AGAIN SOMETIMES 50 MILES VERY DANGEROUS SITUATION IN HEAVY TRAFFIC. *TR
Official recalls
906V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
06V289000 · Engine And Engine Cooling
Aug 3, 2006
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
05V455000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Oct 5, 2005
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
05V161000 · Parking Brake
Apr 22, 2005
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
05V163000 · Seat Belts:rear/other
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
05V055000 · Power Train:manual Transmission:shift Pattern Indicator
Feb 14, 2005
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
05V043000 · Service Brakes, Hydraulic
Feb 8, 2005
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
05V018000 · Steering:gear Box:shaft Sector
Jan 21, 2005
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
04V376000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Aug 2, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.