2022 GMC Sierra 3500

While driving on the interstate we were exiting to pull into a rest area while slowing down the rear wheels momentarily locked up and the truck downshifted hard and abruptly with that happening the check engine light came on along with a decreased power message. We pulled into a parking spot during so we tried to shift into reverse and it didn’t want to shift into reverse, we tried this for a while. We finally got it into reverse and we were able to back out of the parking spot. When we tried shifting to drive we encountered the same issue. The vehicle did not want to go into drive. Once finally into drive it did not want to shift into any higher gears. It was essentially stuck in one of the gears. We made it to a GMC dealer on the next exit -we drove on the side of the interstate to get there- when we arrived we had them run the codes and they told us it was a transmission control valve which GMC has had a major recall on. While we had this “fixed” at a different dealership previously in march of 2025 it only entailed “updating the software” involving the transmission control valve. We had to leave the truck at the GMC dealer that we were able to ‘limp’ to in Crestview FL. We’ve been told our truck now needs an entirely new transmission that is going to cost $7,000. We had a similar issue right after the “software update for the transmission control valve” on march 20, 2025. The software was updated roughly a week before that incident which seemed to have cleared itself because it was momentarily and never happened again until now. Our safety was at risk because we had to drive on the side of the interstate to get to a shop because we were out of town and a tow truck was going to cost between 600-1000 dollars to get home.

The contact owns a 2022 GMC Sierra 3500. The contact stated that while driving at 30 MPH, the message “Trailer Brake Disconnected" was displayed on the instrument panel. The contact was hauling a 5th-wheel trailer during the failure. The contact pulled over to the side of the road, turned off the vehicle, and waited for several minutes before restarting the vehicle. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that the failure persisted. Most recently, while driving 55 MPH, the message "Trailer Brake Disconnected" was displayed. The contact pulled over to the side of the road, turned off the vehicle, and waited before restarting the vehicle and continuing driving. The contact stated that before the most recent failure, the vehicle was taken to the dealer and the trailer plug was replaced. The vehicle was not diagnosed or repaired after the most recent failure. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 21V758000 (SERVICE BRAKES, HYDRAULIC); however, the VIN was not included. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was approximately 30,000.

The tire Goodyear LT275/65R20 are the original tires on the truck when purchased. The tires have been rotated and balanced at the dealership routinely, approximately 42,000 miles on the set. On [XXX], I was travelling [XXX] here in NC when I felt a bump as if I had hit something in the road. I pulled off to the shoulder to inspect for damage or a flat tire. The left rear tire had completely lost its tread, only the steel belts were showing. Thus caused significant damage to the fender and tailgate of the truck. The tire remained inflated. Another driver pulled over in front of me and stated that the separated part had damaged his car. The NC State patrol was called and a report made for insurance. No one was injured to my knowledge. I changed the tire and was able to complete my trip. This could have caused a serious problem with a very serious accident. Fortunately, no one was injured. There were no warning that this might happen. I have sent pictures of the damage to my truck to the insurance company. This makes me very uneasy about these tires, I may need to purchase an entirely new set of tires from another manufacturer. I am not sure Goodyear is a decent brand of tire. The police report number is [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• What component or system failed or malfunctioned, and is it available for inspection upon request? The issue appears to be with the gear shifter assembly and/or park position sensor within the power train system. The vehicle fails to detect that it is in “Park,” even when the gear lever is physically in the Park position. Yes, the vehicle and component are available for inspection upon request. ⸻ • How was your safety or the safety of others put at risk? This malfunction prevents the vehicle from shutting off properly and displays a “Shift to Park” message even when parked. This creates a risk of the vehicle rolling away if the parking brake is not engaged and prevents secure shutdown, potentially draining the battery or creating confusion in an emergency. It compromises both driver and public safety. ⸻ • Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the issue was reproduced and acknowledged by a certified GMC dealership service department. They noted it is a known issue affecting other GM vehicles but stated there is no open recall or warranty extension currently available for my specific model. ⸻ • Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has only been inspected by a GMC-certified dealership. No inspection has been conducted by the manufacturer, police, or insurance representatives at this time. ⸻ • Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes, a “Shift to Park” message appears on the dash even when the shifter is correctly placed in the Park position. This message began appearing intermittently and has now become a consistent issue over the past few weeks.

The contact owns a 2022 GMC Sierra 3500. The contact stated that while driving at unknown speeds, the transmission downshifted hard. The contact stated that the transmission failed to properly shift gear. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 24V797000 (Power Train); however, the VIN was not included. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 117,000.

LT275/65R20. We were traveling about 74 mph on Hwy 90 going westbound, when suddenly we heard an explosion and noticed pieces of the passenger rear tires coming apart. It was about 90 degrees when we were on the road, and I had checked the tire pressure earlier that day, and it was at the recommended tire pressure. At no point during our trip was there a low-pressure warning or we did not hit any object on the road. We would have had a severe accident if the tire had been on the front. The tread seems to have separated from the tire, causing major damage to the truck bed. The tire was manufactured in week 20 of 2022, and it still had a good amount of tread remaining. I do have front and rear dashcam footage available.

The GM N242454440 “collision Rear Wheel Lock Up from Transmission Valve Failure” was performed. The recall rendered the electrical charging system inoperable. GM engineering has been working on the vehicle for more than one month and recently determined that the recall software does not work properly with all vehicles. My truck is being returned to me without the recall being performed. Accordingly the safety hazard associated with rear wheel lockup has not been addressed and cannot be addressed at this time. Presumably GM will develop software in the future to address the safety condition. Meanwhile the safety hazard remains unaddressed for my vehicle and an unknown number others. Reference Riverview Chevrolet GMC repair order 894074

The transmission failed which stemmed from the faulty (recently recalled valve body). General Motors has been contacted and there is no transmission in sight and is not able to provide an ETA. They are also not willing to cover the catastrophic failure because I am outside of my warranty terms. The dealership has inspected and concluded a whole new transmission is recommended. The vehicle has been in their possible for nearly one (1) month.

The contact owns a 2022 GMC Sierra 3500. The contact stated while the vehicle was parked, the trailer plug was connected, and electrical fuses popped. The contact stated that all the fuses were blown. In addition, the contact stated while driving the vehicle, the trailer brakes failed to function as intended. The contact stated that the trailer brakes went off and on. The vehicle was taken to the dealer where it was diagnosed with trailer brake control module failure. The contact was informed that the trailer brake control module needed to be replaced. The vehicle was repaired. The contact referenced an unknown recall; however, the VIN was not included in the recall. Additionally, the contact stated that the failure had previously occurred, and an unknown part was replaced; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 31,308.