Several months ago while having my truck serviced, I asked the repair shop to inspect the ball joints on the passenger side because they would make a popping noise when turning the wheel. The shop inspected them and said that was a normal sound due tot he factory lift. Recently I was driving home and about to turn into my lane w…
Read full complaint
Several months ago while having my truck serviced, I asked the repair shop to inspect the ball joints on the passenger side because they would make a popping noise when turning the wheel. The shop inspected them and said that was a normal sound due tot he factory lift. Recently I was driving home and about to turn into my lane when the front passenger wheel assembly collapsed under the truck due to the a upper ball joint failure separating the brake line and loss of steering. At the time, I was only going about 25mph and the truck slid to a stop on its own. The truck has 65,000 miles on it and if this had happen at highway speeds personal injury to myself and others would have been likely. The repair cost were $7,500. Fortunately I purchased an extended warranty which covered all but $1,700 of the repair.
NHTSA ODI #11758525
Mileage unknown · Feb 17, 2026
SteeringSuspension
While driving 13-15mph down the road the front right upper control arm ball bearing sheared off causing the tire to lean in rubbing the wheel well, forcing my truck to veer to the left across the other lane of traffic. Luckily there wasn't any car next to me.
NHTSA ODI #11718386
71,000 miles · Dec 27, 2024
Suspension
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving at 10 MPH, the upper control arm and ball joint on the passenger’s side fractured, and the wheel partially detached from the vehicle and was sticking out. The vehicle was towed to an independent mechanic where it was diagnosed and the failure was confirmed…
Read full complaint
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving at 10 MPH, the upper control arm and ball joint on the passenger’s side fractured, and the wheel partially detached from the vehicle and was sticking out. The vehicle was towed to an independent mechanic where it was diagnosed and the failure was confirmed; additionally, the driver’s side upper control arm and ball joint were also fractured. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mile was approximately 71,000.
NHTSA ODI #11632770
70,000 miles · Aug 21, 2024
SteeringSuspension
The contact owns a 2019 GMC Sierra 1500. The contact stated that while his wife was driving 25 MPH, the vehicle made an abnormally loud sound and the front driver's side wheel detached. The vehicle came to a complete stop. The vehicle was towed to the dealer, where it was diagnosed that the upper control arm had disconnected fro…
Read full complaint
The contact owns a 2019 GMC Sierra 1500. The contact stated that while his wife was driving 25 MPH, the vehicle made an abnormally loud sound and the front driver's side wheel detached. The vehicle came to a complete stop. The vehicle was towed to the dealer, where it was diagnosed that the upper control arm had disconnected from the steering wheel ball joint, and it was determined that the upper control joint, steering wheel column, and front driver's and passenger's side wheel needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle had received an alignment twenty days prior to the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000.
NHTSA ODI #11609898
Mileage unknown · May 17, 2023
Suspension
I was driving the vehicle heard a loud thumping sound got out to look and the driver side tire was nearly off the vehicle! Had I been driving on the highway I could've been killed/seriously injured by loss of control by way of steering. It looks like the upper control arm completely seperated from the tire at the ball joint caus…
Read full complaint
I was driving the vehicle heard a loud thumping sound got out to look and the driver side tire was nearly off the vehicle! Had I been driving on the highway I could've been killed/seriously injured by loss of control by way of steering. It looks like the upper control arm completely seperated from the tire at the ball joint causing the tire to fall away from the vehicle. There is a current recall out there for this make, year, and model. The vehicle has been inspected by the manufacturer. No warning lamps or messages have appeared.
NHTSA ODI #11522486
Mileage unknown · May 8, 2023
Suspension
Driver's side front wheel assembly separated from the vehicle. It was hard to tell exactl what happened but I am told that it may have been a ball joint failure. I was driving in the middle lane on the highway with cruise control set to 70MPH. All of a sudden, my truck jumped up and my truck starting pushing towards the left m…
Read full complaint
Driver's side front wheel assembly separated from the vehicle. It was hard to tell exactl what happened but I am told that it may have been a ball joint failure. I was driving in the middle lane on the highway with cruise control set to 70MPH. All of a sudden, my truck jumped up and my truck starting pushing towards the left median. I thought I had a tire blow out. Luckily there wasn't anyone in the left lane at the time and I was able to get to the grassy left median. If there was another vehicle in the left lane and or if the left median wasn't grass, this would have caused a major accident as I has no control over where the truck was going. When I got out I saw that my entire wheel had separated from the vehicle and it was on its face under the truck. I did not hit a pothole. There was no prior indication that anything was wrong with the assembly. A tow truck was called and brought the truck back to their shop. The assembly had to be replaced, (ball joint, axel, steering control arms etc.). I called my local GMC dealer and they have nothing being reported of this issue but when I looked online I've seen multiple reports of premature failures of ball joints. Total repairs so far have been $3,400.00 and I still need to replace a cracked rim. Repairs will be over $4,000 when all said and done.
NHTSA ODI #11520900
Mileage unknown · Apr 18, 2023
Suspension
At 50,000 miles the upper control arm/ball joint on the driver side came apart with no warning causing considerable damage to the suspension, tires, wheel, and front bumper. About two months before at approximately 48,000 miles the passenger side control arm/ball joint came apart again with no warning. Warranty has just elapse…
Read full complaint
At 50,000 miles the upper control arm/ball joint on the driver side came apart with no warning causing considerable damage to the suspension, tires, wheel, and front bumper. About two months before at approximately 48,000 miles the passenger side control arm/ball joint came apart again with no warning. Warranty has just elapse and GM has denied any responsibility and will not cover any of the repairs. This could have easily been catastrophic if we would have been on the freeway. This is a Safety issue! This truck has the aluminum upper control arms which my opinion for what its worth is the problem. I have no clue at this time how we are going to be able to fix this. Even when it is fixed we will never trust it.
NHTSA ODI #11517636
Mileage unknown · Jul 10, 2022
Suspension
Ball joint separated from control arm while driving. Vehicle was undrivable had to be towed.
NHTSA ODI #11473184
43,000 miles · Apr 18, 2022
Suspension
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving 65 MPH, the front driver’s side tire detached from the vehicle. The contact stated there was no warning light illuminated. The contact was able to park on the side of the road and noticed that the ball joint had separated from the A-arm. The vehicle was no…
Read full complaint
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving 65 MPH, the front driver’s side tire detached from the vehicle. The contact stated there was no warning light illuminated. The contact was able to park on the side of the road and noticed that the ball joint had separated from the A-arm. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the front driver’s side tire, ball joint, and the upper A-arm to be replaced. The vehicle was not repaired but was pending repairs. The manufacturer had not been informed of the failure. The failure mileage was approximately 43,000.
NHTSA ODI #11461128
1,100 miles · Mar 2, 2020
Electrical SystemPower TrainSuspension
TRANSMISSION SLIPPING TURNING CORNERS AT 5 MPH, TRANSMISSION SLIP TAKE OFF AT HILL STOP SIGN, TRANSMISSION HARD SHIFT 2ND TO 3RD GEAR INTERMITTED AND VIBRATION 45 MPH TO 55 MPH
General Motors (GM) is recalling certain 2019-2021 GMC Sierra 1500 and Silverado 1500 vehicles equipped with certain accessory road tires and a 17" spare tire. The 17" spare tire provided with the vehicle is not compatible for use with the accessory wheels, which can cause the anti-lock brake system (ABS) to not function properly under certain conditions.
Consequence & remedy
Consequence: An ABS system that does not function properly can increase the risk of a crash.
Remedy: Dealers will provide a new 17" spare tire and wheel assembly that is compatible with the accessory wheels, free of charge. Dealers will also apply a new spare tire information label, and provide owners with an owner's manual insert clarifying which spare tire to use with the accessory road tires and with the 17" original tires. Owner notification letters were mailed February 7, 2022. Owners may contact GM customer service at 1-800-462-8782 or GMC customer service at 1-800-462-8782. GM's number for this recall is N212346510.
General Motors, LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The affected tires were cured for too long during production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers inspect and replace the tires as necessary, free of charge, free of charge. Owner notification letters were mailed on June 25, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N212336230.
Additional source detail variants (2)
Tires:sidewall
General Motors, LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The affected tires were cured for too long during production.
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers inspect and replace the tires as necessary, free of charge, free of charge. Owner notification letters were mailed on June 25, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N212336230.
Tires
General Motors, LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The affected tires were cured for too long during production.
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers inspect and replace the tires as necessary, free of charge, free of charge. Owner notification letters were mailed on June 25, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N212336230.
General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC Acadia, Sierra 1500, and certain Continental tires sold to the aftermarket for various model year 2018-2021 vehicles. The affected tires were cured for too long during production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021. Owners may contact GMC customer service at 1-888-988-7267, Buick customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212329050.
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Consequence & remedy
Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Additional source detail variants (2)
Seat Belts:critical Fasteners
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Seat Belts
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 and 2020 Chevrolet Silverado 2500 trucks. One of the driveshaft joints may not have been properly welded, causing the driveshaft to separate while the vehicle is moving.
Consequence & remedy
Consequence: If the driveshaft separates, there may be a loss of propulsion, increasing the risk of crash.
Remedy: GM will notify owners, and dealers will replace the driveshaft, free of charge. The recall is expected to begin December 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N202314870.
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. These vehicles received updated software for the Electronic Brake Control Module (EBCM). This software has an error, and as a result, the vehicle's electronic brake assist may be disabled. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: A loss of electronic brake assist can increase the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 24, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268091.
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 trucks. The battery positive (B+) cable rings may have been manufactured with excessive glue, potentially causing an intermittent electrical connection between the B+ cable and alternator.
Consequence & remedy
Consequence: An intermittent electrical connection between the B+ battery cable and the alternator could cause the vehicle to stall, increasing the risk of a crash. The intermittent connection could also lead to electrical arcing, which could generate sufficient heat to damage surrounding material, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will inspect for the presence of glue or other contamination at the B+ cable attachment to the alternator and clean the connection and reattach the B+ cable connection, as necessary. If arcing has damaged the cable, nut, or alternator, the dealer will replace the damaged components. All services will be performed free of charge. GM issued owners an interim notification on February 4, 2020. GM issued second notice and the recall began March 9, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192273510.
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:abs Warning Light
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2020 Silverado 2500, Silverado 3500, Sierra 2500, and Sierra 3500 vehicles equipped with carpet floor covering. When the front seat belt pretensioners deploy, hot gas may vent through an opening in the pretensioner bracket, possibly igniting the carpet.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: GM will notify owners, and dealers will close off the opening in the pretensioner bracket, free of charge. The recall began December 13, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192270600.
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 Crew Cab and GMC Sierra 1500 Crew Cab vehicles. The passenger-side frontal air bag module may have been damaged during assembly, possibly resulting in the air bag not inflating properly in the event of a crash.
Consequence & remedy
Consequence: In the event of a crash, an air bag that does not inflate properly can increase the risk of injury.
Remedy: GM will notify owners, and dealers will replace the passenger side air bag module, free of charge. The recall began on December 18, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N182198820.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2019 GMC Sierra 1500 Problems, Complaints & Recalls | Skip That Year
Illustration