NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
8 reportsClear category filter40,000 miles · Apr 17, 2026
EnginePower TrainService Brakes, Hydraulic
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving approximately 5 MPH, the rear wheels locked up. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the brakes needed to be replaced. The vehicle was repaired; however, t…
Read full complaint
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving approximately 5 MPH, the rear wheels locked up. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the brakes needed to be replaced. The vehicle was repaired; however, the failure recurred intermittently. The vehicle was taken to another local dealer, Walker Bros Chevrolet (700 Erie St, Edinboro, PA 16412); for a second opinion, and the transmission and TCM were replaced. The vehicle was repaired; however, the failure reoccurred. Upon further investigation, the contact related the failure to the Customer Satisfaction Program: N192272400; however, the VIN was not included. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 40,000.
NHTSA ODI #11731897
42,320 miles · Apr 3, 2026
Service Brakes, Hydraulic
The contact's partner owns a 2019 GMC Sierra 1500. The contact stated that upon starting the vehicle, the "Service Brake System" and ABS warning lights illuminated. The brake pedal was depressed to the floorboard, and the message that the vehicle would not exceed 62 MPH was displayed. The vehicle was restarted, and several unkno…
Read full complaint
The contact's partner owns a 2019 GMC Sierra 1500. The contact stated that upon starting the vehicle, the "Service Brake System" and ABS warning lights illuminated. The brake pedal was depressed to the floorboard, and the message that the vehicle would not exceed 62 MPH was displayed. The vehicle was restarted, and several unknown warning lights were illuminated with a message that the vehicle would not accelerate above 42 MPH. The vehicle was taken to a dealer, where a diagnostic test was performed and the diagnostic test revealed that the brake pipe had seized in the brake master cylinder and that the pipe fitting threads were damaged. The contact was informed that the brake master cylinder and the reservoir seal needed to be replaced. Despite the repair, the dealer stated that the master cylinder and brake line fitting were still defective. After several additional repairs to the brake system, the vehicle was returned to the owner. Upon driving the vehicle, the contact stated that the prior brake warning lights returned on the instrument panel. The vehicle was returned to the dealer and remained with the dealer. Upon investigation, the contact discovered NHTSA Campaign Number: 20V055000 (Service Brakes, Hydraulic); and associated the failure with the recall. The manufacturer was notified of the failure, and the contact was informed that the vehicle was not included in the recall. The contact was then given a case number. The contact was also transferred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was 42,320.
NHTSA ODI #11729002
68,000 miles · Feb 25, 2026
Service Brakes, Hydraulic
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and the brakes seized. No warning lights were illuminated. The contact parked the vehicle. The contact inspected the vehicle; however, the failure reoccurred. The contact attempted to drive the v…
Read full complaint
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and the brakes seized. No warning lights were illuminated. The contact parked the vehicle. The contact inspected the vehicle; however, the failure reoccurred. The contact attempted to drive the vehicle several times, but the failure reoccurred. The contact stated that the failure was persistent. Due to the failures, the contact was almost in two crashes. The vehicle was towed to an independent mechanic, where it was diagnosed with a brake module reset. The independent mechanic contacted the dealer and was informed that the brake module needed to be reset. The technician from the dealer installed the software for the brake module reset, and the vehicle was repaired. The vehicle was retrieved, but the failure reoccurred a month later. The vehicle was towed to the dealer, and the contact was informed that the vehicle needed to be inspected by the engineer. The vehicle was not diagnosed or repaired. The contact was advised to continue driving the vehicle. The contact was advised to disable all the safety features. The contact stated that two major crashes were averted and refused to drive the vehicle until it was repaired. The contact stated that the failure was common with the vehicle. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 68,000.
NHTSA ODI #11720355
7,000 miles · Feb 18, 2025
Electronic Stability Control (esc)Service BrakesService Brakes, Hydraulic
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving approximately 20 MPH, the vehicle came to a screeching stop. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the electronic brake control module had short-circuited and there was a miscommuni…
Read full complaint
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving approximately 20 MPH, the vehicle came to a screeching stop. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the electronic brake control module had short-circuited and there was a miscommunication, which engaged the parking brake and locked up the rear wheels. The vehicle was not repaired. The vehicle was previously taken to the same dealer on two occasions and repaired under NHTSA Campaign Number: 19V889000 (SERVICE BRAKES, HYDRAULIC, SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC); however, the failure recurred. The manufacturer was contacted and opened a case, but no additional assistance was provided. The failure mileage was approximately 7,000.
NHTSA ODI #11643365
85,502 miles · Apr 18, 2024
Electronic Stability Control (esc)Service Brakes, Hydraulic
The contact owns a 2019 GMC Sierra 1500. The contact stated while making a left turn, the steering wheel was yanked to the left. The contact stated that the "Service ESC and Power Steering" message was displayed. The vehicle was taken to the residence. On another occasion, the following day while making a right turn, the steerin…
Read full complaint
The contact owns a 2019 GMC Sierra 1500. The contact stated while making a left turn, the steering wheel was yanked to the left. The contact stated that the "Service ESC and Power Steering" message was displayed. The vehicle was taken to the residence. On another occasion, the following day while making a right turn, the steering wheel was yanked to the right. Additionally, the contact stated that the steering wheel was firm and difficult to turn. The contact stated that a "Service ESC and Power Steering" message was displayed. The vehicle was steered to the side of the road. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. The contact believed that the failure was associated with NHTSA Campaign Number: 19V889000 (Service Brakes, Hydraulic, Service Brakes, Electronic Stability Control (ESC). The manufacturer was notified of the failure. The failure mileage was 85,502.
NHTSA ODI #11583826
133,000 miles · Jun 28, 2023
Electronic Stability Control (esc)Service BrakesService Brakes, Hydraulic
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving 45 MPH, the vehicle started to decelerate independently, and the steering wheel became difficult to turn. The contact stated that several unknown warning lights were illuminated. The contact was able to park the vehicle safely off the highway. The vehicle …
Read full complaint
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving 45 MPH, the vehicle started to decelerate independently, and the steering wheel became difficult to turn. The contact stated that several unknown warning lights were illuminated. The contact was able to park the vehicle safely off the highway. The vehicle was not drivable. The contact towed the vehicle first to his residence and then the following day to an independent mechanic and was informed that the Electronic Brake Control Module (EBCM) needed to be replaced. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 19V889000 (Service Brakes, Hydraulic, Service Brakes, Electronic Stability Control) however, the VIN was not included. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 133,000.
NHTSA ODI #11529427
13,000 miles · Feb 8, 2022
Electrical SystemService Brakes, Hydraulic
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the battery was draining quickly and was replaced. The vehicle was taken to the dealer, but the dealer could not duplicate the failure. The vehicle was then taken to an…
Read full complaint
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the battery was draining quickly and was replaced. The vehicle was taken to the dealer, but the dealer could not duplicate the failure. The vehicle was then taken to an independent mechanic and diagnosed with brake system failure. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the dealer for diagnostic testing. The failure mileage was approximately 13,000.
NHTSA ODI #11450961
8,000 miles · Apr 15, 2020
Service BrakesService Brakes, HydraulicCrash
DRIVING MY 2019 SIERRA ON A SLIGHTLY SNOW COVERED ROAD APPLIED BRAKES AND TRUCK PULLED TO THE RIGHT AND ANTILOCK BRAKES NEVER WORKED CAUSING ME TO HIT GUARD RAIL. CALLED INSURANCE TALKED WITH DEALER ABOUT WHAT HAPPENED THEY SAID TO CONTACT GM CUSTOMER SERVICE. HAD MY WRECKED TRUCK FIXED AND WHEN GM GOT BACK TO ME THEY SAID THERE…
Read full complaint
DRIVING MY 2019 SIERRA ON A SLIGHTLY SNOW COVERED ROAD APPLIED BRAKES AND TRUCK PULLED TO THE RIGHT AND ANTILOCK BRAKES NEVER WORKED CAUSING ME TO HIT GUARD RAIL. CALLED INSURANCE TALKED WITH DEALER ABOUT WHAT HAPPENED THEY SAID TO CONTACT GM CUSTOMER SERVICE. HAD MY WRECKED TRUCK FIXED AND WHEN GM GOT BACK TO ME THEY SAID THERE WAS NOTHING ELSE THEY COULD DO BECAUSE I CONTACTED MY INSURANCE INSTEAD OF DEALERSHIP???? NOW I HAVE RECEIVED ANOTHER RECALL NOTICE TELLING ME MY BRAKES ARE NOT RESPONDING PROPERLY. GUESS I NEED A LAWYER I DON'T KNOW. *TR
NHTSA ODI #11321245
Official recalls
10Dec 16, 2021
General Motors (GM) is recalling certain 2019-2021 GMC Sierra 1500 and Silverado 1500 vehicles equipped with certain accessory road tires and a 17" spare tire. The 17" spare tire provided with the vehicle is not compatible for use with the accessory wheels, which can cause the anti-lock brake system (ABS) to not function properly under certain conditions.
Consequence & remedy
Consequence: An ABS system that does not function properly can increase the risk of a crash.
Remedy: Dealers will provide a new 17" spare tire and wheel assembly that is compatible with the accessory wheels, free of charge. Dealers will also apply a new spare tire information label, and provide owners with an owner's manual insert clarifying which spare tire to use with the accessory road tires and with the 17" original tires. Owner notification letters were mailed February 7, 2022. Owners may contact GM customer service at 1-800-462-8782 or GMC customer service at 1-800-462-8782. GM's number for this recall is N212346510.
Jun 3, 2021
General Motors, LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The affected tires were cured for too long during production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers inspect and replace the tires as necessary, free of charge, free of charge. Owner notification letters were mailed on June 25, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N212336230.
Additional source detail variants (2)
Tires:sidewall
General Motors, LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The affected tires were cured for too long during production.
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers inspect and replace the tires as necessary, free of charge, free of charge. Owner notification letters were mailed on June 25, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N212336230.
Tires
General Motors, LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The affected tires were cured for too long during production.
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers inspect and replace the tires as necessary, free of charge, free of charge. Owner notification letters were mailed on June 25, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N212336230.
Feb 25, 2021
General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC Acadia, Sierra 1500, and certain Continental tires sold to the aftermarket for various model year 2018-2021 vehicles. The affected tires were cured for too long during production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021. Owners may contact GMC customer service at 1-888-988-7267, Buick customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212329050.
Dec 17, 2020
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Consequence & remedy
Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Additional source detail variants (2)
Seat Belts:critical Fasteners
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Seat Belts
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Oct 22, 2020
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 and 2020 Chevrolet Silverado 2500 trucks. One of the driveshaft joints may not have been properly welded, causing the driveshaft to separate while the vehicle is moving.
Consequence & remedy
Consequence: If the driveshaft separates, there may be a loss of propulsion, increasing the risk of crash.
Remedy: GM will notify owners, and dealers will replace the driveshaft, free of charge. The recall is expected to begin December 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N202314870.
Jan 30, 2020
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. These vehicles received updated software for the Electronic Brake Control Module (EBCM). This software has an error, and as a result, the vehicle's electronic brake assist may be disabled. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: A loss of electronic brake assist can increase the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 24, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268091.
Dec 12, 2019
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 trucks. The battery positive (B+) cable rings may have been manufactured with excessive glue, potentially causing an intermittent electrical connection between the B+ cable and alternator.
Consequence & remedy
Consequence: An intermittent electrical connection between the B+ battery cable and the alternator could cause the vehicle to stall, increasing the risk of a crash. The intermittent connection could also lead to electrical arcing, which could generate sufficient heat to damage surrounding material, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will inspect for the presence of glue or other contamination at the B+ cable attachment to the alternator and clean the connection and reattach the B+ cable connection, as necessary. If arcing has damaged the cable, nut, or alternator, the dealer will replace the damaged components. All services will be performed free of charge. GM issued owners an interim notification on February 4, 2020. GM issued second notice and the recall began March 9, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192273510.
Dec 12, 2019
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:abs Warning Light
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Nov 14, 2019
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2020 Silverado 2500, Silverado 3500, Sierra 2500, and Sierra 3500 vehicles equipped with carpet floor covering. When the front seat belt pretensioners deploy, hot gas may vent through an opening in the pretensioner bracket, possibly igniting the carpet.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: GM will notify owners, and dealers will close off the opening in the pretensioner bracket, free of charge. The recall began December 13, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192270600.
Dec 6, 2018
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 Crew Cab and GMC Sierra 1500 Crew Cab vehicles. The passenger-side frontal air bag module may have been damaged during assembly, possibly resulting in the air bag not inflating properly in the event of a crash.
Consequence & remedy
Consequence: In the event of a crash, an air bag that does not inflate properly can increase the risk of injury.
Remedy: GM will notify owners, and dealers will replace the passenger side air bag module, free of charge. The recall began on December 18, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N182198820.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration