Engine And Engine CoolingEquipmentPower TrainCrash
WHILE DRIVING AT APPROX 15 MPH PREPAIRING TO STOP, WEATHER CONDITION WAS DRY, REAR ENDED VEHICLE IN FRONT. WENT TO APPLY BRAKES, HEARD NOISE ,NO REACTION, NO SKID MARKS FROM WHEELS. DEALERSHIP CANNOT FIND PROBLEM. CHANGED BRAKEPADS AND SHOES/ROTORS/MASTER CYLINDER. THIS DEFECT CAN RESULT IN AN ACCIDENT. *AK SERPENTINE BELT R…
Read full complaint
WHILE DRIVING AT APPROX 15 MPH PREPAIRING TO STOP, WEATHER CONDITION WAS DRY, REAR ENDED VEHICLE IN FRONT. WENT TO APPLY BRAKES, HEARD NOISE ,NO REACTION, NO SKID MARKS FROM WHEELS. DEALERSHIP CANNOT FIND PROBLEM. CHANGED BRAKEPADS AND SHOES/ROTORS/MASTER CYLINDER. THIS DEFECT CAN RESULT IN AN ACCIDENT. *AK SERPENTINE BELT REPLACED DUE TO CAUSING NOISE. TRANSMISSION SLIPPING, DEALER FOUND NO PROBLEMS. FRONT BRAKES WORN TO SENSORS, DEALER HAS REPLACED REAR BRAKE DRUMS REPLACED, FRONT CALIPER DRAGGING. CONSUMER STATES FROST COMING OUT OF VENTS AT TIMES. OIL PRESSURE DISPLAY UNSTABLE AND INTERMITTENT, DEALER REPLACED OIL PRESSURE SENDING UNIT REPLACED. WIND NOISE AROUND DRIVER DOOR. *SLC
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence & remedy
Consequence: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence & remedy
Consequence: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Illustration